2005 BMW X3 ELECTRICAL SYSTEM,SEATS

TL* THE CONTACT OWNS A 2005 BMW X3. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMING FROM THE FRONT SEAT LUMBAR CUSHION OF THE DRIVER'S SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO TAYLOR BMW (4180 WASHINGTON RD, EVANS, GA 30809, (706) 868-6400) WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER'S SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

BOTH SEATS. PURCHASED THIS VEHICLE WITH 183K MILES. WAS GETTING COLD OUT, TURNED ON THE HEATED SEAT FUNCTION AND NOTICED A BURNING SMELL UPON DRIVING DOWN THE COUNTRY ROADS FROM MY HOUSE. THE SIDE OF THE DRIVERS SEAT MELTED THROUGH. COULD SEE IT GLOWING INSIDE OF THE SEAT. SOMEONE HAD DONE A SEAT REPAIR PREVIOUSLY TO COVER THIS ISSUE. APPROX. 1 YEAR LATER I WAS DRIVING DOWN THE HIGHWAY WHEN MY PASSENGER HAD TURNED ON HIS HEATED SEAT. HE STARTED YELLING AND NOTICED THE SEAT HAD BURNED THROUGH THE LEATHER. LUCKILY NO ACCIDENTS WERE CAUSED.

THE DRIVER'S SEAT (BOTTOM) CONTAINS A HEATING ELEMENT. WHEN ON, EVEN ON THE LOWEST SETTING, A HOT SPOT DEVELOPS NEAR THE LEFT REAR SIDE THAT IS SO HOT I HAVE TO SHUT OFF THE HEATER OUT OF FEAR OF A FIRE. *TR

TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE HEATED SEAT FUNCTION OVERHEATED. IN ADDITION, THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED AND THE KEY BECAME DIFFICULT TO RELEASE FROM THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE WIRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

WAS DRIVING WITH SEAT HEATER ON. THE SEAT FELT VERY HOT ON MY LEGS AT IT SMELLED LIKE SOMETHING WAS BURNING. I IMMEDIATELY TURNED OFF THE SEAT HEATER. I PULLED INTO A PARKING LOT AND EXITED THE CAR. I NOTICED A BURN MARK ON THE DRIVERS SIDE SEAT. THERE IS A MATCHING BURN MARK ON THE WOOL COAT I WAS WEARING. THE COAT IS WHAT PREVENTED ME FROM BEING INJURED. I HAVE PICTURES OF THE DAMAGE IF YOU NEED IT. *TR

THE SEAT HEATER IN MY 2005 BMW X3 CAUGHT FIRE AND MELTED A HOLE IN THE SEAT AND BURNED MY LEFT BUTT CHEEK WHILE I WAS DRIVING. MY LEFT BUTT CHEEK WAS BURNED A LITTLE BUT I WAS OTHERWISE UNINJURED. I READ ONLINE THAT A TON OF OTHER PEOPLE WITH THE SAME/SIMILAR MAKE AND MODEL CAR AS ME HAVE HAD THE SAME PROBLEM. THE DEALER SAID IT WOULD COST ABOUT $2000 TO REPLACE THE ENTIRE SEAT. THERE IS CLEARLY A MAJOR FLAW IN THE SEAT HEATER AND IT COULD POSE A MAJOR SAFETY ISSUE SHOULD A FIRE OCCUR AND THE DRIVER IS NOT ABLE TO LEAVE THE CAR RIGHT AWAY. BMW SHOULD RECALL AND/OR PAY FOR THE REPLACEMENT/REPAIR OF THE SEAT. *TR

I WAS DRIVING THE VEHICLE AND TURNED ON THE DRIVER SIDE HEATED SEAT. I TURNED IT ON TO THE FIRST SETTING WHICH IS THE HIGHEST. AFTER ABOUT 2 MINUTES I STARTED TO SMELL SOMETHING BURNING. THEN I ALSO FELT MY LEG BURNING. THE HEATED SEAT HAD HEATED UP SO MUCH THAT IT MELTED A SMALL HOLE IN THE LEATHER WHERE MY LEFT OUTSIDE THIGH WOULD TOUCH THE SEAT. I AM UNABLE TO USE THE HEATED SEAT ANYMORE BECAUSE I AM AFRAID OF GETTING BURNED WORSE. *TR

HEATED DRIVERS SEAT BURNED THROUGH LEATHER AND SCORCHED DRIVERS PANTS. *TR

SEAT WARMER CAUGHT ON FIRE! WHILE PARKED IN THE DRIVEWAY WITH THE ENGINE RUNNING, I TURNED ON BOTH MANUFACTURER-INSTALLED FRONT SEAT WARMERS (OUTSIDE TEMP. 36 DEGREES FARENHEIT) FOR MY SON AND I. I FELT A PINCHING ON UPPER LEFT THIGH / BUTTOCK. THOUGHT IT WAS A BUG. SHIFTED IN THE SEAT, AND FELT IT AGAIN, MORE PAINFUL THIS TIME. LIFTED MYSELF FROM THE SEAT A BIT TO LOOK AT THE SEAT AND SEE WHAT WAS POKING OR PINCHING ME, SAW SMOKE COMING OUT OF A NEW HOLE ON THE LEFT SIDE OF THE SEAT. LOOKED THROUGH THE HOLE, AND SAW FLAMES AND SMELLED BURNING. IMMEDIATELY, TURNED OFF THE SEAT WARMER, GOT OUT OF THE VEHICLE, REACHED OVER AND TURNED OFF THE VEHICLE. THE SEAT SMOLDERED FOR ANOTHER COUPLE OF MINUTES. CALLED MY SPOUSE TO CHECK IF IT WAS STILL SMOLDERING, BUT IT HAD STOPPED. TOOK THE VEHICLE TO THE DEALER TO GET IT CHECKED OUT.

HEATED SEAT CAUGHT FIRE, BURNING THROUGH THICK LEATHER UPHOLSTERY. 2005 BMW X3, 36,000 MILES. NOT REPAIRED, OUT OF WARRANTY, BMW ONLY WILLING TO PAY FOR HALF OF REPLACEMENT, CONSUMER COST 700 DOLLARS. *TR