2011 Ford Explorer Power Train

The wheel locks in low speeds. It does not happen often, maybe about 3 times per year. I have brought this up to Ford dealer in Encinitas CA for several years and the problem is seldom that they did not find anything wrong with it. Recently I found the recall online and brought it to their attention. I never received the notice of recall back in 2015. They are refusing service because it has been more than 10 yrs since the recall and my vehicle is at 180,000 miles. I use the car to carpool my kids and other people's kids. Please help fix the problem.

The power steering system fault failed .Yes, the power steering system is available for inspection upon request.The failure of the power steering system put my safety and the safety of others at risk because it became extremely difficult to steer the vehicle, especially at low speeds, which could have led to a loss of control and potential accidents.Yes, the problem has been reproduced and confirmed by SUBURBAN FORD OF TROY .The vehicle has been inspected by SUBURBAN FORD OF TROY.There were no warning lamps or messages prior to the failure. The issue first appeared suddenly while driving on September 14, 2024.

The contact owns a 2011 Ford Explorer. The contact stated that on five different occasions while driving at various speeds, the power steering warning light illuminated, and the steering wheel became firm, making it difficult to steer the vehicle. The contact stated that on one occasion, the vehicle was towed to a dealer where the contact was informed that the power steering gear needed to be replaced. The vehicle was repaired; however, the failure recurred a week later. The manufacture was notified of the failure. The failure mileage was approximately 120,000.

Driving along and the power steering assist went out. I called dealer and they said if it was over 10 years they didnt have to repair it. According to your website, It has a 15 year window. Please advise

Between 7/17/20 and 9/7/20 car stalled five times and stopped moving while in drive mode with no warning. Dealer kept car from 7/30/20 to 8/7/20, but problem was not fixed. Car returned to dealer 9/8/20 and kept by them until 9/16/20 when it was returned with problem apparently fixed. No problem since. Diagnosed Throttle Body Failure. Have verifying work order and invoice.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE CONTACT ENTERED AND STARTED THE VEHICLE. THE VEHICLE WAS SHIFTED INTO REVERSE HOWEVER, WHILE TURNING THE STEERING WHEEL THE VEHICLE FAILED TO OPERATE AS DESIGNED. THE POWER STEERING WARNING LIGHT BECAME ILLUMINATED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT SPOKE WITH A REPRESENTATIVE AT TONY SERRA FORD (40905 HIGHWAY 280, SYLACAUGA, AL 35150 (256) 245-5000) AND WAS INFORMED THAT THE VEHICLE WAS NOT UNDER RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000.

RANDOMLY HAS A AWD FAULT WARNING. LOSES TRANS POWER. REQUIRES STOP. SHUT OFF & RESTART. DANGEROUS! HAS HAPPENED OF FREEWAY SEVERAL TIMES. DEALER FOUND NO RECORD SAVED???? JUST HAPPENED AGAIN YESTERDAY!!!

SECOND (2ND) OCCURRENCE. VEHICLE AS BACKED INTO DRIVEWAY AND PARKED WEDNESDAY FEBRUARY 20,2019. THURSDAY FEBRUARY 21, 2019 AT APPROXIMATELY 7:00 AM, IT WAS OBSERVED THE THE VEHICLE HAD ROLLED BACKWARDS APPROX. 13 FEET ON ITS OWN. VEHICLE WAS LOCKED AND TRANSMISSION WAS IN PARK. APPROXIMATELY 7:15 AM IT WAS OBSERVED THAT THE ROLLED APPROXIMATELY 16 INCHES MORE WITH THE BACK BUMPER RESTING AGAINST THE WALL. THIS EVEN IS DOCUMENTED WITH PICTURES. FIRST (1ST) OCCURRENCE VEHICLE WAS PARKED NOSE FIRST IN DRIVEWAY ON FEBRUARY 11, 2019. FEBRUARY 12, 2019 AT APPROXIMATELY 8:00 AM, MY WIFE HAD ASKED IF WE HAD MOVED THE VEHICLE FORWARD BECAUSE THE FRONT OF VEHICLE WAS ALMOST TOUCHING THE WALL. THE VEHICLE WAS LOCKED AND IN PARK. THE WEATHER ON BOTH OCCURRENCES WAS SNOW THEN RAIN. UNABLE TO ATTACH PHOTOS DUE TO FILE SIZE.

SHIFTER DOES NOT ENGAGE INTO PARK AND WARNING LIGHT COMES ON. WILL NOT ENGAGE MY SEAT TO SLIDE BACK AFTER PUTTING IT INTO PARK. MY CAR WAS STATIONARY EVERY TIME. ALTHOUGH, THE PERSON WHO REALISED IT WAS NOT SHIFTING INTO PARK WAS THE FORD DEALERSHIP. AND NOW IVE NOTICED IT EVERY TIME. NO MATTER HOW MANY TIMES I RESTART MY CAR IT WELL NOT SHIFT INTO PARK. I MUST APPLY THE PARKING BRAKE. FORD HAS NUMEROUS RECALLS ON VEHICLES FOR THE SAME PROBLEM, HOWEVER THE FORD EXPLORER IS NOT....WHY? AFTER LEAVING DEALERSHIP I WAS GIVEN THE PARTS LIST FOR THE SHIFTING ISSUES, WHICH IS A SAFETY CONCERN THAT SHOULD HAVE BEEN FIXED BY FORD.

CAR LOSSES POWER WHILE IN MOTION. FRIST TIME NEAR MY HOME. SECOND TIME WHILE DRIVING IN TOWN. STOP, TURN OFF MOTOR THEN BACK ON AND MESSAGE IS GONE. MY CAR HAS DONE THIS TWICE NOW. DO NOT TRUST MY CAR TO DRIVE FAR FROM HOME. THROTTLE BODY ASSEMBLY IS HAVING ISSUES AND UNDERSTAND IT'S BEEN RECALLED ON A DIFFERENT FORD CAR BUT NOT EXPLORER. MOST LIKELY SAME THROTTLE ASSEMBLY!

ON 8/24/2017, WHILE I WAS DRIVING ON GARDEN STATE PARKWAY, NJ, APPROACHING TOLL GATE NEAR EXIST 114, SUDDENLY THE INDICATOR LIGHTS SHOWED AWD OFF AND I LOST ALL POWER. I WAS ABLE TO COAST THROUGH THE TOLL GATE BUT COULD NOT ACCELERATE ANYMORE. I WAS ABLE TO PARK ON ROAD SHOULDER. I DISMISSED INDICATOR AWD OFF WARNING BY CLICK "OK" BUT IT KEPT COMING BACK AND I CANNOT DRIVE FORWARD ANYMORE. MEANWHILE, THE TERRAIN MANAGEMENT SYSTEM INDICATION LIGHT GOT OFF. I STOPPED ENGINE AND RESTARTED ENGINE, AND EVERYTHING WAS BACK TO NORMAL. THIS IS A SERIOUS LOSE POWER ISSUE THAT MANY OTHER FORD EXPLORER OWNERS REPORTED. THERE IS A PE13003 NHTSA RECALL BUT THIS DOESN'T COVER FORD EXPLORER, EVEN I BELIEVE MANY OTHER FORD CARS (LIKE FORD EDGE) SHARE SAME PARTS WITH EXPLORER. IF I LOST POWER WHEN I DRIVE IN HIGH SPEED, I MAY END UP WITH MAJOR CAR ACCIDENT!!!

ELECTRONIC THROTTLE BODY ISSUE - OVER THE LAST 30 DAYS, MY 2011 FORD EXPLORER HAS STALLED LEAVING ME WITH NO POWER TO CONTROL MY SPEED. LUCKILY THE TIMES THIS HAS HAPPENED, I HAVE BEEN ON CITY STREETS DRIVING 30-40 MPH. A WARNING GOES OFF STATING "AWD OFF" AND THEN A PICTURE OF A WRENCH APPEARS AND I LOSE ALL SPEED AND AM FORCED TO LIMP OFF THE ROAD. I AM ABLE TO SHIFT INTO PARK, TURN THE VEHICLE OFF AND THEN START BACK UP. AFTER THE FIRST INCIDENT, I TOOK THE VEHICLE TO THE LOCAL FORD DEALER AND THEY WERE UNABLE TO DETECT THE ERROR CODE AND SAID IT WAS LIKELY A FLUKE. SINCE THAT VISIT TO THE DEALERSHIP, MY VEHICLE HAS HAD THIS ISSUE ON MULTIPLE OCCASIONS. TODAY, IT HAPPENED 4 TIMES WHICH HAS LEFT ME TO FEAR DRIVING ON THE HIGHWAY OR INTERSTATE FOR SAFETY REASONS. AFTER DOING ONLINE RESEARCH, IT APPEARS THAT THE ISSUE IS VERY SIMILAR TO THE ETB ISSUES THAT FORD OPENED UP "CUSTOMER SATISFACTION PROGRAM 13N03" BUT UNFORTUNATELY IT DID NOT INCLUDE FORD EXPLORERS.

I HAVE A 2011 FORD EXPLORER AND I ABSOLUTELY HATE IT !!! EVER SINCE I PURCHASED THE VEHICLE , I HAVE HAD MANY PROBLEMS. I JUST HAD MY POWER STEERING RACK REPLACED , OUT OF POCKET, UNTIL FORD DECIDED TO RECALL IT. NOW, I HAD TO REPLACE THE TRANSFER CASE , WHICH IRONICALLY WENT BAD OUT OF NO WHERE. THE TRANSFER CASE IS A MAJOR ISSUE WITH FORD VEHICLES AND FORD REFUSES TO RECALL IT . I HAVE HAD MANY MANY PROBLEMS WITH

DRIVING AT SPEED LIGHT ON THE STREET AT 35-40 MILES AND ALL OF THE SUDDEN THE SPEED GOES DOWN TO ABOUT 5MILES AND STARTS TO SHAKE AND A WRENCH LIGHT APPEARS ON THE DASH BOARD AND I HAVE TO PULL OVER AND TURN OF THE CAR WAIT ABOUT 5-10 MINS TURN IT BACK ON AND WORKS PERFECTLY NORMAL ABOUT, THIS HAS HAPPEND ONCE EVERY WEEK FOR THE PAST 4 WEEKS, LAST WEEK WE TOOK IT TO THE DEALER FOR SEVERAL RECALLS THE CAR HAD, AND TOKD THEM ABOUT IT BUT THEY DIDNT SAY ANYTHING. THEIRS NEED TO BE A RECAL ON THIS BECAUSE THIS IS A SERIOUS DANGEROUS SITUATION

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING 35 MPH, THE VEHICLE FELT AS IF THE TRANSMISSION ATTEMPTED TO SHIFT GEARS INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING 35 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE SERVICE VEHICLE SOON WARNING LIGHT ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE. IN ADDITION, WHILE DRIVING, THE VEHICLE FAILED TO DOWNSHIFT. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

WHILE DRIVING 65 MPH ON THE INTERSTATE, I HEARD A DING, SAW A LARGE WRENCH ICON ON THE LEFT SIDE OF THE DASH, AND I LOST ALL ACCELERATOR POWER. MY CAR SLOWED TO A CREEP. THE AUTO PROPULSION MECHANISM WOULD DRIVE IT ABOUT 2 MPH, AND I COULD PUSH THE ACCELERATOR TO THE FLOOR AND NOTHING HAPPENED. *TR

I REVIEVED SAFETY RECALL NOTICE 14S06/NHSA RECALL 14V-286 FROM FORD MOTOR COMPANY IN DEARBORN, MICHIGAN INFORMING ME THAT A RECALL WAS TO BE PERFORMED ON MY POWER STEERING. THE NOTICE ALSO STATED THAT THE POWER STEERING GEAR WOULD BE REPLACED UNDER WARRANTY FREE OF CHARGE (PARTS AND LABOR) SHOULD IT FAIL BEFORE 150,000 MILES OR THE END OF DECEMBER 2015. "THE LOSS OF POWER STEERING EFFORT, ESPECIALLY AT LOW SPEEDS, WHICH MAY INCREASE THE RISK OF CRASH" WAS STATED IN THE LETTER. I TOOK MY VEHICLE TO THE LOCAL FORD DEALER(SOUTHWEST FORD OF GREENVILLE, TEXAS) AND WAS TOLD THAT THE PROGRAMMING OF THE POWER CONTROL MODULE WAS COMPLETE BUT THEY COULD NOT REPLACE THE POWER STEERING GEAR UNLESS DIRECTED BY FORD TO DO SO. THE LETTER STATED THE GEAR WOULD BE REPLACED AT NO CHARGE (PARTS AND LABOR) IF THE GEAR IS REPLACED BEFORE 150,000 MILES ON THE VEHICLE, OR DECEMBER 31, 2015. THE FORD DEALER SERVICE DEPARTMENT SAID THEY ARE NOT AUTHORIZED TO REPLACE THE GEAR UNLESS DIRECTED BY FORD HOME OFFICE. IF THIS IS A KNOWN SAFETY ISSUE I WOULD LIKE TO HAVE IT REPLACED BEFORE IT FAILS. I AM NOT CLOSE TO THE 150,000 MILES BUT THE END OF 2015 IS NEAR.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED AFTER THE POWER TRAIN WARNING INDICATOR ILLUMINATED. THE VEHICLE DID RESTART, HOWEVER, THE VEHICLE FAILED TO RESPOND PROPERLY WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS TOWED TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED, HOWEVER, THE FAILURE RECURRED ON THREE OTHER OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 34,147.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. AFTER PARKING THE VEHICLE, THE SHIFT TO PARK WARNING INDICATOR ILLUMINATED. THE DEALER STATED THAT THE SHIFT TO PARK SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 27,000.

THE VEHICLE WHEN SHIFTED INTO PARK WOULD NOT SHUT OFF, WITH THE VEHICLE NOT SEEING THE SHIFTER IN PARK. ON INSPECTION IN SEPTEMBER 2014, IT WAS DETERMINED THAT THE SHIFT LEVER WAS FAILING, WHICH CAN CAUSE THE VEHICLE TO SLIP OUT OF PARK AND MOVE UNEXPECTEDLY. FORD INDICATED THERE WAS NOT A RECALL ON THIS AT THIS TIME AND WOULD NOT COVER ANY REPAIR WORK FOR THIS SERIOUS SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD JERK VIOLENTLY. IN ADDITION, THE VEHICLE WOULD DECELERATE ON ITS OWN AND FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE DEALER RE-INSTALLED THE SOFTWARE, TRANSMISSION SENSOR, AND SHIFT CONTROL CABLE, BUT THE FAILURES RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 20,652.

MY DAUGHTER AND I WERE DRIVING ABOUT 55 MPH ON A HIGHWAY, AND ALL OF A SUDDEN THE TRUCK LOST POWER. ALL OF A SUDDEN AN ORANGE WRENCH SYMBOL APPEARED ON MY INSTRUMENT PANEL, BUT I HAD NO IDEA WHAT IT MEANT. VERY SCARED, I PUT ON MY HAZARD LIGHTS AND HAD TO MOVE TO THE RIGHT IN 3 LANES OF TRAFFIC!! I WAS SO TERRIFIED A CAR OR TRUCK WAS GOING TO SMASH INTO THE BACK OF OUR VEHICLE. THE TRUCK WAS ONLY ABLE TO GO ABOUT 5 MPH EVEN THOUGH I WAS PUSHING THE GAS PEDAL AS FAR DOWN AS POSSIBLE. WHEN WE FINALLY WERE ABLE TO PULL OVER, I TURNED OFF THE TRUCK. I THEN LOOKED THROUGH THE FORD MANUAL TO TRY AND IDENTIFY THE ORANGE WRENCH SYMBOL, WHICH WAS LIT UP IN MY INSTRUMENT PANEL. IT INDICATED THAT THE VEHICLE HAD A POWER TRAIN MALFUNCTION. AFTER WAITING 15 MINUTES I THEN STARTED THE TRUCK UP, WITH SUCCESS. THE TRUCK SEEMED TO BE WORKING AGAIN AND ODDLY ENOUGH THE ORANGE WARNING SYMBOL HAD DISAPPEARED. THERE WERE NO WARNING SYMBOLS AT ALL ANYMORE. I DROVE IT IMMEDIATELY TO OUR FORD DEALERSHIP. I HAD TO GET A RENTAL BECAUSE THEY WERE SO BUSY AND TOLD ME THEY WOULDN'T BE ABLE TO LOOK AT IT UNTIL THURSDAY. THIS AFTERNOON (24 HRS. LATER) FORD CALLED AND TOLD ME WE NEEDED A NEW THROTTLE BODY PART ($650). THIS TRUCK IS ONLY 3 YEARS OLD!! WE COULD HAVE BEEN SERIOUSLY INJURED. I THANK GOD WE WEREN'T AS THIS IS A VERY ACTIVE HIGHWAY. *TR

I WAS IN A PARKING LOT WHEN MY STEERING WHEEL LOCKED UP AND A SERVICE POWER STEERING LIGHT CAME ON. I TURNED THE CAR OFF AND IT FIXED ITSELF HOWEVER I WAS DRIVING ON THE 12TH ON THE HIGHWAY AND IT HAPPENED AGAIN. *TR

I WAS TAKING MY KIDS TO SCHOOL AND WAS ACCELERATING AFTER A STOP. THE POWER STEERING WENT OUT AND I LOST ALL POWER. THE POWERTRAIN MALFUNCTION LIGHT CAME ON WITH THE WRENCH SYMBOL. I WAS ABLE TO GET INTO A DRIVEWAY AND TURN THE CAR OFF. WHEN I RESTARTED IT EVERYTHING WAS BACK TO NORMAL. FIVE DAYS LATER I WAS AGAIN DRIVING WITH KIDS. THIS TIME I WAS GOING ABOUT 35 MPH ON A ROAD WITH NO SHOULDER. THE CAR LOST POWER. I WAS ABLE TO GET THE HAZARD LIGHTS ON AND RESTART IT BEFORE I WAS REAR ENDED. THIS COULD HAVE CAUSED A SERIOUS WRECK. THE DEALERSHIP SERVICE DEPARTMENT SAID THEY COULD NOT DUPLICATE THE ISSUE AND THERE WAS NO HARD FAULT DETECTED BY THE CAR'S COMPUTER. SO I JUST GET TO KEEP ON DRIVING AND HOPING FOR THE BEST. *TR