2011 Ford F-250 FUEL/PROPULSION SYSTEM

Truck started leaking fuel and then the engine shut down the next day it was drove, while driving! I’ve received 2 quotes and need the whole fuel system replaced due to CP4 pump failing which will cost about $13,000! This is the same issue as the 24S78 Ford recall but my truck doesn’t fall in the correct year! I still owe 10k on this vehicle so it’s basically totaled now.

2011 FORD F250 WITH 6.7 LITER DIESEL ENGINE BLEW A FUEL INJECTOR DUE TO A BROKEN HOLD DOWN CLAMP. WHILE BEING REPAIRED, MECHANIC NOTICED TWO OTHER CLAMPS WERE CRACKED AND THEY WERE REPLACED BY UPGRADED CLAMPS FROM FORD. ENGINE HAS 62K MILES ON IT. WRITER HAS SEEN NUMEROUS POSTS ONLINE FROM OTHER OWNERS WITH THE SAME ISSUE.

FUEL FILTER EXPLODED CONTAMINATING FUEL SYSTEM

TRUCK STARTED GETTING BAD FUEL MILEAGE AND WOULD NOT GET UP TO SPEED VERY FAST TOOK TRUCK TO AUTOZONE AND HAD CODES READ WAS READING P20BD AND P20BE SO LOOKED UP VIN AND IT STATED IT HAD A RECALL ON THE DEF REDUCTANT HEATER WHICH WHERE THE CODES PULLED UP CALLED AND SCHEDULED AN APPOINTMENT FOR IT TO GET FIXED AT YAKLIN FORD IN RICH WOOD TEXAS TOOK IT IN FOR THE RECALL AND NOW THEY ARE TRYING TO SAY IT'S NOT COVERED ON RECALL AND NOW WHEN I LOOK UP MY VIN THE RECALL IS GONE WHAT CAN I DO TRUCK ONLY HAS 95000 MILES

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 45 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD AND POWER OF THE ENGINE. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO A REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE FUEL PRESSURE PUMP BLEW OUT UNDER THE HOOD. THE MECHANIC STATED THAT THE ENTIRE FUEL SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.

THE FUEL RAIL PRESSURE SENSOR STARTED SPRAYING DIESEL FUEL ALL OVER THE TOP OF THE MOTOR . THE FUEL IS COMING OUT OF THE TOP OF THE SENSOR .THIS IS ON 05/25/19 .. THIS TRUCK ONLY HAS 132214 ON THE MILEAGE . I AM GETTING TIRED OF PAYING FOR A BROKEN TRUCK EVERY WEEK . LAST WEEK ON 05/05/17/19 THE INNER COOLER BOOT DUCT BLEW APART . THAT WAS A $480 FIX .

TAKATA RECALL. TRUCK JUST SHUT DOWN AND DIED WHILE DRIVING. WE TRIED TO RESTART TO MOVE BETTER LOCATION AND ONLY WORKED FOR FEW MORE FEET.NO WARNINGS AND WHOLE FUEL SYSTEM HAS METAL SHAVINGS IN IT AND COSTING 11,000 TO REPAIR AND FORD NOT RECALLING OR COVERING ANY OF THE REPAIR WHEN THEY KNOW THIS IS AN ISSUE CAUSING WRECKS AND EVEN A DISTASTER KIT ONLINE FOR THE PROBLEM WITH FORD TRUCKS FROM 2011-2015. WE HAVE SPOKE WITH MUTLIPLE REPAIR SHOPS AND OUR INSURANCE AND IT IS MECHANICAL FAILURE AND HAPPENS ALOT WITH FORD AND NOT A RECALL NOR IS FORD HELPING OUT CUSTOMERS THAT THE MECHANICAL FAILURE IS HAPPENING TOO. WE ONLY HAVE 100,000 MILES DISEAL TRUCK AND DO ALL OUR MAINTENCE NEEDED AND FORD DEALERSHIP STATED AS MECHANICAL FAILURE.

DUE TO FAULTY/SNAPPED INJECTOR CLAMP, FORD TSB 14-0233, A FUEL INJECTOR WAS BLOWN OUT OF MY ENGINE AN SPRAYED FUEL ALL OVER THE ENGINE BAY. FORTUNATELY FOR ME I HAD JUST STARTED THE TRUCK IN MY DRIVEWAY SO IT WAS STATIONARY AND NOT HOT.

2011 FORD SUPER [XXX], 6.7L FIRE HAZARD, FUEL INJECTOR HOLD DOWN FAILURE WHILE IDLING IN YARD, SPRAYING FUEL ALL OVER PLACE, TOWED TO DEALER, RECOMMENDS REPLACING ALL HOLD DOWNS DO TO FAULTY PART. TSP ON IT.. 1600.00 NOT COVERED UNDER WARRANTY 86,000 MILES. FIRE HAZARD. GLAD I'M NOT THE ONE THAT'S GOING TO BURN IN THE SUPER [XXX] TRUCK RECOMMEND YOU HAVE FORD RECALL ALL 2011 6.7 LITERS TO REPLACE THE DEFECTIVE PARTS. SELL FORD STOCK. FIRE PROFESSOR AND ENGINEERING STUDENTS. COME ON PEOPLE REALLY!!!!!!!!!!!!!!!!!!!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVING ON FREEWAY AT 65 MPH MOTOR SHUT DOWN. AFTER TAKING IT TO THE SHOP I WAS INFORMED THAT THE FUEL PUMP HAD FAILED. I WAS TOLD BY THE SERVICE WRITHER THAT A NUMBER OF THE FUEL PUMPS HAS FAILED ON TRUCKS LIKE MINE. COST TO FIX $8,400.00!!!

MY 2011 F-250 DIESEL WOULDN'T START 2 WEEKS AGO AND AFTER HAVING IT TOWED FOUND IT TO BE THE H.P.F.P HAD TORN ITSELF APART AND PUT METAL SHAVINGS IN THE ENTIRE FUEL SYSTEM. IT WAS STATIONARY AT THE TIME BUT I BELIEVE IT WAS OUT OF SHEER LUCK THAT I WASN'T ON THE INTERSTATE. THIS IS A RECURRING PROBLEM THAT THIS YEAR AND MODEL HAVE, BUT FORD WILL NOT ACKNOWLEDGE IT AS A PROBLEM OTHER THAN TO PUT A KIT TOGETHER FOR THE CONSUMER WHEN THIS HAPPENS TO SIMPLIFY THE ORDERING PROCESS. THIS IS A DANGER TO MY FAMILY AND ANYONE ELSE ON THE ROAD IF MY VEHICLE SUDDENLY STALLS AND LOSES ALL POWER. THIS IS A FREQUENT ENOUGH OCCURRENCE TO WARRANT AN INVESTIGATION IN MY OPINION FOR THE THOUSANDS OF AFFECTED FORD DIESEL OWNERS.

I HAD A FUEL PUMP TO MALFUNCTION CAUSING THE ENTIRE FUEL SYSTEM TO BE REPLACE ON MY 2011 FORD F 250 AT A COST OF ALMOST $8000. THIS IS UNBELIEVABLE I CONTACT MY INSURANCE PROVIDER AND THE ADJUSTER SAID THIS IF A COMMON PROBLEM ON THIS MAKE AND MODEL. THERE HAS TO BE SOMETHING WRONG FOR TYPE OF REPAIR TO BE A COMMON THING. WHO CAN AFFORD TO PAY FOR A REPAIR LIKE WITH THE COST THIS TRUCK AND INSURANCE. PLEASE CALL ME AT [XXX] [XXX]. MY VEHICLE IS CURRENTLY AT LANDERS FORD 2082 W POLPLAR AVE., COLLIERVILLE, TN 38017. I FEEL IF FORD IS AWARE OF THIS WHY IS THERE A NOT A RECALL FOR THIS TO BE CORRECTED. WE CAN'T AFFORD TO PAY FOR THIS KIND OF REPAIR COST. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

TL* THE CONTACT OWNS A 2011 FORD F-250. THE CONTACT STATED THAT WHILE REFUELING, FUEL WOULD SPEW BACK OUT OF THE FILLER NECK WITHOUT ANY WARNINGS MAKING IT EXTREMELY DIFFICULT TO FILL THE FUEL TANK. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL VAPOR CANISTER AND AIR FILTER FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING AT 15 MPH, THE CLAMP USED TO SECURE THE HIGH PRESSURE FUEL LINE LEADING TO THE FUEL INJECTOR FRACTURED CAUSING A FUEL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE FRACTURED CLAMP WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.

AFTER ENGINE IS WARMED UP, WHEN YOU SLOW DOWN, THERE IS A FEW SECONDS, 3 TO 5, THAT THE TRUCK WILL NOT SPEED UP. THIS PROBLEM CONTINUES AS LONG AS YOU ARE IN SLOW DOWN AND SPEED UP TRAFFIC. IF YOU ARE TURNING LEFT THE SPEED UP TIME CAN BE 3 TO 8 SECONDS. I HAVE CARRIED TRUCK BACK TO THE DEALER SEVERAL TIMES WITH THIS PROBLEM. I HAVE BEEN TOLD AT THESE TIMES THAT THEY CAN NOT DUPLICATE WHAT I HAVE TOLD THEM. THIS PROBLEM HAS ALMOST CAUSED A ACCIDENT SEVERAL, SEVERAL TIMES. I HAVE EXPLAINED TO THE SERVICE MANAGER SEVERAL TIMES ABOUT THIS PROBLEM AND THERE IS STEEL NO FIX FOR THIS PROBLEM. I BELIEVE THAT IF THIS PROBLEM IS NOT FIXED THAT I WILL BE IN A ACCIDENT.

FUEL SYSTEM FAILED, FILTER HOUSING SPLIT OPEN BEFORE SERVICE INTERVAL, DIESEL FUEL SPRAYED OVER ENTIRE ENGINE, NO FIRE BUT IT COULD HAVE CAUGHT ON FIRE. *TR