2005 BMW 5 Series Power Train

I PURCHASED THIS BMW 525I USED FROM A PERSON THAT OBTAINED IT FROM A WHOLESALE DEALER, IT HAD SOME MINOR FRONTEND DAMAGE FROM A FENDER BENDER (BROKEN GRILL, DING TO HOOD) SHOWING 107900 MILES. EVERYTHING ELSE CHECKED OUT. I FEW MONTHS LATER I NOTICED A SLIGHT CHANGE IN TRANSMISSION SOUND, BUT IT MIGHT HAVE BEEN DUE TO THE COLD TEMPERATURES HERE IN WISCONSIN. A COUPLE OF DAYS LATER WHILE JUST FINISHING GOING UP A SLIGHT STRAIGHT INCLINE AT AROUND 45MPH THE TRANSMISSION DROPPED DOWN INTO LIMP DOWN MODE AND A TEMPORARY NOTICE CAME UP ON THE COMPUTER SCREEN INDICATING A TRANSMISSION PROBLEM. STOPPING AND RESTARTING THE ENGINE CLEARED THE PROBLEM, THE NEXT DAY NEAR THE SAME SPOT IT OCCURRED AGAIN. I ASSUMED THE TRANSMISSION MIGHT BE LOW ON FLUID BUT LOOKING ONLINE BMW INDICATED THIS IS A NO SERVICE TRANSMISSION BUT THAT IT IS POSSIBLE TO CHECK THE FLUID LEVEL BY ACCESSING A PLUG UNDER THE CAR. WHEN A SERVICE TECH CHECKED HE SAID THE FLUID LEVEL WAS NORMAL BUT SMELLED BURNT. HE RECOMMENDED AGAINST ANY SERVICE IN THAT IT LIKELY WOULD RESULT IN FASTER COMPLETE FAILURE. THE PROBLEM HAS NOT REOCCURRED AND NO CODES SHOW IN THE SYSTEM FILE, IN THAT BMW INSISTED ON NO PROVIDING A METHOD TO CHECK THE TRANSMISSION FLUID, THEY ASSUMED THE LIABILITY FOR FAILURE IF REGULAR MAINTAINANCE (TRANSMISSION FLUSH) COULD HAVE PREVENTED THIS FAILURE.

I STARTED HAVING PROBLEMS SEVERAL MONTHS AGO THAT HAS PROGRESSIVELY GOTTEN WORSE. WHEN I ACCELERATE FROM A STOP, IT APPEARS THAT THE AUTOMATIC TRANSMISSION IS STRUGGLING TO GET TO THE NEXT GEAR. THE RPMS WILL FLUCTUATE UP AND DOWN AND SOMETIMES REV WAY UP BEFORE THE CAR KICKS LIKE I HAVE BEEN HIT. IF I TRY TO ACCELERATE FAST FROM A STOP, THE ENGINE WILL REV UP TO ABOUT 5K RPM AND STOP RESPONDING UNTIL I LET OFF THE GAS AND LET THE RPMS DROP DOWN AND THEN IT WILL KICK INTO GEAR. IF I SLOW DOWN TO ALMOST A STOP AND THEN ACCELERATE IT WILL MOST CERTAINLY KICK, SO I HAVE TO BE VERY CAUTIOUS. I HAVE TO MAKE SURE I HAVE PLENTY OF ROOM WHEN PULLING OUT OF AN INTERSECTION BECAUSE I NEVER KNOW WHEN IT WILL ACT UP (WHICH IS MOST OF THE TIME) AND HINDER MY ACCELERATION. ONCE I GET UP TO CRUISING SPEED (ABOVE 45 MPH) IT RUNS SMOOTHLY, BUT IT HAS GOTTEN TO THE POINT THAT I DREAD EVERY TIME I HAVE TO STOP AT AN INTERSECTION OR SLOW WAY DOWN. I TALKED TO THE DEALER AND SAID IF IT WAS THE TRANSMISSION THEN THE SERVICE LIGHT WOULD COME ON. HE ASKED ME WHAT KIND OF GAS I USE AND I SAID SHELL HIGH OCTANE AND HE SAID THAT IS GOOD. OTHER THAN THAT, HE DIDN'T TELL ME MUCH MORE. I WANT TO SELL THE CAR NEXT SPRING BUT WHO WILL BUY IT WITH IT PERFORMING THIS WAY?

WAS TRAVELING ON THE FREEWAY WHEN THE CAR GAS PEDAL BEGAN TO REV UP ON ITS ON AND THEN THE WARNING LIGHT ALERT "TRANS. MALFUNCTION" THE VEHICLE WILL HAVE REDUCED ACCELERATION. HAVE THE SYSTEM CHECKED BY THE NEAREST BMW CENTER. TRANS. FAULT DRIVE MODERATELY, WE PULLED OFF THE FREEWAY AFTER TURNING OFF THE CAR FOR A WHILE I WAS ABLE TO DRIVE BUT THIS CONTINUES TO HAPPENS, I HAVE CHECKED ON WWW.MOTORTREND.COM FOR RECALLS AND EVERYONE THAT IS LISTED ARE PROBLEMS IM HAVING,RECALL # 76534 AIR BAGS FRONTAL LIGHT, RECALL 51587 POWER TRAIN; AUTOMATIC TRANSMISSION, RECALL #93389 ENGINE & ENGINE COOLING: COOLING SYSTEM: FAN, RECALL 71260 SERVICE BRAKES, HYDRAULIC: POWER ASSIST: VACUUM, I'M HAVING TROUBLE WITH MY CAR IN ALL THESE RECALLS, PLEASE HELP. *TR

TRANSMISSION JERKS AS IF YOU ARE MISSING A SPARK OR IT IS TRYING TO FIND A HIGHER OR LOWER GEAR WHILE CRUISING IN TRAFFIC BETWEEN 32-40 MPH. *TR

FOR MANY YEARS, AND AFTER MANY "REPAIRS" MY 2005 BMW 545I, WHICH I BOUGHT NEW, HAS NEVER RUN RIGHT. BMW IS AWARE OF THE PROBLEM, DOES ACKNOWLEDGE THAT IT IS AN ISSUE, BUT HAS BEEN UNABLE TO REPAIR IT. I HAVE SPENT MANY THOUSANDS OF DOLLARS IN SEARCH OF A PERMANENT FIX, BUT THE LAST BMW DEALER I DEALT IS MIFFED ON SOLVING THE PROBLEM. WHEN APPROACHING BETWEEN 25-35 MPH, THE TRANSMISSION "SLAMS" AND FEELS LIKE YOU HAVE BEEN REAR-ENDED. IT IS A CONTINUOUS PROBLEM. I HAVE TO SLIGHTLY LET UP ON THE GAS IN THESE SPEEDS IN ORDER FOR THE CAR TO RUN RIGHT WITHOUT AN EMERGENCY LIGHT COMING ON SAYING "TRANSMISSION FAULT; DRIVE MODERATELY." THIS CAN BE A DANGEROUS SITUATION BECAUSE THE CAR IS SENSING THE FAULT AND IT WILL NOT ALLOW ONE TO DRIVE MUCH ABOVE 50 MPH WITHOUT STRAINING THE ENGINE. GOING DOWN THE HIGHWAY AT 50MPH IN MY AREA CAN BE A HAZARDOUS ACTIVITY! THIS HAS BEEN A CONTINUOUS SITUATION WITH THE CAR SINCE I PURCHASED IT UP AND THRU THE PRESENT DATE, AUG, 21, 2014. I HAVE NO FAITH IN THE ENGINE/POWER TRAIN/TRANSMISSION. THIS IS MY FIRST AND LAST BMW. *TR

GOING 55 MPH. THE CAR LOST POWER WITH A LARGE WARNING DIAGNOSTIC ON CONTROL PANEL -- TRANSMISSION ERROR INDICATING THAT CAR WOULD NOW OPERATE IN A DIMINISHED STATE. LUCKILY MANAGED TO PULL OFF TO THE SIDE WITHOUT CAUSING ACCIDENT. THIS IS A HAZARDOUS SITUATION THE LOSS OF POWER COULD EASILY HAVE HAD MORE DISASTROUS CONSEQUENCES. IT WAS SPUTTERING AND I SHUT ENGINE OFF AND IT STARTED AGAIN. I DROVE HOME. TOOK IT TO A BMW REPAIR SHOP AND BMW AND NO ONE COULD FIND PROBLEM. *TR

COMING ONTO HIGHWAY PUSHED GAS PEDAL TO ACCELERATE, THE CAR ATTEMPTED TO DOWNSHIFT BUT LOST POWER WITH A LARGE WARNING DIAGNOSTIC ON CONTROL PANEL -- TRANSMISSION ERROR INDICATING THAT CAR WOULD NOW OPERATE IN A DIMINISHED STATE. LUCKILY MANAGED TO PULL OFF TO THE SIDE WITHOUT CAUSING ACCIDENT. THIS IS A HAZARDOUS SITUATION THE LOSS OF POWER COULD EASILY HAVE HAD MORE DISASTROUS CONSEQUENCES. *TR

I WAS DRIVING ALONG THE HIGHWAY AT APPROXIMATELY 55 MPH IN MYCERTIFIED PRE OWNED 2005 BMW 530I THAT I HAVE OWNED FOR 3 AND A HALF YEARS WHEN ALL OF A SUDDEN I GOT A MESSAGE IN THE IDRIVE THAT READ :TRANSMISSION FAILSAFE, DRIVE MODERATELY". I THEN PROCEEDED TO DRIVE HOME APPROXIMATELY 15 MILES. AFTER A COUPLE OF DAY I HAD MY VEHICLE TOWED TO THE NEAREST BWM SERVICE CENTER WHERE I WAS INFORMED THAT THE TRASMISSION WOULD NEED TO BE REPLACED. THE VEHICLE HAD 46K MILES ON IT WHEN I PURCHASED IT SO THAT MEANS THAT I HAVE ONLY DRIVEN 50K WHEN THE TRANSMISSION FAILED. I JUST FIND IT DISCERNING THAT A VEHICLE WITH SUCH LOW MILEAGE IS IN NEED OF A TRANSMISSION. I HAVE KEPT UP THE MAINTENANCE ON MY VEHICLE AND AS I MENTION ABOVED I PURCHASE A PRE- CERTIFIED VEHICLE AND I HAVE NEVER HAS A VEHICLE TO NEED A TRANSMISSION THIS SOON. AFTER CHECKING THE INTERNET IT CONCERNS ME THAT ALOT OF OTHER PEOPLE HAVE HAD THE SAME ISSUE AND THAT BMW HAS NO ADDRESS IT. *TR

CAR SLAMS LIKE YOU JUST GOT REAR ENDED IF YOU SPEED UP WHILE ROLLING AT AROUND 35MPH. THIS IS VERY DANGEROUS AS IT HAPPENS WHEN I'M TRYING TO CHANGE LANES AND SPEED UP. ALSO TRANSMISSION JERKS AS IF YOU ARE MISSING A SPARK OR IT IS TRYING TO FIND A HIGHER OR LOWER GEAR WHILE CRUISING IN TRAFFIC BETWEEN 32-40 MPH. IT JERKS NOTICEABLY WHERE MY SON ASKS WHY ARE YOU DRIVING LIKE THAT. THIS IS TERRIBLE AND NEEDS TO BE DEALT WITH, REGARDLESS WHETHER THE CAR IS STILL UNDER WARRANTY OR NOT. NONE OF THESE INCIDENTS SIGNALS A CHECK ENGINE WARNING. THE BANG AT ROLLING IS ENOUGH TO GIVE ONE WHIPLASH. *TR

TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THERE WAS A PAN SLEEVE GASKET LEAK COMING FROM THE TRANSMISSION. THE VEHICLE WAS TAKEN TO THE DEALER FOR A ROUTINE INSPECTION WHEN THEY FOUND THE TRANSMISSION LEAK. THE DEALER STATED THAT A GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS ADDRESSING THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 80,000.

MY BMW 545I 2005 HAS EXPERIENCED PROBLEMS WITH MECHATRONICS FOR SOME TIME. ONE DAY I WAS DRIVING HOME AND MY CAR HAS DOWN SHIFTED FROM HIGH 4TH GEAR TO 2ND AND CAUSED ME TO DRIVE INTO A DITCH. LUCKILY I WAS WEARING A SEAT BELT BUT STILL EXPERIENCED NECK INJURIES FROM HITTING THE DITCH. THIS PROBLEM NEEDS A RECALL BEFORE SOME ONE GETS KILLED. BMW CAN NO LONGER COVER THIS UP AND THIS ISSUE NEEDS TO BE INVESTIGATED. MANY FORMS ON THE INTERNET HAVE ADDRESSED THE SAME PROBLEM. THIS IS NO LONGER A ISSUE, ITS A LIFE SAFETY PROBLEM. *TR

2005 BMW 545I. IF THE CAR DOES NOT COME TO A COMPLETE STOP, AND I ACCELERATE WHILE IN A SLOW ROLL, THERE IS AN EXTREMELY HARD SLAM FROM THE TRANSMISSION. THIS IS A KNOWN PROBLEM THROUGHOUT BMW OWNER OF THE 545I SERIES. BMW HAS TO KNOW ABOUT THE FAULT IN EITHER THERE PROGRAMMING OR THERE TRANSMISSION AND SHOULD RECALL AND FIX PROPERLY. ANYONE CAN GO TO THE NUMEROUS BMW FORUMS THROUGHOUT THE INTERNET AND FIND THE MANY THREADS REGARDING THIS ISSUE. *TR

I OWN A 2005 545I. I WAS PULLING INTO THE GAS STATION TO REFUEL. I BEGAN TO HIT THE BRAKE THE CAR STARTED TO JERK BACK AND FORTH AND THEN IT ACCELERATED ON ITS OWN. I BEGAN TO PUMP THE BRAKE AND THE CAR STOP SHORT OF THE MINI MART THANK GOD! AFTERWARDS A GEAR INDICATOR APPEARED AND THE CAR WENT INTO SAFE MODE AND SHUT OFF. I COULDN'T START THE CAR AND I TRIED FOR THIRTY MINUTES AND ONLY THE GEAR INDICATOR WOULD COME ON. I THEN CALLED A TOW TRUCK COMPANY AFTER THIRTY MINUTES, RIGHT BEFORE THE TOW TRUCK ARRIVED THE CAR STARTED. I TOOK THE CAR TO BMW OF ROXBURY AND I WAS TOLD THAT SINCE MY DSC LIGHT WAS ON THAT NEEDED TO BE REPAIR TO ALLEVIATE THE PROBLEM. AFTER CHALLENGING THEM, HOW CAN A ADD ON FEATURE (TO INCREASE STABILIZATION AND TRACTION) THAT I NEVER USED WHEN IT WAS WORKING CAUSE THE CAR TO DRIVE BY ITSELF. THEY DROPPED THE ISSUES CALLED ME BACK AFTER A HOUR AND SAID THEY DROVE THE CAR AROUND FOR 25 MIN AND NOTHING IS WRONG. ALSO THERE WAS NO RECORD OF THE GEAR INDICATOR COMING ON EVEN THOUGH IT CAME ON TWENTY OR SO TIMES WHEN I WAS TRYING TO START THE CAR. SO I GUESS I WILL GET MY CAR BACK AND PAY THEM A FEW HUNDRED DOLLARS FOR NOTHING. IS FINE AND THERE IS NO RECORD THE GEAR LIGHT EVER CAME ON. SO. *TR

MY 2005 BMW 545I HAS A HESITATION, AND STRONG HARD DOWNSHIFT PRESENT, UNDER FACTORY WARRANTY I COMPLAINED ABOUT THIS, AND NOW OUTSIDE OF FACTORY WARRANTY I AM STILL HAVING ISSUES, AND NO ONE IS WILLING TO DO ANYTHING ABOUT IT AT MY DEALER BASNEY IMPORTS. WHEN CALLING BMWNA THEY ARE UNWILLING TO HELP UNTIL A "HARD CODE" IS PRESENT, EVEN THOUGH THE SERVICE ADVISOR, AND TECHNICIANS HAVE ROAD AROUND WITH ME IN THE CAR, AND FELT THE SITUATION. *TR

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE BRAKING, THE TRANSMISSION SHIFTED AND THE VEHICLE ABNORMALLY ACCELERATED BARELY MISSING A COLLISION WITH A PEDESTRIAN. THE CONTACT STATED THE FAILURE WOULD OCCUR INTERMITTENTLY WHEN DRIVING AT SPEEDS OF 20-40 MPH. THE DEALER ADVISED THERE WAS A PROGRAMMING ERROR THAT COULD BE REPAIRED, BUT THE REPAIR WAS NOT COVERED UNDER THE CONTACT'S WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 45,000.