2000 Chevrolet Malibu Engine

2000 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO VEHICLE FIRE AND ENGINE OIL MAY DEPOSIT ON THE EXHAUST MANIFOLD RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE CAUGHT OF FIRE. *JB

AS DRIVING ALONG THE HIGHWAY THE CAR COMPLETELY SHUT OFF AND WOULD NOT START UP AGAIN AND HAS NOT STARTED UP SINCE. THE CAR WAS IN MOTION, I WAS ON THE HIGHWAY, TRAVELING ON I-10 HIGHWAY.

TL* THE CONTACT OWNS A 2000 CHEVY MALIBU. THE CONTACT WAS DRIVING 90 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PULLED OVER AND CALLED A TOW TRUCK. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED FOR THE FAILURE. THE CONTACT CALLED THE MANUFACTURER AND WAS ADVISED THAT THEY WERE UNABLE TO ASSIST. THE FAILURE MILEAGE WAS 200,010. THE VIN WAS UNAVAILABLE.

COOLANT IN THE OIL. HAS ALWAYS OVER HEATED IN STOP & GO TRAFFIC, NO ONE KNOWS HOW TO FIX BUT IS AWARE OF THE PROBLEM & SAYS GM COULD CARE LESS & WON'T FIX IT. HOW MANY COMPLAINTS DO YOU NEED BEFORE THIS VERY COMMON COMPLAINT IS RECOGNIZED & IS RECALLED???????? *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH, THE ENGINE WARNING LIGHT INTERMITTENTLY ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN STATED THERE WAS A LEAKAGE WITHIN THE INTAKE MANIFOLD GASKET WHICH COULD RESULT TO THE ENGINE OVERHEATING AND POTENTIALLY CAUSING A FIRE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 63,000. UPDATED 02/23/11*LJ UPDATED 02/28/11

TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING AT HIGHWAY SPEEDS, THE VEHICLE SUDDENLY SHUTS OFF. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 135,000.

TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 40 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT THE INTAKE MANIFOLD GASKET CAUSED THE FAILURE. THE MECHANIC ALSO STATED THAT THIS WAS A COMMON ISSUE FOR THIS YEAR, MAKE, AND MODEL VEHICLE. THE CONTACT FEELS THAT THIS IS A MAJOR DEFECT AND CHEVROLET SHOULD BE RESPONSIBLE FOR THE REPAIRS. THE CURRENT AND FAILURE MILEAGES WERE 144,000.

AFTER REPLENISHING RADIATOR FLUID IN MY 2000 CHEVY MALIBU WITH THE APPROVED FLUID, HAVOLINE DEX-COOL RADIATOR FLUID, MY CAR STARTED TO CONSTANTLY LEAK ANTI-FREEZE AND NOW I HAVE A LEAK AND MY RADIATOR "IDIOT" LIGHT IS CONSTANTLY ON. THE CAR WAS PERFECTLY FINE PRIOR TO THE APPLICATION OF THE DEX-COOL BUT DAYS AFTERWARD MY TROUBLES BEGAN. THERE WAS NEVER A PROBLEM BEFORE AND AS USUAL 4-6 WEEKS I WOULD HAVE TO REPLENISH 1/2 GALLON OF FLUID. THIS IS NOTED ON EVERY DISCUSSION BOARD REGARDING THIS MODEL BETWEEN 1997-2003. IT'S TOO CIRCUMSTATIAL THAT IMMEDIATELY AFTER THE APPLICATION OF THE DEX-COOL THAT MY TROUBLES BEGAN THEN FINDING THE SETTLEMENT OF GM REGARDING THIS MATTER AND IMPROPER GASKETS FOR THEIR MANIFOLDS AND WATER PUMPS (NYLON/SOLICONE BASED) THAT THE COURTS FOUND THAT THE COOLANT DOES INDEED CORRODE THESE GASKETS. NOW THAT MY CAR IS 8 YRS OLD, MY ABILITY TO RECOUP ANY MONEY ON USING THE PROPER/RECOMMENDED PRODUCT AS STATED BY GM IS MORE THAN LIKELY IMPROBABLE. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO OVERHEAT. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND THEY STATED THAT THE INTAKE MANIFOLD FAILED AND NEEDED TO BE REPLACED. THE MECHANIC STATED THAT THE ENGINE FAILURE WAS COMMON FOR THIS YEAR, MAKE, AND MODEL VEHICLE. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 63,000.

NOTICED COOLANT LEAKING FOR THE 2ND TIME IN 2 YEARS. THIS IS NOW THE 2ND TIME TO REPLACE INTAKE MANIFOLD GASKET. THE 1ST REPLACEMENT WAS DONE 2006 FOR ~$750. NOW THE ESTIMATE TO REPLACE GASKET AND FLUSH COOLING SYSTEM IS ~ $800. NEW RADIATOR MAY BE REQUIRED IF THE SERVICE SHOP CAN NOT FLUSH OIL OUT OF THE RADIATOR. *TR

I OWN A 200 CHEVY MALIBU AND HAVE HAD TO REPAIR AN INTAKE MANIFOLD TWICE- ONCE AT 92,000 MILES AND AGAIN AT 105,000 MILES. GM KNOWS THAT THEIR DEX COOL ANTIFREEZE EATS THROUGH THE GASKETS BUT DOES NOTHING TO FIX IT. I DO NOT KNOW WHY THE GOV.'T LETS THEM GET AWAY WITH THIS. THIS IS VERY EXPENSIVE AND NOT SOMETHING THAT SHOULD HAVE TO BE REPAIRED WITHIN 100,000.00 MILES. THE SPEEDS ON THE FAN DID NOT WORK SHORTLY AFTER PURCHASE AND AROUND 50,000. MILES THE TURN SIGNAL DID NOT WORK . I DID HAVE THE EXTENDED WARRANTY AND BOTH WERE COVERED BUT THESE ARE NOT THINGS THAT SHOULD BREAK DOWN. IT WAS VERY DANGEROUS TO BE SITTING AT A LIGHT AND TURNING LEFT AND NOT BEING ABLE TO SIGNAL. I DID EVENTUALLY GET A RECALL ON THIS BUT IT WAS WAY AFTER IT WAS FIXED. GM MAKES JUNK AND THE GOV.'T SHOULD HOLD THEM RESPONSIBLE. I WILL NEVER PURCHASE ANOTHER GM PRODUCT. *TR

I OWN A 200 CHEVY MALIBU AND HAVE HAD TO REPAIR AN INTAKE MANIFOLD TWICE- ONCE AT 92,000 MILES AND AGAIN AT 105,000 MILES. GM KNOWS THAT THEIR DEX COOL ANTIFREEZE EATS THROUGH THE GASKETS BUT DOES NOTHING TO FIX IT. I DO NOT KNOW WHY THE GOV.'T LETS THEM GET AWAY WITH THIS. THIS IS VERY EXPENSIVE AND NOT SOMETHING THAT SHOULD HAVE TO BE REPAIRED WITHIN 100,000.00 MILES. THE SPEEDS ON THE FAN DID NOT WORK SHORTLY AFTER PURCHASE AND AROUND 50,000. MILES THE TURN SIGNAL DID NOT WORK . I DID HAVE THE EXTENDED WARRANTY AND BOTH WERE COVERED BUT THESE ARE NOT THINGS THAT SHOULD BREAK DOWN. IT WAS VERY DANGEROUS TO BE SITTING AT A LIGHT AND TURNING LEFT AND NOT BEING ABLE TO SIGNAL. I DID EVENTUALLY GET A RECALL ON THIS BUT IT WAS WAY AFTER IT WAS FIXED. GM MAKES JUNK AND THE GOV.'T SHOULD HOLD THEM RESPONSIBLE. I WILL NEVER PURCHASE ANOTHER GM PRODUCT. *TR

I BOUGHT THE CAR AT THE END OF 2000 AND HAD TO REPLACE THE INTAKE MANIFOLD GASKETS AT AROUND THE SAME TIME (THANKSGIVING) IN 2001. MY FUEL PUMP WENT OUT IN 2002 AND MY MECHANIC JUST TOLD ME THE INTAKE MANIFOLD GASKETS ARE LEAKING AGAIN. HE SUGGEST TO REPLACE THEM SOON. IT COST $900 TO GET IT FIXED THE FIRST TIME WHICH WAS NOT UNDER MY EXTENDED WARRANTY PLAN. I JUST PAID THE CAR OFF AND HAVE TO FORK OUT ANOTHER $700-900 TO GET IT FIXED AGAIN. IT IS COMMON KNOWLEDGE TO GM THAT THERE IS A HISTORY OF GASKETS PROBLEMS IN SEVERAL CHEVY MODELS ESPECIALLY THE MALIBU, BUT NO RECALL HAS BEEN ISSUED AND NO COMPENSATION HAS BEEN AWARDED TO ALL THOSE HARD WORKING PEOPLE WHO TRUST THE CHEVY NAME. IF NOTHING IS DONE I WILL NEVER BUY CHEVY AGAIN. PONTIAC HAD THE SAME PROBLEM WITH SOME OF ITS CARS A FEW YEARS BACK AND RECALLED ALL MODELS WITH LESS THAN 100,000 MILES ON THEM. WHY WONT CHEVY. THERE NEEDS TO BE A RECALL OR A LEMON LAW ON THE CHEVROLET MALIBU!!! I AM SURPRISED THAT A CLASS ACTION LAWSUIT HAS NOT BEEN FILED AGAINST GM FOR SELLING SUCH A DEFECTIVE PRODUCT!!! I HOPE THAT NO ONE HAS HAD AN ACCIDENT, INJURY, OR EVEN DEATH RESULT FROM THIS DANGEROUSLY DEFECTIVE CAR!!! *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE LOW COOLANT WARNING INDICATOR LIGHT ILLUMINATED; HOWEVER, THE VEHICLE WAS FILLED WITH COOLANT. THIRTY MINUTES LATER, THE VEHICLE OVERHEATED WHILE DRIVING 70 MPH. THE LOW COOLANT WARNING INDICATOR LIGHT ILLUMINATED AGAIN. THE DEALER STATED THAT THERE WAS A LEAK IN THE INTAKE MANIFOLD. NO REPAIRS WERE MADE. THE CONTACT VERIFIED HIS VIN; HOWEVER, IT WAS INVALID. THE ENGINE SIZE AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 125,000.

SMALL LEAK DEVELOPED AT REAR OF INTAKE MANIFOLD. CAUSED OVERTEMP AND ALL COOLANT BOILED OUT. @ $800.00 TO REPAIR. I AM REPORTING THIS BECAUSE 2 SEPARATE REPAIR SHOPS INFORMED ME THIS IS A KNOWN DEFECT FOR THIS MODEL, TO THE EXTENT THE DEFECT IS POSTED ON ALL REPAIR DATA BASES. IT IS VERY COMMON TO SUSTAIN A CRACK IN THE ENGINE BLOCK BECAUSE OF THIS DEFECT.

FROM THE TIME I GOT MY CAR IN 6/07, I HAVE ALSO HAD PROBLEMS WITH THE AC SYSTEM HAVING A MIND OF ITS OWN. 1 AND 2 WON'T WORK AND THE AC POWER LIGHT FLICKERS ON AND OFF WHILE DRIVING AND RESETTING IT TO PULL THE AIR FROM OUTSIDE INSTEAD OF CIRCULATE. THE PREVIOUS OWNER ALSO STATED THAT SHE HAD PROBLEMS WITH THE CAR NOT STARTING IN THE MORNING AND HAVING TO WAIT ABOUT 15 MINUTES. HAVEN'T HAD ANY PROBLEMS WITH IT STALLING, BUT HAVE ONLY HAD IT 2 MONTHS. OCCASIONALLY WHILE AT A LIGHT OR IN PARK, I FEEL THE CAR JOLT SLIGHTLY AND THE RPM GAUGE MOVING, AND WHILE IN PARK PRESSED THE GAS TO SEE WHAT IT WOULD DO, AND WHILE MY FOOT WAS STEADY ON GAS, THE RPM WENT UP AND DOWN LIKE CRAZY. MECHANIC FRIEND OF MINE LOOKED AT MOTOR BRIEFLY AND SAID I HAD A BAD SENSOR. *TR

I HAVE HAD ONGOING PROBLEMS 3 YEARS., APPROXIMATELY WITH FREQUENT LOW COOLANT LEVELS AND LOW OIL LEVELS, IN ADDITION TO NOTICING A STRONG ODOR OF COOLANT AFTER TURNING CAR OFF. I WAS INFORMED RECENTLY , DURING A ROUTINE OIL CHANGE IN MAY, 2007, OF A COMMON PROBLEM OFTEN OBSERVED IN GM 3.1 L AND 3.4L V-6 ENGINES. THE INTAKE MANIFOLD GASKET LEAKED AND ALLOWED CROSS CONTAMINATION OF THE COOLANT AND OIL SYSTEMS. THE OIL SYSTEM LEAKED INTO THE COOLANT SYSTEM, CLOGGING THE FLOW OF ENGINE COOLANT AND DAMAGING OTHER SYSTEMS, GASKETS AND FLUIDS. THE COOLANT LEAKE D INTO THE OIL SYSTEM AS WELL, CAUSING ENGINE WEAR.*AK NOW I AM TOLD IT WILL COST ABOUT $1000.00 TO REPLACE THE INTAKE MANIFOLD GASKET, IN ADDITION TO ALL THE OTHER GASKETS AFFECTED BY THIS LEAK. THE MAIN EXPENSE IS FOR THE LABOR TO REACH THE INTAKE MANIFOLD GASKET IN MID-ENGINE. I WAS ALSO INFORMED THAT THIS PROBLEM AFFECTS ALL GM 3.1L AND 3.4L V-6 ENGINES SINCE 1996, AND THAT THESE ENGINES HAVE NOT BEEN RECALLED, IN SPITE OF THE FREQUENCY OF THIS COMPLAINT. MY VEHICLE IS NO LONGER UNDER WARRANTY, BUT SINCE THIS ENGINE'S PROBLEM HAS BEEN KNOWN SINCE BEFORE I PURCHASED THE CAR, I BELIEVE I AM JUSTIFIED IN REQUESTING THAT GM COVER THE COST OF ANY NECESSARY REPAIRS TO REPLACE THIS LEAKING GASKET BEFORE THE ENGINE IS DESTROYED.

2000 CHEVY MALIBU INTAKE MANIFOLD GASKET FAILURE, 800.00 TO FIX. REPLACED GASKET AT DEALER, TOLD CAR WAS A FIXED AND THEN THE HEAD GASKET FAILS, WITHIN HOURS OF LEAVING REPAIR SHOP. *JB

MY ENGINE STALLS AT LEAST 2 TO 3 TIMES A MONTH, NOTHING HAS BEEN DONE BECAUSE IT IS AN EXPENSIVE PROBLEM... AND IT IS A MANUFACTURERS DEFECT.... *TR

WHILE DRIVING MY CAR ALONG THE FREEWAY AND WITHOUT ANY NOTICE THE CAR WENT FROM HAVING A NORMAL TEMP TO RED LINING ON THE TEMPERATURE. I IMMEDIATELY SLOWED THE VEHICLE DOWN AND TURNED ON THE HEAT. AT THIS POINT NO HEAT CAME OUT AND SOON AFTERWARDS THE VEHICLE OVERHEATED AND DIED. I CRUISED IT OFF THE FREEWAY AND ONTO A SIDE ROAD. I WAS IN THE MIDDLE OF NOWHERE AND A PASSERBY WAS NICE ENOUGH TO STOP. I ENDED UP REFILLING THE COOLANT AND WAS ABLE TO DRIVE TO WHERE I NEED TO GO AND RETURN HOME. I HAD REFILL THE FLUID LEVEL MULTIPLE TIMES. I TOOK IT TO A RADIATOR SHOP THAT STATED THAT THE SEALS ON MY ENGINE WERE LEAKING EXHAUST INTO THE FLUIDS WHICH CAUSED THE VEHICLE TO OVERHEAT. THEY STATED THAT CHEVY WAS HAVING TROUBLE WITH THE DEXACOOL COOLANT IN THE VEHICLES AND THAT IT WAS EATING AWAY THE SEAL IN THE ENGINE. *JB

DT*: THE CONTACT STATED WHILE PARKED IN THE DRIVEWAY, A LEAK WAS NOTICED UNDER THE VEHICLE. IT WAS DRIVEN TO THE DEALER WHO DETERMINED THE INTAKE GASKET NEEDED TO BE REPLACED.

COOLENT LEAKS AND OVERHEATING,WHAT THE HELL GM WAITING FOR,WE NEED TO GET THIS INFORMATION OUT TO THE BUYING PUBLIC TO STOP BUYING GM PRODUCT THAT THEY WILL NOT STAND-BY. FIX YOUR PROBLEM. YOUR COOLANT CALLS FOR REPLACING 100,000 TO 150,000 MILES, NOT EVERY COUPLE OF DAYS. THE JAPANESE AUTO MAKERS WOULD HAVE SOLVED THIS PROBLEM A LONG TIME AGO AT NO CHARGE TO THE OWNERS. CLASS ACTION LAWSUIT IS IN ORDER.STOP-F----- YOUR MALIBU OWNER

I FIRST NOTICED THAT THE COOLANT WAS LEAKING FROM BELOW MY CAR. IT HAS 76,000 MILES. THE INTAKE MANIFOLD GASKETS ARE DEFECTIVE. THIS IS A PROBLEM THAT I HAVE RESEARCHED AND DISCOVERED THAT MANY, MANY OTHERS HAVE EXPERIENCED THIS. THIS IS A $1000 PROBLEM THAT I FEEL CHEVY HAS REFUSED TO RECALL BECAUSE AT $1000 A POP, WHO WOULD? *JB

WE LOST ALL OF OUR ANTI-FREEZE THINKING WE LOST A HOSE. UPON TAKING IT IN TO A CERTIFIED MECHANIC HE HAD TO REPLACE THE MANIFOLD INTAKE GASKETS FOR THE 2ND TIME. UPON SHOWING THE MANIFOLD TO A MECHANIC FOR GM HE FOUND A BUBBLE IN THE MANIFOLD WHEN IT WAS MOLDED. *JB

MY CAR WAS RUNNING HOT AND IT SMELL LIKE SOMETHING WAS BURNING UNDER THE HOOD, SO I TOOK THE CAR IN TO THE SHOP TO HAVE FIX AND THE WORKER TOLD ME IT WAS A DEFECTIVE INTAKE MANIFOLD GASKETS. IT WOULD COST ME CLOSE TO $850 TO FIX. THE PART ITSELF ONLY COST $89, BUT THE LABOR IS WHAT I WAS PAYING FOR. I CANNOT AFFORD TO KEEP FIXING THIS CAR ON A COLLEGE STUDENT BUDGET. AFTER TALKING TO OTHER MALIBU OWNERS WITH THE SAME PROBLEMS I CHECK TO SEE IF IT IS A RECALL PROBLEM, BUT IT IS NOT. THIS IS NOT FAIR THAT THE COMPANY KNOW THEY SOLD DEFECTIVE CARS AND NOT PLAN ON DOING ANYTHING ABOUT IT. *NM