2007 BMW X3 ELECTRICAL SYSTEM,SEATS

THE DRIVER'S SEAT HEATING ELEMENT BURNED AND DAMAGED THE SKIN OF THE SEAT AND BURNED MY BACK WHILE DRIVING IN THE CITY. I WAS SO SURPRISED WHEN THIS HAPPENED THAT I JUMPED IN THE SEAT AND CAUSED AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2007 BMW X3. WHEN THE VEHICLE WAS WARMING UP, THE CONTACT STEPPED AWAY FOR A FEW MINUTES. UPON RETURNING, THE INTERIOR WAS FILLED WITH SMOKE. THE CONTACT NOTICED THAT THE FRONT DRIVER SEAT WAS BURNING. THE CONTACT TURNED THE ENGINE OFF AND WAITED FOR THE SEAT TO COOL DOWN. THE CONTACT DROVE THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRIC WIRING FOR THE SEAT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

TL* THE CONTACT OWNS A 2007 BMW X3 SAV. AFTER A SEAT WARMER WAS ACTIVATED, THE HEAT GENERATED BECAME SO INTENSE THAT IT BURNED A HOLE IN THE SEAT, AS WELL AS THE CONTACT'S JACKET AND JEANS. THERE WERE NO INJURIES. THE CONTACT WAS ALTERED TO THE FAILURE DUE TO A BURNING ODOR. THE FAILURE OCCURRED WITHOUT WARNING. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE FAILURE WAS CAUSED BY A FAULTY HEATING ELEMENT AND THE SEAT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 111,000.

IN COOL CLIMATE ON NOVEMBER 1, 2016. TURN ON MY HEAT SEAT, THEN I SMELLED SOMETHING BURNED, THEN I FELT SHARP BURN ON LEFT BUTT CHEEK. THEN I KNEW SOMETHING WRONG WITH HEAT I TURNED OFF, , ON NOVEMBER 7, 2016, I TRIED AGAIN,,, BURNING SMELL IS SO BAD, THE HEAT STILL BURNED ALMOST THROUGH OUT SIDE LAYER OF SEAT

BMW X3 HEATED SEAT BURNED HOLE THROUGH SEAT. IF HEATED SEAT IS TURNED ON, VISIBLE SPARKS OR FIRE WILL COME THROUGH HOLE. HOLE IS DIRECTLY BELOW DRIVER'S LEFT THIGH. BMW HAS ISSUED A RECALL FOR OTHER MODELS, BUT NOT THE X3. THE X3 IS SUSCEPTIBLE TO THE SAME ISSUE.

DUE TO COLD WEATHER, ENGAGED THE DRIVER SIDE SEAT HEATER. NOTICED A SHARP PAIN IN MY LEG AND THEN BEGAN TO SMELL AND SEE SMOKE. FORTUNEATLY, I WAS QUICKLY ABLE TO REALIZE THE SEAT HEATER APPEARED TO HAVE A SHORT IN IT, AND TURNED OFF BEFORE BURNING THROUGH THE LEATHER AND SETTING MY CLOTHS ON FIRE. I WILL BE CONTACTING MY LOCAL BMW DEALERSHIP TO SEE WHAT, IF ANYTHING THEY ARE WILL TO DO. I FEEL THERE SHOULD BE A RECALL BEFORE SOMEONE IS SERIUOSLY HURT OR KILLED. THE ENGINE WAS IDLING WHEN SEAT HEATER WAS ON. I WAS BACKING OUT OF DRIVEWAY AND DRIVING DOWN STREET WHEN I NOTICED. IF I WOULD HAVE HAD SEAT HEATER ON AND THEN STEPPED AWAY FROM VEHICLE AS IT WAS WARMIMG UP, I AM CONFIDENT THE DRIVER SEAT WOULD HAVE CAUGHT ON FIRE OR AT LEAST SEVERLY DAMAGED IT.

THE CAR IS EQUIPPED WITH SEAT HEATERS. ONE OF THE HEATING ELEMENTS FAILED, OVERHEATED AND BURNED THROUGH THE SEAT SURFACE. IN DOING RESEARCH, THIS APPEARS TO BE A PROBLEM WITH THE VEHICLES. BMW DID DO A RECALL ON THE X5, BUT DOES NOT SHOW A RECALL ON THE X3. ON VARIOUS SITES, THIS ISSUE HAS OCCURRED MANY TIMES WITH OWNERS, SOME WITH THE VEHICLE CATCHING ON FIRE. I FOUND COMPLAINTS ON THE FOLLOWING SITES; CARCOMPLAINTS.COM, BIMMERFEST.COM AND ARFC.ORG. JUST ON CARCOMPLAINTS, THIS COMPLAINT IS SHOWN 23 TIMES; MADBURY, NH, PORTLAND, OR, WESTFIELD, IN, DERWOOD, MD, TAMPA, FL, ANNAPOLIS, MD, LOUISVILLE, KY, BERGENFIELD, NJ, HOLDERNESS, NH, LIBERTY TOWNSHIP, OH, LAUREL, MD, NOVI, MI, CROMWELL, CT, PRAIRIE VILLAGE, KS, HILLSBOROUGH, NC, DALY CITY, CA, ALEXANDRIA, VA, SAGINAW, TX, BETHESDA. MD, PITTSBURG, PA, SELAH, WA. SAME ISSUE WITH EACH. BMW OF NORTH AMERICA WAS CONTACTED AND THEIR RESPONSE WAS "IT'S A PART OF WEAR AND TEAR....NO OFFER TO ASSIST" FROM BMW NA. YET, THE ISSUE HAS CONTINUED TO ARISE AND BMW NA DID REPLACE THE HEATER ELEMENT AND SEAT SURFACE IN SOME INSTANCES, MAKING THE REPLACEMENT A MATTER OF PREFERENCE OR DISCRIMINATION, OR DEALER'S OPINION OF THE CAR OWNER VERSUS CORRECTING THE MANUFACTURING/DESIGN DEFECT PROBLEM. I WOULD REQUEST THE ASSISTANCE OF NHTSA TO REVIEW THIS MATTER AND PROTECT THE PUBLIC FROM HAZARDOUS OVER-HEATING/ FIRE THREATS. I WAS FORTUNATE TO HAVE BEEN JUST GETTING INTO THE VEHICLE AND SMELL THE BURNING LEATHER AND TURNED OFF THE SEAT HEATING SYSTEM BEFORE A FIRE COULD OCCUR.

WHILE DRIVING SMELLED SOMETHING BURNING AND ALSO REALIZED MY UPPER LEG WAS IN PAIN. TURNED OFF THE SEAT WARMER AND INVESTIGATED AFTER REACHING MY DESTINATION. THERE WAS A SCORCH MARK IN THE SEAT NEAR THE BOTTOM LEFT BOLSTER. LUCKY THIS DIDN'T CAUSE A FIRE OR BODILY INJURY. *TR

DRIVING VEHICLE NOTICED A BURNING SMELL, AT FIRST THOUGHT IT WAS COMING FROM OUTSIDE OF CAR, THEN WHILE IN HEAVY TRAFFIC AND UNABLE TO PULL OVER FELT A BURNING PAIN ON THIGH. IMMEDIATELY TURNED OFF SEAT WARMER AND TRIED TO PULL OVER. FOUND THAT DRIVERS SIDE SEAT WARMER HAD BURNT A HOLE THRU THE LEATHER SEAT COVER AND BURNED MY PANTS. THIS COULD HAVE VERY EASILY CAUSED A WRECK! *TR

I HAD CAR HEATING SYSTEM ON AND FELT SOME THING VERY HOT UNDER MY THIGH. I GOT DOWN TO INSPECT AND FOUND A HOLE IN THE CAR SEAT. I PUT OFF THE HEATING SYSTEM TO REACH HOME SAFELY. I HAVE SENT PICTURES AND MY COMPLAINT TO BMW AG AND BMW USA. *TR

DRIVER'S SIDE SEAT HEATER HAS MALFUNCTIONED AND HAS BURNT THE LEATHER AND CAUSED DISCOMFORT WHILE DRIVING. HEAVY BURNT SMELL IN THE CABIN RESULTED FROM USING THE SEAT HEATER. *TR

TURNED ON HEATED SEAT ON DRIVER'S SIDE. AFTER APPROXIMATELY 2 MINUTES, FELT BURNING ON LEFT SIDE OF SEAT. TURNED OFF THE HEATED SEAT, TURNED ON THE LIGHT AND THE SEAT WAS SMOKING SUBSTANTIALLY. A SMALL HOLE WAS BURNED THROUGH THE LEATHER SEAT (ABOUT THE SIZE OF A DIME) AND THROUGH MY PANTS. I HAVE A SMALL RED MARK ON THE TOP OF THE BACK OF MY LEG. THE VEHICLE SMELLS LIKE SMOKE. LUCKILY, I WAS IN THE DRIVEWAY WHEN THIS HAPPENED OR AN ACCIDENT MIGHT HAVE OCCURRED. VERY CONCERNING AND WILL LIKELY BE A COSTLY REPAIR. HAVE NOTED SEVERAL OTHER SIMILAR INCIDENTS REPOTED ON-LINE. *TR