2017 Ford Escape Engine

Coolant leaking into engine cylinder 2 possible head gasket issue associated with known problem for this vehicle. Will cause overheating due to coolant levels needing to be refilled on a regular basis.

My [XXX] daughter was driving her 2017 Ford Escape 1.5L EcoBoost check engine light came on and a message to pull over immediately. Vehicle was out of coolant. The coolant isn't leaking. The vehicle has a design flaw that causes coolant intrusion into the cylinders. Extremely dangerous and could leave someone stranded. The cost to fix is about the same as the value of the car!! Thousands of dollars!! This is a known design, flaw, and thousands of customers are experiencing it. It can leave drivers stranded and dangerous situations, including drivers like my teenage daughter. Ford should be responsible to fix this dangerous design flaw! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The engine started sputtering. Took it to a mechanic, and they said that the engine block had a crack.

On 1/13/26, vehicle was taken to Don Hinds Ford, Fishers, IN 46038-2892 for loss of coolant and sporadic shaking during start. Service performed diagnostic "Diagnostic: PERFORMED COOLANT PRESSURE TEST AND USED BOROSCOPE TO INSPECT EACH CYLINDER. FOUND CYL# 3 & 4 TO HAVE COOANT INTRUSION. RECOMEND REPLACEMENT OF ENGINE LONG BLOCK." Service recommendation "Engine Rebuild/Replace: REPLCEMENT OF ENGINE LONG BLOCK VIA TSB 22-2229" totaling $9,229.68 to be paid by customer. TSB 22-2229 is expired and vehicle has 82K miles. Known issue with this engine design, but not covered by Ford. I contacted Ford Customer Service requesting goodwill assistance or out-of-warranty coverage. Both were denied over the phone.

Coolant leaking into cylinder car has under 60,000 miles.

Coolant intrusion due to engineering defect in engine. Ford is more than aware of this, but will not help us at all. Car is effectively dead and unusable. Ford TSB admits to this defect and requires a "long block" replacement (full engine replacement), but is doing nothing to help customers. This is fleecing.

Coolant intrusion due to head gasket wear from Ecoboost, a known defect on the Ford Escape from 2013-2019. Yes, safety was put at risk, as the entire vehicle started shaking violently without warning on the expressway due to misfire caused from coolant intrusion. Vehicle is currently at Roy O'Brien Ford, SCS MI, where it was diagnosed having coolant intrusion. No warning lights appeared until the incident on [XXX], with a flashing check engine light while driving, with the vehicle shaking violently. Prior to, I could feel and see the RPM's bouncing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine, Yes. There is a known coolant intrusion engine fault with ford escapes. ford has issued TSBs over this How was your safety or the safety of others put at risk? Engine abruptly died. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No

Vehicle is slowly losing collant, and when I park I get a strong smell of collant. I took vehicle to have collant flushed and was took system was ok. From what I have researched is that there is a history of coolant entering engine cylinder because of defective engine and causeing engines to event ually seize.

Engine failure due to multiple coolant failures, due to poor design of the long engine block. Ford removed and replaced the long block in full, but it was out of warranty. There are multiple class action lawsuits against Ford for the defecting engine block design. There was only 49,187 miles on the car, well under mileage warranty, but above the 7 year old car age warranty. I paid $8379.39 for the new long block engine.

Coolant intrusion on the 2.0 ecoboost engine diagnosed by a ford dealer service center and a well documented issue. The coolant intrusion causes the engine to misfire rendering the car unusable and a potential road hazard.

Ford Technical Service Bulletin (TSB) number is 21-2269. The engine block is leaking coolant into the cylinders which causes the engine to report over heating.

Known coolant leak into the cylinders that ford won’t cover

Coolant in cylinder 2 due to crack in cylinder wall at head gasket due to thin sealing surface

Coolant intrusion on 2.0L Ecoboost Engine Car started running rough, oil light came on. Palmetto Ford Charleston SC indicated engine needed replacement due to coolant intrusion. This same dealer replaced the Turbo Wastegate 10/17/2025. 12/17/2025 the car ran rough.Service Bulletin 19-2346 seems to be the problem. Called Ford Customer Service who offered no assistance. Car has 75,000 miles, 1 owner, well maintained.

Stalled at Traffic lights when stopped and finally told engine coolant leak at 89K miles.

The contact owns a 2017 Ford Escape. The contact stated that while driving 10 MPH and attempting a right turn, the “High Temperature - Fire Risk” message was displayed, and the vehicle independently shut off while depressing the accelerator pedal. The contact started to merge the vehicle into a shopping center. An independent mechanic was contacted. The vehicle was towed to an independent mechanic, where it was diagnosed, and determined that the engine needed to be replaced. The thermostat was replaced, and the remaining coolant was drained and refilled, and the coolant temperature sensor was replaced, and the vehicle was repaired. The contact stated that the failure had occurred twice. The manufacturer was notified of the failure and informed the contact that there was no recall or warranty on the vehicle for the repair. The contact was informed that if the vehicle was repaired out of pocket and then there became a recall for the failure, there was a possibility of being reimbursed. The approximate failure mileage was 88,344.

Coolant leaking into engine. Known problem they say they won’t fix

05/03/2025 - My Escape has the 1.5L 4-cylinder engine failed at 118763 miles. Local Ford Dealership installed new Short Block. 09/11/2025 - Engine failed at 122742. Local Ford Dealership installed new Short Block.

Coolant leaking into the engine and blowing white smoke

The vehicle has experienced consistent overheating issues and coolant leak this Fall. My mechanic searched and realized that there were hundreds of thousands of vehicles that experienced engine performance issues traced to coolant intrusion—a known problem in certain Ford 2.0L EcoBoost engines (model years around 2015–2019). Coolant leaked into the cylinders, causing misfires and eventual engine failure. While this issue is widely documented and addressed under Ford’s Customer Satisfaction Program (CSP 21N12), it is not part of an official safety recall. As a result, coverage is limited to specific warranty or mileage criteria, leaving some vehicles, including this one, ineligible for repair under the program despite the severity of the failure. I have no recourse for this, and it seems as though a very costly repair is likely even though there is a known issue that Ford has acknowledged and fixed for many other owners.

In 2023, at around 77,000 miles the engine block in my moms 2017 Ford Escape Titanium (2.0L EcoBoost) cracked due to coolant intrusion and we had to have it replaced. Although the engine was replaced, the replacement engine was the same model, just from 2016 instead of 2017. The engine is still running fine, but due to the poor manufacturing of the engine block, I am worried it will happen again soon since the car itself has 108,000 miles, and the engine has around 85,000.

Known issue from Ford with coolant intrusion into cylinder 2 and maybe cylinder. Addressed through TSB 22-2232. Purchased car in February 2024 with 77k on it. Dealer won't repair the issue. Needs a new redesigned engine. Dealer only covers the issue if it's under the original warranty with less than 60k miles. My car now has 131k miles on it.

The contact owns a 2017 Ford Escape. The contact stated that while driving at 25 MPH, the engine overheated. The message to "Immediately Pull Over" was displayed. The vehicle was taken to an independent mechanic, where coolant was added. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the failure was related to the Customer Satisfaction Program: 21N12. The contact filed a complaint with the Ford chat division and was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 83,000.

The contact’s friend owns a 2017 Ford Escape. The contact stated that while his friend was driving at an undisclosed speed, the check engine warning light illuminated. The engine idled roughly, and there was white smoke coming from the exhaust pipe. The contact, an independent mechanic, diagnosed the vehicle and discovered that cylinder #1 had a blown head gasket. The contact determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact's friend to report the failure to the NHTSA Hotline. The failure mileage was approximately 105,000.