1997 Ford Explorer Visibility

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT NOTICED THAT THE DEFROSTER WAS NOT FUNCTIONING AND THE WINDSHIELD WOULD NOT CLEAR. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE DASHBOARD WOULD HAVE TO BE REMOVED AND THE BLENDING CHAMBER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000. UPDATED 07/10/13*LJ UPDATED 07/12/13 *JS

WAITING AT A TRAFFIC LIGHT THE SUNROOF SHATTERED NOTHING BUT RAIN HAD FALLEN ON THE VEHICLE. *TR

HAVE EXPERIENCED PERIODS WHEN THE WINDSHIELD WIPERS DO NOT OPERATE WHEN THE CONTROL IS ON. HAS OCCURRED WHEN FIRST TURNING ON THE CONTROL AS WELL AS WHEN CHANGING FROM A DIFFERENT SPEED SETTING ON THE CONTROL. NO REGULARITY IN THE OCCURRENCE, SEEMS TO BE RANDOM. THIS HAS OCCURRED MANY TIMES DURING MY OWNERSHIP SINCE 2000. I WAS CHECKING THE DATABASE AND FOUND AN ENTRY ON THIS PROBLEM UNDER "DEFECT INVESTIGATIONS" SO I AM ADDING MY EXPERIENCE TO YOUR RECORDS. *TR

BLEND DOOR ON MY 1997 FORD EXPLORER IS NOT WORKING. ITS A PROBLEM WHEN DEFROSTING, AND DRIVING IN BAD WEATHER DUE TO THE FACT THAT THE WINDSHIELD IS NOT DEFROSTING. *TR

TL*THE CONTACT OWNS A 1997 FORD EXPLORER SPORT. THE WINDSHIELD WIPERS AT ANY SPEED OTHER THAN HIGH DIDN'T OPERATE NORMALLY. WHEN THE RAIN WAS HEAVY OR LIGHT THE WINDSHIELD WIPERS ONLY OPERATED ON HIGHER SPEEDS. THE FAILURE MILEAGE WAS 116000 ,AND THE CURRENT MILEAGE WAS 126000. *AK

DT*: THE CONTACT STATED DUE TO THE HEATER BEING INOPERABLE, THE DEFROSTER DID NOT OPERATE. THE VEHICLE WAS DRIVEN TO THE DEALER, WHO DETERMINED THE BLEND DOOR NEEDED TO BE REPLACED.

I AM THE ORIGINAL OWNER OF THIS 1997 FORD EXPLORER. AFTER A FEW YEARS, I STARTED TO HAVE PROBLEMS WITH THE HEAT/DEFROST. I HAVE HAD THIS REPAIRED TWICE COSTING AROUND $2000 TOTAL. ONCE AGAIN, I NO LONGER HAVE HEAT/DEFROST AND AM SCHEDULED FOR AN EVALUATION NEXT MONDAY. DURING SNOW AND RAIN, NOT ONLY ARE YOU MISERABLE BECAUSE OF THE COLD BUT IT IS DANGEROUS WHEN YOU ARE TRYING TO CLEAR THE CONDENSATION OFF THE WINDOW TO HAVE COMPLETE VISIBILITY. *JB

BOUGHT EXPLORER IN THE SUMMER OF 2006, WENT TO TURN ON THE HEAT ONLY BLOWS COLD AIR UNABLE TO DEFROST WINDOWS. THIS IS A 1997 EXPLORER THAT AFTER TALKING TO THREE DIFFERENT DEALERSHIPS TOLD ME THAT THEY ALL DO BREAK AND THAT FORD HAS MADE A STRONGER BLEND DOOR TO REPLACE THE DEFECTIVE ONE AND THEY WOULD BE HAPPY TO REPLACE FOR A COST OF 1200.00. AFTER SPEAKING TO FIVE OR SIX DIFFERENT REPAIR SHOPS AND FINDING THE ARTICLE BY LARRY HAMMER OF MIGHTY AUTO PARTS I BELIEVE THAT FORD HAS A RESPONSIBILITY FOR ITS ADMITTED FACTORY DESIGN FLAW. *NM

DT*: THE CONTACT STATED IN AN ATTEMPT TO DEFROST THE WINDSHIELD, NO HEAT WAS PRODUCED. THE VEHICLE WAS DRIVEN TO THE DEALER, WHO DETERMINED THE BLEND DOOR NEEDED TO BE REPLACED.

THE BLEND DOOR ON MY 1997 FORD EXPLORER FAILED. THIS FAILURE DID NOT ALLOW PROPER DE-FOGGING OF THE WINDSHIELD. *NM

THE HEATER BLEND DOOR FAILED ON MY 1997 FORD EXPLORER WHILE DRIVING IT IN SNOWY CONDITIONS. I ONLY HAD COLD AIR BLOWING ON MY WINDOWS. AFTER REVIEWING WEB SITES, I HAVE FOUND THAT THE TOP PIECE OF MY HEATERS HOT AND COLD BLEND DOOR IS BROKEN. THE COST OF REPLACING THIS ONE PIECE OF PLASTIC IS AROUND $1000. FORD HAS A REPLACEMENT PART THAT IS NOW STRONGER, BUT FAILS TO REALIZE THE DEFECT IN THE OLDER DOORS. *NM

1997 FORD EXPLORER DEVELOPED A DEFECT IN THE DEFROSTER AND DEFOGGER SYSTEM. *MR THE PROBLEM WAS DUE TO A BROKEN PLASTIC DOOR IN THE A/C/HEATER PLENUM. THIS CREATED A CONDITION OF FOGGING THE WINDSHIELD UNCONTROLLABLY AND IMPAIRING THE DRIVERS VISION. *SC

TEMPERATURE OUT OF CONTROL, DEFOGGING/DEFROSTING CHALLENGED ON A 1997 FORD EXPLORER. WAS TOLD IT WILL IT IS DUE TO DEFECT IN THE AIR BLEND DOOR. I CAN'T DEFROST THE WINDOWS WHICH COULD BE AN ACCIDENT WAITING TO HAPPEN. *NM

DT: CONTACT STATED WHILE USING THE DEFROSTER SYSTEM THE WINDSHIELD CRACKED FROM THE OUTSIDE TO THE INSIDE. VEHICLE HAD NOT BEEN TO A SERVICE DEALER, BUT WAS SCHEDULED TO BE TAKEN IN THIS WEEK. *AK

I OWN A 1997 FORD EXPLORER THAT SINCE ITS BEEN PURCHASED THE AIR CONDITIONING AND THE HEAT WERE ALWAYS GIVING ME PROBLEMS, I HAVE SINCE FOUND OUT THAT ITS A PROBLEM WITH ALMOST EVERY FORD EXPLORER OUT ON THE ROADS TODAY. THIS IS A MAJOR CONCERN TO ME DUE TO WINDOW DEFROSTING DURING THE WINTER MONTHS, THE BLEND DOOR HAS A MIND OF ITS OWN AND WILL OPEN AND CLOSE AT ANY TIME. PLEASE ADVISE ME ON HOW I CAN GET THIS LOOKED INTO. I BELIEVE THAT FORD SHOULD BE RESPONSIBLE FOR THIS AND THEY BELIEVE THAT THEY DONT. THANK YOU FOR YOUR TIME

BLEND DOOR CRACKED ON 1997 FORD EXPLORER, CAUSING LACK OF ABILITY TO DEFROST WINDOWS. I LIVE IN WISCONSIN AND THE WINDOWS FOGGED UP BADLY. VERY DIFFICULT TO DRIVE WHEN IT'S 20 BELOW OUT AND THE DEFROSTER DOESN'T WORK. COST TO REPLACE AIR PLENUM WITH REVISED, REDESIGNED ONE ABOUT $900. *AK

HEATER IN VEHICLE BECAME INOPERATIVE DURING A SLEET AND ICE STORM. HEATER BLEND DOOR FAILED CAUSING ONLY COLD AIR TO BLOW OUT OF HEATER AND DEFROSTER, WINDSHIELD AND WINDOWS FOGGED UP AND I COULD NOT SEE THE ROAD. HEATER BOX AND BLEND DOOR REPLACED THAT COST ME $700.00. 8NM

HEATER/AC TEMPERATURE CONTROL. TEMPERATURE CONTROL DOOR IS STUCK IN THE POSITION FOR HEAT. HAVE TALKED TO DEALER THEY SAY INEXPENSIVE PART, LABOR FOR REPAIR IS ABOUT 7 HOURS TO BE CHARGED FOR. THIS DEALER HAS HAD OTHER COMPLAINTS AND FIXED SOME. CHECKED WITH OTHER DEALERS IN AREA, THEY GAVE SAME ANSWER AS TO COST AND COMPLAINTS. I AM TOLD THIS IS A PLASTIC BRACKET ON DOOR ASSEMBLY THAT BREAKS WHEN SERVO MOVES DOOR TO CONTROL HOT OR COOL AIR FLOW.*AK

HEATER BLEND DOOR ON MY 1997 FORD EXPLORER DOES NOT CHANGE POSITIONS. IT IS STUCK IN THE POSITION ONLY GIVING ME AIR CONDITIONING FULL TIME. NO MATTER WHERE THE DIAL ON THE DASH IS TURNED THE HEAT REFUSES TO ACTIVATE. THROUGH A QUICK SERIES OF ODD WEATHER OCCURRENCES I FOUND MY WINDSHIELD COVERED IN A LAYER OF ICE THAT COULD NOT BE REMOVED SINCE THE HEAT DID NOT WORK ON THE DEFROSTER. THIS ALMOST CAUSED A NEAR FATAL HEAD-ON COLLISION. I HAVE NO OPTION NOW BUT TO HAVE THE HEATER PLENUM REPLACED AT A COST $1010. *NM

THE HEAT ACTUATOR "BROKE" AND ELIMINATED ANY HEAT TO DEFROST MY WINDOWS. *AK

THE HEATING SYSTEM STOPPED OPERATING AND CAUSED POOR VISIBILITY TO THE DRIVER BECAUSE THE WINDSHIELD COULD NOT BE DEFROSTED. AN INDEPENDENT AUTO MECHANIC DETERMINED THAT THE ENTIRE HEATING SYSTEM NEEDED TO BE REPLACED. *NM

THE BLEND DOOR IS BROKEN ON MY HEATER...EVER TRY TO DEFROST A WINDOW WHEN IT IS MINUS 5 WITH THE AIR CONDITIONER ON..? THIS NEEDS TO BE ADDRESSED IN A RECALL CAMPAIGN IT IS POORLY DESIGNED AND DANGEROUS! *AK

TEMPERATURE CONTROL BLEND DOOR DOES NOT WORK PROPERLY. STUCK ON COLD. UNABLE TO DEFROST AND DEFOG WINDOWS. *LA

MY HEATER TEMPERATURE CONTROL BECAME INOPERATIVE. THE BLEND DOOR INSIDE THE PLENUM CHAMBER IS BROKEN AND NO LONGER MOVES (ON FULL HEAT). THE NEW PLENUM CHAMBER NOW CONTAINS A NYLON DOOR IN STEAD OF PLASTIC. THIS LOOKS LIKE FORD KNOWS THERE IS A PROBLEM WITH THE OLD STYLE DOORS BUT WILL NOT GIVE ANY ASSISTANCE ON REPAIRS. THE COST OF REPAIR IS STEEP! I WAS QUOTED $108.00 FOR THE PLENUM CHAMBER AND $598.00 TO INSTALL IT. FROM WHAT I HAVE LEARNED THE PROBLEM IS NOT ISOLATED TO ME, IN FACT THE DEALER I PHONED HAD JUST SOLD A REPLACEMENT PLENUM THE PREVIOUS DAY AND WAS WAITING FOR ONE TO ARRIVE TO FILL THERE STOCK. WHEN A DEALER STOCKS A PART THERE USUALLY IS A LARGE DEMAND FOR IT! *NLM

CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING REAR WINDOW SHATTERED. DEALER NOTIFIED. *AK