2004 BMW 3 Series Electrical System

TL* THE CONTACT OWNED A 2004 BMW 325I. THE CONTACT STATED THAT WHILE PARKED AT A FUELING STATION AND WHEN EXITING THE STORE NOTICED SMOKE EXITING THE TRUNK OF THE VEHICLE. THE CONTACT USED THE KEY FOB TO OPEN THE TRUNK OF THE VEHICLE AND SAW THAT TRUNK WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT AND POLICE DEPARTMENT WERE CALLED FOR ASSISTANCE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE AND POLICE REPORT WERE FILED. THE FIRE DEPARTMENT STATED THAT THE FIRE WAS NOT DUE TO OPERATOR INVOLVEMENT AND WAS CAUSED BY AN ELECTRICAL FAILURE. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS TOWED TO A TOW YARD. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT RECEIVED A LETTER FROM THE MANUFACTURER WHICH STATED THAT THE FAILURE WAS POSSIBLY DUE TO RODENT INTRUSION IN THE VEHICLE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. *LN *DL

THE ADAPTIVE HEADLIGHTS ARE FLICKERING (STATIONARY OR IN MOTION). THIS POINTS TO A FAULTY WIRING ISSUE, ACCORDING TO MANY OTHER OWNERS REPORTING THIS ON INTERNET FORUMS FOR THIS VEHICLE.

VEHICLE ADAPTIVE XENON HEADLIGHT WIRING IS FAULTY . WIRE INSULATION IS CRACKING/DETERIORATING AND ENTIRE WIRES ARE BREAKING APART. SYMPTOMS START WITH FLICKERING XENON HEADLIGHT EVENTUALLY (ABOUT A WEEK LATER) STOPS WORKING AT ALL. VEHICLE IS MOVING OR STATIONARY, ENGINE ON. THE FAULTY WIRES ARE IN A WEATHER SEALED COMPARTMENT OF THE HEADLIGHT AND HAVE NEVER (TO MY KNOWLEDGE) EVEN BEEN UNSEALED/ACCESSED SINCE LEAVING THE FACTORY. THE ISSUE IS ON THE PASSENGER SIDE, UNKNOWN IF IT IS ON THE DRIVER SIDE AS WELL. THE ATTACHED PHOTO SHOWS BACK SIDE OF THE HEADLIGHT HOUSING LOOKING DOWN, WITH THE WEATHER-SEALED COMPARTMENT OPEN. ALL EXPOSED WIRE IS AS A RESULT OF THE ISSUE, NOBODY HAS ACTIVELY CUT OR STRIPPED THE WIRES. PROBLEM FIRST NOTICED IN SEPT OF 2016, ATTEMPTS WERE MADE TO REPAIR BUT NOW IT HAS HAPPENED AGAIN, WORSE.

VEHICLE HAD BEEN SITTING PARKED FOR SEVERAL WEEKS, LOW BATTERY 9.8 VOLTS. SPONTANEOUSLY HEADLIGHTS CAME ON SMOKE FILLED CAR, DOORS WOULD NOT UNLOCK MANUALLY OR BY REMOTE. SHATTERED DOOR GLASS WITH FIRE EXTINGUISHER . CLOSE INSPECTION APPEARS FAULTY HEADLIGHT SWITCH STARTED FIRE HAD 8 TO 10" FLAMES COMING OUT OF LEFT DASHBOARD. DAMAGE TO HDLT SWITCH,VENTS,DASH,CLUSTER,A PILLAR COVER. PUT OUT FIRE MYSELF SO NO FIRE DEPT. REPORTS.

MY VEHICLE UNEXPECTEDLY STARTED ON FIRE AS MY DAUGHTER WAS DRIVING TO SCHOOL. IT WAS DETERMINED THAT IT WAS AN ELECTRICAL FIRE, AND RESULTED IN THE CAR BEING TOTALED. THE 2004 MODELS NEED TO BE INCLUDED IN THE RECALL (NOT THAT IT WILL HELP WITH THE LOSS OF MY CAR).

HEADLIGHT WIRING JACKETS FLAKED OFF. HAD THE BALLAST AND BULB REPLACED IN PASSENGER SIDE HEADLIGHT, BECAUSE THE HEADLIGHT NO LONGER WORKED. NOTICED THAT THE WIRING WAS BARE & LOOKED LIKE SOMEONE HAD CLIPPED 2 OF THE WIRES. AFTER REPLACING BOTH THE BALLAST & HEADLIGHT IT STILL DID NOT WORK. BUT A COUPLE OF DAYS AFTER, TURNED ON THE HEADLIGHTS AND NOW IT WORKS AGAIN. I KNOW THIS IS NOT SAFE, I SEE WHERE OTHERS HAVE HAD THE SAME ISSUE. NOT SURE HOW TO GET THE NEW WIRING FOR THE HEADLIGHT OR DOES THE WHOLE THING NEED REPLACED? IT SHOULD BE A RECALL WITH THIS MANY CARS HAVING THE SAME ISSUE.

IGNITION SYSTEM: VEHICLE WILL COMPLETELY STALLED WHILE IN MOTION AT LOW AND HIGH VELOCITY SPEED. HAD TO COMPLETELY TURN THE IGNITION TO OFF POSITION TO BE ABLE TO RESTART. I HAVE BEEN KEEPING TRACK ON HOW OFTEN THIS HAPPENS. SO FAR 11 TIMES SINCE OWNERSHIP.

I WAS NOT ABLE TO UNLOCK MY CAR WITH MY CAR KEY. I WAS ABLE TO HEAR THE CLICK SOUND ON PRESSING THE UNLOCK BUTTON ON THE KEY BUT NOTHING WAS HAPPENING. AFTER NUMEROUS ATTEMPTS FOR ABOUT 10 MINUTES CAR GOT UNLOCKED. NOW I'M HAVING THIS PROBLEM ON/OFF BASIS. I TOOK THE CAR TO THE LOCAL BMW DEALER. AFTER DIAGNOSE THEY SAID I HAVE A FAILED GENERAL MODULE WHICH WILL COST ME AROUND $1000. THIS IS WAY TOO MUCH FOR CAR FOR IT'S TOTAL VALUE OF AROUND $7000. THIS IS SCARY SINCE I'M NOT ABLE TO TRUST THE LOCKING SYSTEM ON MY CAR. SOMETIME I'M NOT ABLE TO LOCK AT ALL AND AT SOMETIME I'M NOT ABLE TO UNLOCK ANYTHING. *TR

THE POWER DOOR LOCK ON PASSENGER SIDE CANNOT BE UNLOCKED EITHER VIA REMOTE OR INSIDE BUTTON. WORSE, OFTEN WHEN THIS HAPPENS, THE DOOR CANNOT BE OPENED EVEN BY PULLING ON THE HANDLE FROM THE INSIDE! A PASSENGER CANNOT GET OUT OF THE CAR VIA THE DOOR. FURTHERMORE, REPEATEDLY ATTEMPTS TO HAVE THIS FIXED ALL FAIL WITHIN A SHORT TIME.

ALL DOORS, WITH THE EXCEPTION OF DRIVERS DOOR, ARE UNABLE TO OPEN MANUALLY INSIDE AND OUTSIDE. CANNOT USE ALARM OR UNLOCK BUTTON TO OPEN EITHER. THIS IS OF GREAT CONCERN CONSIDERING I HAVE TWO YOUNG CHILDREN UNDER MY CARE. *TR

CANNOT OPEN THE 3 PASSENGER DOORS FROM INTERIOR. PASSENGERS CANNOT EXIT THE CAR. *TR

SECURITY LOCK SYSTEM FAILED TO ALLOW PASSENGERS TO EXIT THE VEHICLE. THE DOORS WOULD NOT UNLOCK AND THE PASSENGERS HAD TO CLIMB OUT OF THE WINDOWS TO EXIT. IF THERE WERE AN EMERGENCY (E.G. CAR DROVE INTO DEEP WATER) THE WINDOWS WOULD NOT FUNCTION AND THERE WOULD HAVE BEEN NO WAY TO EXIT THE CAR. SEEM LIKE A SERIOUS FAILURE. *TR

TL* THE CONTACT OWNS A 2004 BMW 325CI. THE CONTACT STATED THAT SHE NOTICED THERE WAS A LEAK FROM UNDER THE FRONT OF THE VEHICLE. THE CONTACT THEN ATTEMPTED TO START THE VEHICLE BUT TO NO AVAIL. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY ADVISED HER THAT THE BATTERY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 63,000.

THE VEHICLE HAD BEEN PARKED APPROXIMATELY 15-20 MINUTES WHEN WE WERE ALERTED BY THE FIRE ALARM IN OUR CONDO BUILDING. UPON EVACUATING THE BUILDING, WE WERE TOLD THAT OUR 2004 BMW 325I WAS ON FIRE. WE STILL HAVE NOT BEEN GIVEN ANY SPECIFIC CAUSE FOR THE FIRE, EXCEPT THAT IT WAS PROBABLY ELECTRICAL IN NATURE. SPECIAL AGENTS FROM OUR INSURANCE COMPANY WERE ALSO CALLED IN, WHO, IN TURN, CALLED IN TWO MORE EXPERTS. EVIDENCE WAS BAGGED AND THE CAR WAS SHRINK WRAPPED TO BE TAKEN TO A LOT WITH AT LEAST THREE OTHER BMW'S WHICH HAD ALSO CAUGHT FIRE WHILE PARKED. THIS IS ONE OF THE MOST FRIGHTENING THINGS TO EVER HAPPEN TO US. WE ARE POSTING THIS HOPING IT CAN HELP THIS FROM HAPPENING TO ANYONE ELSE. *TR

I RECEIVED A LETTER FROM BMW STSTING THERE WAS NOW A RECALL FOR THE BAD GROUND WIRE ON THE REAR TAILLIGHT ASSEMBLY THAT CAUSED THE METLING OF THE CONNECTOR. I HAD ALREADY SPENT $400 FOR THE FIX, NOW THEY RECALL THE PART. BMW NORTH AMERICA TOOK TOO LONG TO DO THIS, AND I AM GOING INTO THE DELAERSHIP TO SEE ABOUT GETTING A REFUND FOR THE SERVICE I PAID FOR THAT THEY WOULD NOT COVER.

DURING A MASSIVE RAINSTORM WINDSHIELD WIPERS, RADIO AND CENTRAL LOOKING SYSTEM STOP FUNCTIONING PROPERLY. LOOKS LIKE GENERAL MODULE 5 HAS FAILED. *TR

I WANT TO REPORT A PROBLEM WITH THE IGNITION COILS IN THE BMW 330XI MODEL MADE IN THE YEAR 2004 THAT RESULTS IN REDUCED IGNITION FIRING POWER. THE ENGINE RUNS ROUGH AND THE "SERVICE ENGINE SOON" LIGHT ILLUMINATES. BMW HAD A RECALL ON IGNITION COILS FAILURE IN 2005 AND 2006 ON SOME MODELS BUT THIS PROBLEM NOW SURFACE ON OTHER MODELS AS WELL. PLEASE INVESTIGATE. *TR

TL*THE CONTACT OWNS A 2004 BMW 325I. THE CONTACT STATED THAT THE FAULTY LAMP WARNING INDICATOR WOULD INTERMITTENTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE ELECTRICAL HARNESS THAT PLUGS INTO THE REAR OF THE LAMP HARNESS FOR THE EXTERIOR LIGHTING HAD A FAULTY GROUND IN THE CONNECTOR. THE DEALER STATED THAT THE WIRES COULD NOT TAKE THE HEAT DISTRIBUTION, WHICH CAUSED THE WIRES TO FRY INSIDE THE CONNECTOR. THE FAILURE ALSO CAUSED THE TURN SIGNALS AND REAR LAMPS TO NOT OPERATE CORRECTLY. THERE WERE NO RECALLS FOR THE FAILURES; HOWEVER, THE CONTACT WAS ABLE TO LOCATE TECHNICAL SERVICE BULLETINS PERTAINING TO THE ISSUES (NHTSA ITEM NUMBERS 10025585 AND 10020856). THE CURRENT AND FAILURE MILEAGES WERE 85,000.

SPEEDOMETER READING OFF BY ~5 MILES PER HOUR - GIVE OR TAKE. TWICE REQUESTED DEALERSHIP TO CORRECT THE ISSUE AND WAS TOLD THAT BMW ALLOWS FOR A +/ - 10 MPH DISCREPANCY. THIS SPEED VARIANCE OR INEXACT SPEED INFORMATION COULD MISLEAD DRIVERS AS TO THE APPROPRIATE SPEED IN ICY OR RAINY WEATHER CONDITIONS AS WELL AS OTHER INSTANCES WHERE SPEED NEEDS TO BE UNDERSTOOD. DEFECT NEEDS TO BE CORRECTED AS MIGHT VIOLATE VARIOUS STATE INSPECTION REQUIREMENTS AS WELL. *TR

NO SING OF MALFUNCTION PRIOR TO OR SINCE INCIDENT. ENGINE CUT OFF WHILE CRUISING ON HIGHWAY. CRUISE CONTROL TURNED OFF, ALL LIGHTS IN DASH LIT UP, ENGINE CAME BACK ON AND EVERYTHING OPERATIONAL IN LESS THAN 5 SECONDS. *NM

WHILE DRIVING AT LOW SPEEDS, THE VEHICLE LOST POWER. THE DEALER STATED THAT THE SOFTWARE MALFUNCTIONED. *AK POWER LOSS ISSUE. *SC

CAR STALLED SEVERAL TIMES AT RED LIGHTS. RPM DROPPED WITH NO WARNING. ALSO EXPERIENCE ROUGH IDLING WHEN AT COMPLETE STOP. *AK

CONTINUOUS BUZZING NOISE COMING FROM FRONT TWEETERS. WENT TO DEALERS SEVERAL TIMES WITH NO FIX. NOISE CAN BE HEARD EVEN WHEN THE VEHICLE IS MOVING. *JB