1993 Ford Explorer SERVICE BRAKES, HYDRAULIC

THE ABS MODULE FAILED WITHOUT WARNING WHILE DRIVING STRAIGHT ON A CITY STREET AT ABOUT 20 MPH.

TL*- THE CONTACT OWNS A 1993 FORD EXPLORER SPORT. WHEN THE BRAKE WAS APPLIED THE PEDAL WOULD GO TO THE FLOOR AND DID NOT STOP THE VEHICLE. THE BRAKES HAD TO BE APPLIED MULTIPLE TIMES BEFORE THEY ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER 02/13/2008, AND THE VEHICLE OWNER WAS TOLD THAT THE COST OF THE VEHICLE REPAIR WAS HIS RESPONSIBILITY. THERE IS A SAFETY RECALL 94V169001 - PARKING BRAKE CONVENTIONAL. THE CURRENT MILEAGE WAS 46,700, AND THE FAILURE MILEAGE WAS 1,500. UPDATED 03-11-08 *BF

DURING NORMAL OPERATION LEFT REAR BRAKE LINE CRACKED, LOST ALL BRAKE FLUID, MANAGED TO STOP VEHICLE ON IN MEDIAN, HAD VEHICLE TOWED TO REPAIR SHOP, AFTER LEFT REAR BRAKE LINE WAS REPLACED MECHANIC WAS BLEEDING BRAKE SYSTEM, DURING THE PROCESS THE MAIN BRAKE LINE LEADING TO THE REAR BRAKE LINES CRACKED AND DEVELOPED A LEAK, LOST ALL BRAKE FLUID AGAIN!FORTUNATELY THIS TIME IT HAPPENED AT SHOP, HAD ALL BRAKE LINES REPLACED, ADVISED SHOP TO HOLD ON TO OLD (ORIGINAL) BRAKE LINES. *JB

INTERMITENT - ANTI LOCK BRAKES FAILURE. PEDAL DROPS DOWN AND NOISE (GROWL) OCCURS, FOLLOWED BY VEHICAL PULLING TO ONE SIDE WITH LONG STOPPING DISTANCE. RECENT INCIDENT REQUIRED EXTREME BRAKING AND THE BRAKES LOCKED UP AND THE VEHICLE SLID OUT OF CONTROL.*AK

CONSUMER NOTICED WHILE TRAVELING, THE BRAKES WERE SMOKING DUE TO OVER HEATING. DEALER HAD BEEN CONTACTED AND THE BRAKING SYSTEM WAS REPLACED. THE BRAKES CONTINUED TO WEAR OUT ONCE A MONTH, THE BRAKES HAD BEEN RESURFACED, ADJUSTED AND REPLACED 5 TIMES. *AK *TT *JB

VENT HOSE IS ON REAR AXLE HOUSING AND RUBBING ON REAR BRAKE LINE.*AK

WHILE DRIVING NEEDS EXCESSIVE EFFORT TO PROPERLY APPLY BRAKES. CONSUMER HEARS SQUEAKING NOISE.*AK

INSUFFICIENT BRAKING RESULTED IN REAR END COLLISION. 2ND ACCIDENT OF SAME NATURE AFTER FORD SERVICE INSPECTION. INDEPENDENT BRAKE SHOP REPLACED REAR BRAKES AND PROBLEM IS OK. FORD ARGUES THAT BRAKES AND VEHICLE WERE OK. *AK

ONGOING PROBLEM WITH BRAKE CALIPER STICKING AND CAUSING ROTORS TO BE CUT AND WARPED. VEHICLE BEEN TO INDEPENDENT REPAIR SHOP ON FOUR OCCASIONS, AND PROBLEM STILL REOCCURRING. PLEASE FEEL FREE TO PROVIDE US WITH ANY FURTHER INFORMATION CONCERNING THIS MATTER. *AK

THE VEHICLES RIGHT AND LEFT REAR WHEEL BRAKE DRUM BECOMES EXTREMELY HOT AND CONSUMER CAN SMELL AN ODOR OF HOT OIL EMANATING FROM THE WHEEL ONCE PARKED IN GARAGE. NLM

WHILE DRIVING BRAKING PEDAL LINKAGE BROKE WHICH CAUSED NO BRAKING ABILTIY AT ALL, AND RESULTED IN A CRASH. WILL BE TAKING TO DEALER. PLEASE PROVIDE FURTHER INFORMATION.*AK

FRONT DISC BRAKE PADS WEAR ABNORMALLY FAST, I'VE REPLACED THE PADS 5 TIMES IN 100000 MILES OF OPERATION. WHEN DRIVING THIS VEHICLE YOU CAN FEEL THAT MOST IF NOT ALL OF THE BREAKING IS DONE BY THE FRONT BREAKS, I FEEL THAT THE BRAKE DESIGN FOR THIS VEHICLE IS INADAQUATE IT SHOULD HAVE DISC BREAKS INSTALLED IN THE REAR TAKING UP MORE OF THE BRAKING LOAD. *AK

SOMETIMES WHILE BRAKING ON A BUMPY ROAD THE BRAKES RELEASE AND THE PEDAL GOES TO THE FLOOR. IF RE-APPLIED QUICKLY BRAKES WILL WORK, FORTUNATELY I WAS NOT FOLLOWING TO CLOSE TO ANOTHER VEHICLE AND WAS ABLE TO RECOVER. *AK

WHILE DRIVING AND USING BRAKES VEHICLE WILL WOBBLE, AND HAS A TENDENCY TO FLIP OVER. CONSUMER HAS BEEN ON TWO WHEELS AND SLAMMED BACK DOWN TO THE GROUND.*AK

WHILE DRIVING AND COMING TO STOP WOULD STEP ON BRAKE PEDAL BUT VEHICLE WOULD NOT STOP UNLESS PUT INTO A LOWER GEAR. THEN, VEHICLE WILL STOP SLOWLY. *AK

MASTER CYLINDER TO BRAKE BOOSTER STUD SHEARED OFF PROBABLY DUE TO STRESS CORROSION CRACK AS DETAILED IN NHTSA RECALL # 96V024001. BRAKING SERVICE SEVERELY DIMINISHED AS MASTER CYLINDER DEFLECTS TO ONE SIDE WHEN BRAKES APPLIED. FORD REFUSES TO ASSIST IN REPAIR COST EVEN THOUGH THE PROBLEM IS KNOWN TO THEM.

BRAKES LOCK UP ON ICE AND WATER AND WHILE HITTING A BUMP AND APPLYING NORMAL BRAKE PRESSURE. HAVE TAKEN TRUCK TO SEVERAL REPAIR SHOPS; NO ONE SEEMS TO BE ABLE TO FIX PROBLEM INCLUDING DEALERSHIP. *AK

THIS VEHICLE SEEMS TO SUFFER FROM PREMATURE WEARING OUT OF FRONT DISC BRAKES AND ROTORS. NEW PADS AND ROTORS RESURFACING WERE NEEDED AT APPROX 15400 MILES, AND NEW PADS AND COMPLETE NEW ROTORS WERE REQUIRED AT APPROX 28608 MILES. WHEN FORD SERVICE WAS ASKED ABOUT THIS FREQUENT DISC BRAKE REPLACEMENT, THE RESPONSE WAS "THERE IS NOTHING WE CAN DO ABOUT THE DESIGN OF THE VEHICLE. I HAVE FRIENDS WITH EXPLORERS FROM THIS SAME MODEL YEAR WHO HAVE REPORTED EVEN MORE FREQUENT DISC BRAKE AND ROTOR REPLACEMENT. *AK

WHEN DRIVING ANDI APPLYING BRAKES THEY MADE NOISE, AND THERE WAS A LOSS OF TOTAL BRAKING POWER. PEDAL WENT ALL THE WAY TO THE FLOOR. CONSUMER CHECKED THE BRAKING FLUIDS ALL THE TIMES AND ITS ALWAYS FULL THE CONSUMER HAD TWO RECALLS. THE MILEAGE FOR THE FIRST RECALL WAS 35000, AND VEHICLE LOST BRAKING POWER AT 50000 MILES. *AK

WHEN DRIVING AND APPLYING BRAKES, THERE WAS A NOISE AND TOTAL LOSS OF BRAKING POWER. PEDAL WENT ALL THE WAY TO THE FLOOR. THERE WERE TWO RECALLS, BUT PROBLEM PERSISTED. NEED NHTSA HELP IN THIS MATTER. *AK

ABS BRAKE SYSTEM PROBLEM. BRAKE PEDAL LOCKS IN UP POSITION. WON'T GO TO FLOOR. NO BRAKES. HIGH PRESSURE (PERHAPS 300 LB) WILL FORCE PEDAL DOWN AND GET BRAKES. REMOVAL OF ABS FUSE PREVENTS RECURRANCE, BUT NO ABS BRAKING THEN.

THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY HAS DEVELOPED CORROSION AND CRACKED . VEHICLE INCLUDED IN RECALL NUMBER 96V024001. PLEASE GIVE ANY FURTHER DETAILS. *AK

WHILE DRIVING AT 35 MPH, GOING AROUND A CORNER AND APPLYING THE BRAKES, THEY LOCKED UP, CAUSING THE VEHICLE TO SKID, AND CONSUMER HIT A CURB, VEHICLE FLIPPED OVER LANDED ON THE TOP OF THE ROOF OF THE VEHICLE, AND THE PAVEMENT WAS WET. *AK

EA96017; INTERMITTENTLY ABS BRAKING SYSTEM LOCKED UP WHILE IN USE WHICH COULD HAVE RESULTED A CRASH. PLEASE PROVIDE FURTHER INFORMATION. *AK

WHEN DRIVING AT ANY SPEED AND APPLYING THE BRAKES, IT FELT LIKE THE BRAKE PADS WERE CRACKING. VEHICLE HAS BEEN IN REPAIR SHOP NINE TIMES FOR BRAKE PROBLEMS, AND THE DEALER CAN'T DETERMINE THE PROBLEM. *AK