2006 BMW X3 ELECTRICAL SYSTEM,SEATS

I turned on my heated seat and within about a minute and a half I smelled a burning smell. Pulled over as I started to feel a burn on my leg because the seat heater has burnt through the leather in my car. This is a known problem at BMW and they have not issued a recall for this.

TL* THE CONTACT OWNS A 2006 BMW X3. WHILE DRIVING APPROXIMATELY 10 MPH WITH THE FRONT DRIVER SIDE HEATED SEAT ACTIVATED, SMOKE APPEARED FROM THE SEAT. AS A RESULT, A HOLE WAS BURNED THROUGH THE FRONT DRIVER SEAT AND THE CONTACT'S COAT. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 95,000.

HEATING ELEMENT FOR FRONT DRIVER SEAT SHORTED, CAUSING IT TO BURN THROUGH THE LEATHER. FORTUNATELY, I CAUGHT IT IN TIME BEFORE FIRE OR INJURY. SEARCHING THE INTERNET REVEALS THAT THIS HAS OCCURRED FOR MANY OTHERS AS WELL, SOMETIMES WITH MORE DAMAGING RESULTS. *JS

DRIVER SEAT CAUGHT FIRE WHEN SEAT WARMER WAS ENGAGED. LEATHER SEAT HAS VISIBLE BURN MARK. FIRE BURNED DRIVER. WHEN SEAT WARMER WAS DISENGAGED, SMOKE BEGAN BILLOWING FROM SEAT, FILLING THE VEHICLE WITH SMOKE. SEAT WARMER WAS ENGAGED UPON VEHICLE START IN OWNER'S GARAGE. VEHICLE WAS MOVING APPROXIMATELY 10 MPS (1-2 MINS LATER) WHEN FIRE BEGAN. *TT

06 BMW X3 3.0 DRIVER SEAT HEATER GETS EXTREMEMY HOT IN ONE SPOT. HOT ENOUGH TO CAUSE A BURN IF NOT TURNED OFF QUICKLY. *TR

WE WERE DRIVING IN COLD WEATHER AND ACTIVATED THE SEAT WARMERS ON THE DRIVER AND FRONT PASSENGER SIDES WHEN WE DETECTED AN ODOR OF SOMETHING BURNING AND SMOKING. WE STOPPED AND GOT OUT OF OUR SUV AND DISCOVERED A BURNT HOLE/SPOT ON THE DRIVER'S SEAT, LOWER LEFT SEAT BACK BOLSTER. ON TAKING IT OUR BMW DEALER FOR REPAIR, WE WERE TOLD THAT THE SEAT WARMER WAS DEFECTIVE AND THAT IS WHAT CAUSED THE BURNT HOLE/SPOT ON THE SEAT BACK, I.E., "FAILED COMPONENT 3". FURTHER WE WERE TOLD THAT OUR SUV WAS TWO MONTHS OUT OF WARRANTY, AND THAT THE COST OF REPAIR WOULD COST $2,900. WE HAVE SEARCHED THE INTERNET AND DISCOVERED SIMILAR MALFUNCTIONS ON BMWS EQUIPPED WITH SEAT WARMERS. FURTHER, WE HAD TO REPLACE THE SEAT WARMER SYSTEM ON THE FRONT PASSENGER SIDE APPROXIMATELY TWO YEARS AGO BECAUSE IT TOO BECAME INOPERATIVE. THIS IS A CLEAR CASE FOR BMW TO ABSORB THE COST OF REPAIR, SINCE THIS SEAT WARMER MALFUNCTION HAS A HISTORY OF OCCURRENCES. THANK YOU FOR YOUR ATTENTION REGARDING THIS CASE.WV