1994 Ford F-250 Fuel System

TL* THE CONTACT OWNS A 1994 FORD F-250. THE CONTACT STATED THE FUEL PRESSURE REGULATOR HAS WORN OUT AND CAUSE FUEL TO LEAK IN ONE OF THE DUAL FUEL TANKS. THE FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A VEHICLE FIRE. THE CONTACT NOTICE A RECALL FOR THE PREVIOUS YEAR MODEL REGARDING THE FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY (00V424000). HE HAD NOT CALLED THE MANUFACTURER TO SEE IF HIS VEHICLE IS INCLUDED IN THIS RECALL. THE CONTACT STATED THE VEHICLE CAN CAUSE A FIRE WHILE DRIVING. THE FAILURE MILEAGE WAS 79,000.

FUEL FLOWING FROM FUEL TANK FILLER CAP. 1994 FORD F-250 WITH DUAL FUEL TANKS HAS CONDITION WHICH OVERFILLS TANK AND CAUSES STEADY FUEL FLOW FROM FILLER CAP. CORRECTIVE ACTION REQUIRED REPLACING BOTH FUEL PUMP ASSEMBLIES. THERE ARE MULTIPLE COMPLAINTS OF THIS CONDITION IN THIS DATABASE, UNFORTUNATELY THEY ARE SPREAD THROUGH VARYING CATEGORIES. MANUFACTURER WARRANTED SAME CONDITION FOR PREVIOUS MODEL YEAR (1993) BUT WAS UNRESPONSIVE TO INQUIRIES REGARDING 1994 MODEL YEAR.*AK

WHEN FILLING UP ONE TANK IT CAUSED OTHER TANK TO OVERFLOW. *AK CONSUMER STATES THAT 1993 MODELS HAVE BEEN RECALLED. *YH

EXHIBITING SAME SYMPTOMS AD NHTSA CAMPAIGN 00V231000. *AK

VEHICLE NOT INCLUDED IN RECALL 00V424000. A MALFUNCTIONING CHECK VALVE ALLOWS FUEL TO TRANSFER FROM ONE TANK TO ANOTHER, RESULTING IN FUEL LEAKAGE. *AK

THE FUEL PUMP IN THE FRONT TANK PUMPS FUEL FROM THE REAR TANK TO THE FRONT TANK CAUSING THE FRONT TANK TO OVERFLOW WHILE DRIVING, FORD REFUSES TO DO ANYTHING ABOUT THE PROBLEM. NLM

REAR DUAL GAS TANK MALFUNCTIONS AND FUEL ODOR COMES OUT OF IT. YH

THE DUAL FUEL TANKS MALFUNCTIONED CAUSING GAS LEAKAGE. YH

FUEL OVERFLOWS OUT OF FILLER CAP FIRE HAZARD. *AK

WHILE TOWING OUR 5TH. WHEEL TRAILER IN THE CURB LANE ON AN INTERSTATE HIGHWAY, WE EXPERIENCED A BLOW OUT WHICH ACTUATED THE EMERGENCY FUEL SHUT OFF VALVE. THE RIGHT, FRONT TRUCK TIRE BLEW OUT AND THE ASSOCIATED BUMPY/SHUDDERING APPARENTLY CAUSED THE FUEL SHUT OFF VALVE TO CLOSE. WE WERE ABLE TO PULL OFF THE HIGHWAY, BUT WITH CONSIDERABLE DIFFICULTY. WHEN THE FUEL STARVED MOTOR SHUT DOWN WE LOST POWER STEERING AND POWER BRAKES WHICH ADDED TO THE DIFFICULTY CONTROLING THE RIG. NOBODY WAS INJURED AND WE WERE ABLE TO INSTALL THE SPARE TIRE AND RE-SET THE FUEL VALVE. OUR CONCERN IS THAT THE FUEL SHUT OFF VALVE MAY HAVE ACTUATED TOO EASILY. IF WE HAD BEEN TRAVELING IN THE CENTER LANE THERE IS A GOOD CHANCE WE WOULD HAVE BEEN UNABLE TO REACH THE SAFETY OF THE MEDIAN OR SHOULDER OF THE HIGHWAY.( DOT NUMBER: TIRE SIZE: LT23585R16 )

THE SEAM ON THE FRONT FUEL TANK HAS A LEAK IN IT AT 25,800 MILES. THE DEALER HAS BEEN CONTACTED. *AK

FUEL PUMP FAILURE, CAUSING VEHICLE TO STALL. *SD