2005 Ford F-250 Steering

THE FORD 250 INITIATES A 'DEATH WOBBLE' OR INTENSE SHIMMY IN THE FRONT WHEELS AT SPEEDS GREATER THAN 50 MPH ANYTIME ANY SMALL BUMP IS ENCOUNTERED ON ROAD. THIS INSTANCE INITIATED 5 TIMES IN A 500 MILE HIGHWAY TRIP AT SUCH AN INTENSE RATE THAT THE VEHICLE LOST SIGNIFICANT STEERING CONTROL AND HAD TO BE IMMEDIATELY DECELERATED TO NEARLY 20 MPH FOR IT TO STOP. INITIAL SPEED WAS CLOSE TO 63 MPH. THE SHIMMY INITIATED WHEN A SMALL BUMP IS PASSED OVER AND ON THREE OF THESE INSTANCES IT INITIATED WITH THE CROSSING OF A EXPANSION GAP OR TRANSITION FROM THE HIGHWAY TO A BRIDGE OR BRIDGELIKE STRUCTURE. THE WOBBLE SHOOK TRUCK SO MUCH THAT DIRECTIONAL CONTROL WAS LOST. APPROACHING (TRAFFIC FROM THE REAR) HAD TO SWERVE OUT OF THEY WAY TO AVOID A REAR COLLISION. IF DECELERATION IS NOT IMMEDIATELY IMPOSED THE VEHICLE MAINTAINS THE SHIMMY AND DIRECTIONAL CONTROL IS SEVERELY COMPROMISED. IN TWO INSTANCES ON THIS TRIP I WAS ABLE TO NURSE THE WOBBLING VEHICLE OFF THE ROAD TO THE SHOULDER TO THEN BRAKE TILL CONTROL COULD BE RETRIEVED. HOWEVER, THERE ARE MANY INSTANCES WHEN ACCESS TO THE RIGHT SIDE IS IMPEDED SUCH AS WHEN PASSING IN LEFT LANE. THE SAME ISSUE HAS HAPPENED BEFORE ON A HIGHWAY TRIP TO ANOTHER STATE 6 MONTHS BEFORE.

ON MY 2005 FORD DIESEL F250,AFTER 126000 MILES, STEERING BECAME VERY LOOSE. HAD ENTIRE FRONT END REPLACED INCLUDING GEAR BOX. REBUILDER PURCHASED MOTOCRAFT REBUILT STEERING BOXES FROM FORD. FOUR OF THESE REBUILT BOXES WERE TRIED ON THE TRUCK. NONE WERE ANY GOOD. BUILDER SAID THAT THIS WAS A COMMON PROBLEM WITH FORD GEAR BOXES. THEY INDICATED THAT THE GEAR BOX REBUILDERS ONLY REPLACED THE BEARINGS, NOT THE WORN-OUT GEARS WITHIN THE BOX. THE FORTH GEARBOX INSTALLED WAS EVEN WORSE, IT WAS DANGEROUS. WHEN DRIVING ON THE FREEWAY THE TRUCK WOULD VEER WITHOUT WARNING INTO ANOTHER LANE AND WOULD BE VERY DIFFICULT TO CORRECT. THE TRUCK IS BACK IN THE SHOP AGAIN. THIS TIME TO BUY AN AFTER MARKET (NON FORD) GEAR BOX. THIS VEHICLE'S FRONT END PROBLEM HAS SO FAR COST ME OVER $4000. IN REPAIRS, BUT , WHAT IS WORSE THESE GEAR BOX REPLACEMENTS COULD CAUSE AN ACCIDENT.

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55 TO 60 MPH, A POT HOLE WAS HIT AND CAUSED THE VEHICLE TO SHIMMY AND SHAKE OUT OF CONTROL. THE BRAKE WAS ENGAGED WHILE AT HIGHWAY SPEEDS TO BRING THE VEHICLE UNDER CONTROL. THE DEALER ADVISED THAT THE TIE RODS FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 97,000.

I STARTED THIS TRIP AT THE KENTUCKY HORSE PARK, I-75 AT EXIT 120. I HAD BEEN DRIVING AN HOUR, HEADING NORTH. THIS INCIDENT TOOK PLACE LATE AFTERNOON, BETWEEN 5PM AND 6PM, BROAD DAYLIGHT EXCELLENT VISIBILITY, DRY, PARTLY CLOUDY, TRAVELING 65 MPH IN THE CENTER OF THREE LANES. I WAS NOT TIRED NOR DISTRACTED. I WAS NORTHBOUND ON I-75 IN NORTHERN KY WHEN I WENT OVER A MINOR BUMP, JUST ROUGH PAVEMENT. I AM ABSOLUTELY CERTAIN THERE WAS NO OBJECT IN THE ROAD. AFTER THE BUMP THE TRUCK BEGAN STEERING ERRATICALLY, WANDERING, MUCH AS IT HAD 4 DAYS EARLIER WHEN I TOOK IT TO MY FORD DEALER AND THEY REPLACED THE FRONT U-JOINTS. I SLOWED DOWN, GOT THE TRUCK UNDER CONTROL, TURNED OFF THE CRUISE CONTROL, AND MOVED TO THE RIGHT LANE. I HEARD A HIGH-PITCHED SCREECHING METAL NOISE. THEN I SMELLED BURNING RUBBER. I WAS ALERT AND VERY AWARE OF ROAD CONDITIONS AND THE TRAFFIC (TWO LANES WERE MERGING FROM THE RIGHT FROM I-275 SO I WAS IN THE CENTER OF FIVE LANES) AND I AM CERTAIN THERE WERE NO OBJECTS IN THE ROAD. THE CONCRETE WAS CLEAR AND SMOOTH. I HEARD A LOUD BANG UNDER THE RIGHT FRONT OF THE TRUCK AND IT TOOK OFF TO THE RIGHT. IT WAS IMMEDIATELY CLEAR THE TRUCK WAS NOT RESPONDING TO THE STEERING WHEEL. I PUT BOTH FEET ON THE BRAKE PEDAL, MADE MY BODY RIGID AND PULLED UP ON THE STEERING WHEEL FOR MAXIMUM DOWN FORCE ON THE BRAKE PEDAL. COMPLETELY OUT OF CONTROL, I TRAVELED ACROSS BOTH LANES ON MY RIGHT (THE MERGING LANES FROM I-275) AND CAME TO A STOP WITH THE LEFT REAR WHEEL ON THE CONCRETE APRON AND ALL OTHER WHEELS IN THE ROCKY SOIL THAT WAS THE SIDE OF A DITCH WITH A MOUNTAIN ON THE OTHER SIDE. IT WAS LATER DETERMINED THAT THE TIE ROD END HAD SNAPPED. ONE THEORY IS THAT THE TIE ROD END WAS OVER-HARDENED AND BECAME BRITTLE, POSSIBLY CRACKED, THEN THE NEW U-JOINTS CHANGED THE STRESSES ON IT AND IT SNAPPED. INSURANCE REPORT, CRASH SITE AND PARTS PHOTOS AVAILABLE ON REQUEST. *TR

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT DROVE OVER A BUMP AND THE VEHICLE BEGAN TO IMMEDIATELY VIBRATE VIOLENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE BOTH FRONT TIE ROD ENDS WERE REPLACED. THE CONTACT ALSO RECENTLY RECEIVED AN ADVISORY NOTIFICATION LETTER FROM THE MANUFACTURER IN REGARDS TO STEERING WHEEL AND FRONT END VIBRATIONS WHEN DRIVING OVER BUMPY ROAD SURFACES. THE MANUFACTURER ADVISED OWNERS TO MAINTAIN PROPER TIRE INFLATION. THE MANUFACTURER WAS NOTIFIED AND MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20.

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHEN WHILE DRIVING OVER A ROAD BUMP, THE VEHICLE WOULD JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE VEHICLE NEEDED TO HAVE A CAMBER ALIGNMENT PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 91,000. UPDATED 02/27/12 *BF

TL*THE CONTACT OWNED A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 70 MPH THE FRONT END OF THE VEHICLE BEGAN TO VIOLENTLY SHAKE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE VEHICLE WAS OUT OF ALIGNMENT. THE VEHICLE WAS REPAIRED. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY WHILE DRIVING AT A SPEED OF 50 MPH. THE FAILURE MILEAGE WAS 4,000 AND THE CURRENT MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH WHEN THE STEERING WHEEL SUDDENLY VEERED TO THE RIGHT. AS HE CORRECTED THE STEERING WHEEL IT VEERED TO THE LEFT SENDING HIM ACROSS TWO LANES OF TRAFFIC AND DROVE INTO THE MEDIAN. THE VEHICLE WAS TAKEN TO A DEALER WHO ADVISED HIM THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE FRONT STARTED SHAKING BETWEEN 55 AND 65 MPH. THE VEHICLE WAS SHAKING EXCESSIVELY THEREFORE; THE SPEED WOULD NOT INCREASE. THE VEHICLE WAS NOT INSPECTED. THE VEHICLE WOULD ALSO SHAKE EXCESSIVELY WHILE DRIVING OVER A BUMP IN THE ROAD. THE DEALER STATED THAT THEY HAD NOT HEARD OF THE FAILURE AND THAT THE WARRANTY EXPIRED. THE FAILURE MILEAGE WAS 45000 AND THE CURRENT MILEAGE 50000.

EVERYTIME I EXIST THE BACKSIDE OF A BRIDGE MY 2005 F-250 4X4 BEGINS TO SHAKE SO BAD I AM UNABLE TO CONTINUE DRIVING AND HAVE TO PULL TO THE SHOULDER. *TR

I HAVE A 2005 FORD F-250 AND WHEN GOING 55MPH OR UP IF YOU HIT A BUMP IN THE ROAD YOU ARE SHAKING OUT OF CONTROL UNTIL YOU STOP THE TRUCK FORD SAID THERE WAS NOTHING WRONG WITH IT AND THAT WAS AT ABOUT 11,000 MILES. NOW AT 30,000 MILES IT DOES IT EVERY DAY ALL DAY. *TR

TL*THE CONTACT OWNS A 2005 FORD F250. WHILE DRIVING APPROXIMATELY 65 MPH DRIVING OVER A SMALL ROAD BUMP; THERE WAS A VIOLENT SHAKE AND VIBRATION. UNEXPECTEDLY, THE VEHICLE LOSS CONTROL FOR APPROXIMATELY 6-8 SECONDS. THERE WAS A SUDDEN RELEASE OF THE ACCELERATOR PEDAL; HOWEVER, THE DRIVER WAS ABLE TO GAIN CONTROL OF THE VEHICLE AND RESUME OPERATION. THE FAILURE RECURRED AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION; HOWEVER, THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FOUR SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES WHICH THERE WERE NO RESOLUTIONS. THE CONTACT HAD CONCERNS OF THE SAFETY RISK INVOLVED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 200. THE CURRENT MILEAGE WAS 47,000.

2005 FORD F-250 WITH STEERING PROBLEMS. CONSUMER STATES THAT THE VEHICLE'S STEERING WHEEL SHAKES SO MUCH THAT THE VEHICLE WILL LEAVE THE ROAD. HE STATES THAT THE DEALER HAS NOT BEEN ABLE TO SOLVE THE STEERING PROBLEM. *KB THE CONSUMER STATED THE TIRES WERE REPLACED, THE SHOCKS, WHEEL BEARINGS, BRAKES AND FRONT END WERE CHECKED BY THE DEALER AND STATED THERE WAS NO PROBLEM. *JB THE CONSUMER STATED THE PROBLEM HAS NOT BEEN RESOLVED. UPDATED.

TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 65 MPH, THE VEHICLE SHOOK VIOLENTLY AND BECAME DIFFICULT TO STEER AFTER DRIVING OVER A BUMP IN THE ROAD. THE CONTACT STATED THAT IT WAS NOT A NORMAL FRONT END SHAKE AND CONTINUED DRIVING HOME AT A LOWER RATE OF SPEED. THE DEALER ROTATED THE TIRES, BUT THAT DID NOT CORRECT THE FAILURE. THE MANUFACTURER ADVISED HER TO CALL NHTSA AND TO TAKE THE VEHICLE BACK TO THE DEALER. THE CURRENT MILEAGE WAS 30,400 AND FAILURE MILEAGE WAS 18,000.