2006 Ford F-250 Suspension

WHILE TRAVELING ON PENNSYLVANIA TURNPIKE AT APPROX. 75 MPH I HIT BUMP AND THE FRONT END OF MY TRUCK STARTED BOUNCING AND STEERING WHEEL WAS SHAKING SO BAD I COULD HARDLY CONTROL MY TRUCK. ONCE I SLOWED DOWN ENOUGH X THE SHAKING STOPPED.

WHILE DRIVING ALONG AT HIGHWAY SPEED OR SPEED AS LOW AS 35 MPH, ON AN UNEVEN SURFACE OR OVER MINOR POTHOLES THE FRONT SUSPENSION WILL BEGIN TO VIOLENTLY SHAKE EFFECTING STEERING AND CONTROL OF THE VEHICLE. IN ORDER TO REGAIN CONTROL YOU NEED TO RAPIDLY DECREASE SPEED THAT CAN AT TIMES BE UNSAFE UNDER CERTAIN DRIVING SITUATIONS.

TL* THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 35 MPH, THE VEHICLE SHOOK AND JERKED WITHOUT WARNING. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OPENED SPECIAL FIELD ACTION NUMBER: 09L02, BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHEN THE VEHICLE WAS BEING DRIVEN 50 MPH OR MORE, THE FRONT END OF THE VEHICLE WOULD VIBRATE VIOLENTLY. THE FAILURE WOULD ALSO OCCUR WHEN DRIVING OVER A SLIGHT ROAD BUMP. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE FRONT SHOCKS, STRUTS AND STEERING STABILIZER WAS REPLACED, BUT THE REPAIRS DID NOT PERMANENTLY CORRECT THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 150,000.

FROM THE VERY FIRST DAY I GOT THE TRUCK WHEN YOU GO DOWN THE HIGHWAY AT A SPEED OF 60 OR HIGHER THE FRONT END SHAKES VIOLENTLY AND PULLS THE TRUCK TO THE LEFT. AND IT DOES IT TO THIS DAY 6YRS LATER. FORD KNOWS OF THE PROBLEM AND STATED IN A LETTER TO ME FROM FORD THAT 2006 F250 TRUCKS HAVE THIS PROBLEM AND IS DANGEROUS. BUT THEY HAVE NOT COME UP WITH A FIX FOR IT AS OF THIS DATE. IT WAS DANGEROUS WHEN I BOUGHT IT IN 2006 AND IT IS STILL DANGEROUS TODAY. YOU COULD POSSIBLY GO INTO ANOTHER LANE AND HIT ANOTHER CAR OR CROSS OVER INTO ON COMING TRAFFIC. FORD SHOULD BE MADE TO FIX THE PROBLEM AT NO COST TO THE OWNERS. *TR

WAS DRIVING ON THE FREEWAY AND HIT A SMALL BUMP. FRONT END STARTED SHAKING SEVERLY. TRUCK WAS FORCED TO CHANGED LANES AND THANK GOODNESS NO ONE WAS BESIDE ME. EVERYTHING IN THE TRUCK WAS SHAKING. ONCE I PULLED OVER OT THE SIDE OF THE ROAD, I COULD SMELL A BURNT SMELL. *TR

THE "DEATH WOBBLE" OCCURRED IN MY VEHICLE WHILE TRAVELING ALONE WITH NO TRAILER AND THE BED WAS EMPTY. THIS HAS OCCURRED SEVERAL TIMES, THE FIRST WHILE TRAVELING NORTHBOUND ON THE 5FWY IN SOUTHERN CALIFORNIA. AT THE TIME THE SHAKING WAS SO VIOLENT THAT I THOUGHT THAT I HAD BLOWN A TIRE AND PULLED OVER. I HAD JUST PURCHASED THE VEHICLE. THE SAME ISSUE IS ALREADY UNDER INVESTIGATION: PE07057.

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT WAS DRIVING 60 MPH OVER A ROAD BUMP WHEN THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST BUT THE DEALER WAS UNABLE TO DEFECT THE CAUSES OF THE FAILURE. THE MANUFACTURER SUGGESTED ADDING FRONT DAMPERS TO THE VEHICLE BUT THE VEHICLE WAS ALREADY EQUIPPED WITH STOCK DAMPERS THAT DID NOT NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY OF LOSING CONTROL OF THE VEHICLE WHEN THE FAILURE OCCURRED. THE FAILURE MILEAGE WAS 62,000.

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHEN DRIVING OVER ANY ROAD BUMP OR UNEVEN ROAD SURFACE, THE FRONT END OF THE VEHICLE WOULD SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DETERMINED THAT THE UPPER AND LOWER BALL JOINTS ON THE FRONT PASSENGER AND DRIVER SIDE OF THE VEHICLE NEEDED TO BE REPLACED. THE CONTACT SPOKE WITH THE DEALER AND THE DEALER ADVISED THAT THE FAILURE WAS CAUSED BY THE TIRES AND RECOMMENDED CHECKING THE TIRE PRESSURE. THE FAILURE MILEAGE WAS 53,500 AND THE CURRENT MILEAGE WAS 54,000.

WHILE DRIVING MY FORD F-250 ON THE HIGHWAY, I HIT A MINOR BUMP IN THE ROAD. THE TRUCK IMMEDIATELY STARTED SHAKING OUT OF CONTROL. I LITERALLY HAD TO STOP IN THE MIDDLE OF THE HIGHWAY BEFORE THE SHAKING WOULD STOP. THIS IS THE 11TH TIME THAT THIS HAS HAPPENED TO ME. IT HAPPENS AT A SPEED OVER 50 MPH. LUCKILY I HAVE NEVER WRECKED THE TRUCK. I HAVE BEEN ABLE TO MAINTAIN SOME SORT OF CONTROL. I HAVE READ FORD'S REQUEST TO MAINTAIN ADEQUATE TIRE PRESSURE. I READ THAT AFTER THE FIRST TIME IT HAPPENED. IT HAS HAPPENED AN ADDITIONAL TEN TIMES. WHEN IS ENOUGH ENOUGH? DOES SOMEONE HAVE TO DIE BEFORE FORD REALIZES THAT THERE IS A PROBLEM? *KB

I HAVE A 2006 F250 SUPER DUTY TRUCK THAT WILL HAVE VIOLENT FRONT END SHAKES AFTER HITTING A POT HOLE AT AVERAGE ROAD SPEEDS (55-70). IT HAS OCCURRED WHILE TOWING AND DURING NORMAL DRIVING WITHOUT TOWING. WHEN IT OCCURRED I HAD TO IMMEDIATELY PULL OF TO THE SIDE OF THE ROAD TO REGAIN CONTROL OF THE TRUCK. I BELIEVE THIS TO BE A VERY UNSAFE CONDITION THAT FORD NEEDS TO RESOLVE. *TT

I OWN A 2006 FORD F-250 LARIAT CREW CAB FOUR WHEEL DRIVE TRUCK. I AM THE ORIGINAL OWNER. THREE WEEKS AGO THE TRUCK STARTED EXPERIENCING VIOLENT FRONT-END SHAKING. DURING AN EPISODE OF LEFT-TO-RIGHT SHAKING, THE TRUCK IS VERY DIFFICULT TO CONTROL. WITH MY HAND PLACED ON THE 12:00 POSITION ON THE STEERING WHEEL, THE SHAKING VIOLENTLY TURNS THE STEERING WHEEL TO WHERE MY HAND IS GOING BACK AND FORTH BETWEEN 10:00 AND 2:00. SLOWING DOWN TO 30MPH HAS STOPPED EACH OF THE THREE EPISODES. THIS TRUCK HAS THE FACTORY INSTALLED WRANGLER ATS TIRES AND DOES NOT HAVE A LIFT KIT ON IT. AIR PRESSURE IN THE TIRES EQUAL MANUFACTURERS RECOMMENDATION. I AM TAKING THE TRUCK TO MY LOCAL FORD DEALERSHIP IN TWO DAYS FOR DIAGNOSTICS. THEY ACT AS IF THIS IS AN UNCOMMON PROBLEM, BUT FOLLOWING AN INTERNET SEARCH, IT APPEARS TO BE VERY COMMON. IT APPEARS THAT FORD MOTOR COMPANY HAS BLAMED TIRE PRESSURE, GIANT AFTERMARKET TIRES, AND LIFT KITS FOR THIS PROBLEM. MY TRUCK HAS NONE OF THESE POSSIBLE CAUSES. *TT

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH AND DROVE OVER A POT HOLE WHEN THE ENTIRE VEHICLE BEGAN TO VIBRATE VIOLENTLY AND CAUSED THE DRIVER TO ALMOST LOSE CONTROL OF THE VEHICLE. THE FAILURE WAS EXPERIENCED ON AN INTERMITTENT BASIS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.

UNCONTROLLABLE WOBBLE TO VEHICLE AFTER HITTING BUMP ON FREEWAY AT 65 MPH. NOT FIRST TIME AND LUCKY I DIDN'T END UP OFF THE FREEWAY. HAD SERVICE DONE AT FORD DEALERSHIP FOR THE SAME PROBLEM IN AUG 2010, REPLACED CAMBER CASTING AND TWO WHEEL ALIGNMENT, AND TIRE PRESSURE. PROBLEM IS BACK. *TR

2006 F250 WITH 36,000 MILES. FRONT END SHAKES VIOLENTLY AFTER HITTING BUMPS IN ROAD. APPEARS TO BE MORE PRONOUNCED WHEN ENCOUNTERING A SERIES OF BUMPS AND GOING DOWN HILL. THERE IS A LOSS OF EFFECTIVE BRAKING WHEN FRONT END IS SHAKING . CAN NOT UNDERSTAND WHY NO RECALL WHEN THERE ARE SO MANY SIMILAR POSTINGS SUBMITTED. ALSO FRONT DRIVE UNIVERSALS ARE BEING REPLACED AT 45,000 MILES AND VACUUM LINE FOR 4 WHEEL ACTIVATION HAS BURNED OFF THREE TIMES, REPAIRED TWICE MY DEALER AT CUSTOMERS COST. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT WAS DRIVING 70 MPH AND DROVE OVER A ROAD BUMP. THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT RECEIVED A LETTER FROM THE MANUFACTURER REGARDING THE "DEATH WOBBLE" THAT INFORMED OWNERS TO CHANGE THE TIRES, LOWER THE TIRE PRESSURE AND HAVE A WHEEL ALIGNMENT PERFORMED. THE CONTACT FOLLOWED THE DIRECTIONS ACCORDING TO THE LETTER BUT TO NO AVAIL. THE CONTACT STATED THAT THERE WERE NUMEROUS COMPLAINTS ONLINE REGARDING THE "DEATH WOBBLE" AND BELIEVED THAT THE MANUFACTURER SHOULD ISSUE A RECALL. THE FAILURE MILEAGE WAS 30,000.

VIOLENT SHAKING OF FRONT END AFTER HITTING A BUMP ON THE ROAD. ONE STRIP OF HIGHWAY IN OUR TOWN WE CAN RECREATE ISSUE EVERYTIME. *TR

MY FORD F250 4X4 TRUCK HAS A SEVERE SHIMMY OF THE FRONT WHEELS WHICH CAN OCCUR WHEN DRIVING AROUND 55-60 MILES PER HOUR. IN ORDER TO CALM THE SHIMMY OR OSCILLATION, I HAVE TO SLOW DOWN AT LEAST 10 MILES PER HOUR. THIS HAS HAPPENED ON SEVERAL TIMES, BOTH WHEN TOWING A 5TH WHEEL AND WITHOUT THE 5TH WHEEL. HOWEVER, IT IS MORE PRONE TO OCCURRING WHEN DOWNING THE 5TH WHEEL. I TOOK MY TRUCK INTO THE FORD DEALER TO INSPECT THE SUSPENSION AND ADJUST THE TIRE PRESSURE, BUT THEY SAID IT WAS ALL FINE. I HAD AN OCCURRENCE OF THIS SHIMMY WITHIN 3 DAYS FROM TAKING IT FROM THE DEALER. I HAVE SEEN THERE HAS BEEN SOME REPORT ON THIS TYPE OF BEHAVIOR, AND FORD HAS STATED IT IS A TIRE INFLATION PROBLEM, BUT AFTER TAKING IT INTO THE FORD DEALER AND THEM CHECKING IT OUT AND THEN IT HAPPENING, I THINK IT IS SOMETHING MORE SERIOUS. *TR

I HAVE A PROBLEM WITH MY 2006 FORD F-250. MY FRONT END WANTS TO VEER OFF THE ROAD WHEN I HIT POT HOLES IN THE ROAD. I HAVE TRAVELED THE SAME ROADS WITH MY WORK TRUCK, 2006 F-150 AND HAVE LITTLE OR NO PROBLEMS COMPARED TO THE F250. I HAVE TAKEN MY TRUCK TO THE DEALER I PURCHASED THE TRUCK FROM AND HAVE NO SUCCESS GETTING THE PROBLEM RESOLVED.*TR

FRONT END DEATH RATTLE. GOING INTO A CURVE ON A HIGHWAY AND HITTING A BUMP. THE FRONT END SHAKES AND RATTLES TO THE POINT WHERE I HAVE TO HIT THE BRAKES UNTIL THE SPEED SLOWS DOWN TO ABOUT 40 MPH. I HAVE CHANGED THE STEERING DAMPENER, THE SHOCKS AND NOTHING SEEMS TO HELP. FORD SAID TO CHECK THE TIRE PRESSURE. I'VE SET IT TO THE RECOMMENDED TIRE PRESSURE FROM FORD AND I'VE SET IT FROM THE TIRE MANUFACTURES RECOMMENDATIONS. NOTHING WORKS. I'VE SHIMMIED ACROSS SEVERAL LANES OF TRAFFIC AND AM TOTALLY SURPRISED THAT I HAVE NOT GOTTEN INTO A ACCIDENT YET. *TR

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) WITHIN THE LAST YEAR AND A HALF I PURCHASED A 2006 FORD F-250, DIESEL, 4 WHEEL DRIVE TRUCK. ON 3 DIFFERENT OCCASIONS,WHILE DRIVING AT INTERSTATE SPEEDS AND IMMEDIATELY AFTER HITTING A POT HOLE OR BUMP,MY TRUCK WENT INTO A VIOLENT FRONT END WOBBLE/CAVITATION CAUSING A SUDDEN REDUCTION OF SPEED TO ZERO FROM APPROX 70 MPH. ALL THREE TIMES IT FELT AS IF THE TRUCK WAS COMING APART AND HAD TO DODGE TRAFFIC AND GET TO THE SHOULDER TO INSPECT THE TRUCK. AFTER FINDING NOTHING WRONG I CONTACTED OUR LOCAL DEALERSHIP TO LOOK AT THE TRUCK AND THEY TRIED DIFFERENT AIR PRESS CHANGES IN THE TIRES, AND RE-ALIGNMENT, NOTHING HAS HELPED AND THEY REFUSE TO LOOK ANY FURTHER. I STARTED RESEARCHING THIS ON THE INTERNET AND FOUND HUNDREDS IF NOT THOUSANDS OF FORD F-250 TRUCK OWNERS WHO ARE EXPERIENCING THE SAME PROBLEM. YOU CAN GOOGLE "FORD 250 DEATH WOBBLE" OR "FORD F250 VIOLENT SHAKING" AND READ FOR YOUR SELF THE STORIES OF NEAR ACCIDENTS AND PROBLEMS FORD REFUSES TO RECOGNIZE IN THE DESIGN OF THESE TRUCKS. HERE RECENTLY FORD MOTOR CO. HAS CAME OUT WITH A SERVICE BULLETIN WERE I HAVE TO PAY TO HAVE FORD FIX THIS PROBLEM. WHY SHOULD I HAVE TO PAY $40,000 FOR A TRUCK THAT HAS A DESIGN FLAW AND PAY FOR THE FIX,OUT OF MY OWN POCKET AS WELL. A RECALL NEEDS TO BE DONE ON THESE TRUCKS BEFORE PEOPLE GET KILLED,WHY SHOULD SOMEONE HAVE TO DIE FIRST BEFORE FORD WILL DO ANYTHING. ANY HELP YOU CAN GENERATE ON THIS WOULD BE AWESOME."THIS IS NOT A TIRE PRESS PROBLEM, BUT RATHER A DESIGN FLAW." YOUR REPORT SOUNDS LIKE YOU SIDE WITH MONEY INSTEAD OF CONSUMER SAFETY. [XXX] *TR

2006 F250 FRONT END SHAKES VIOLENTLY I HAD NEAR MISS ON A HEAD ON COLLISION. *TR

MY 2006 FORD F250 4WD SUPERDUTY PICKUP SHAKES VIOLENTLY WHENEVER I HIT THE SMALLEST POTHOLE OR DRIVE OVER RAILROAD TRACKS. IT IS A DANGER TO MYSELF, MY CHILDREN AND ANYONE DRIVING AROUND ME ON THE ROAD. TOOK THE TRUCK TO MY DEALER AND ALMOST GOT THROWN OUT AFTER GETTING INTO AN ARGUMENT WITH BOTH THE MECHANIC AND SVC MANAGER WHO SAID THERE WAS NOTHING WRONG WITH THE TRUCK, THEY NEVER HEARD OF THIS PROBLEM AND I NEED TO BUY NEW TIRES. TIRES ARE BRAND NEW WITH LESS THAN 20K ON THEM. *TR

I DRIVE A 2006 F250 AND IT HAS BEEN EXPERIENCING VIOLET FRONT END VIBRATIONS. THIS OCCURS AT VARIOUS SPEEDS AND I HAVE TO SLOW DOWN OR STOP TO GET IT TO RETURN TO NORMAL. IT ALMOST CAUSED AN ACCIDENT THE OTHER DAY WHEN I HAD TO SLOW DOWN TO 10 MILES PER HOUR ON THE FREEWAY TO GET IT TO STOP. FORD CLAIMS IT IS TIRE PRESSURE BUT HAD TIRES ROTATED AND BALANCED TWO DAYS PRIOR. THIS APPEARS TO BE A MAJOR DESIGN ISSUE AND A VERY DANGEROUS ONE. *TR

FRONT END BOUNCING OUT OF CONTROL, AFTER HITTING A SLIGHT BUMP, OR POTHOLE AT A SPEED OF SIXTY OR MORE. *TR