2006 Honda Ridgeline Structure

The contact owns a 2006 Honda Ridgeline. The contact stated that the rear subframe was extremely corroded. There were no warning lights illuminated. The vehicle was taken to the local dealer, who had repaired the vehicle under NHTSA Campaign Number: 22V430000 (Structure). The dealer had repaired the vehicle and was awaiting guidance from the manufacturer. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 200,000.

The contact owns a 2006 Honda Ridgeline. The contact received notification of NHTSA Campaign Number: 22V430000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 Honda Ridgeline. The contact stated that he noticed corrosion on the rear subframe of the vehicle. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact received notification of NHTSA Campaign Number: 22V430000 (Structure). The vehicle was taken to a local dealer for the recall repair; however, the contact was informed that due to the extent of the corrosion, the vehicle would not be repaired. The dealer offered to repurchase the vehicle. The manufacturer was not made aware of the failure. The approximate failure mileage was 260,000.

The contact owns a 2006 Honda Ridgeline. The contact received notification of NHTSA Campaign Number: 22V430000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 Honda Ridgeline. The contact received notification of NHTSA Campaign Number: 22V430000 (Structure) and the vehicle was taken to the dealer where an inspection was performed. The dealer informed the contact that the rear subframe was severely corroded and could not be replaced. The dealer sent a diagnostic report to the manufacturer along with photos. The dealer informed the contact that they were awaiting a response from the manufacturer. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The contact followed up with the manufacturer and inquired whether the vehicle could be repurchased or replaced per the recall remedy. A case was opened. The contact was awaiting a call back from the manufacturer. The vehicle was not repaired. The failure mileage was approximately 88,000. Parts distribution disconnect.

The contact owns a 2006 Honda Ridgeline. The contact received notification of NHTSA Campaign Number: 22V430000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 Honda Ridgeline. The contact received notification of NHTSA Campaign Number: 22V430000 (Structure). The dealer was notified of the recall and informed the contact that parts were not yet available for the repair. The contact was referred to another dealer and provided the same information. The manufacturer was notified of the issue and the contact and was provided a case number. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Parts distribution disconnect.

The contact owns a 2006 Honda Ridgeline. The contact received notification of NHTSA Campaign Number: 22V430000 (Structure) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

INSIDE DOOR RELEASES WILL NOT WORK. HONDA HAD A TECHNICAL SERVICE BULLETIN ON THIS MATTER OF DEFECTIVE DOOR CLIPS. HOWEVER WHEN I CALLED THE DEALER SAID THIS WAS NOT A SAFETY RECALL. HOW CAN THIS NOT BE A SAFETY ISSUE? WHAT HAPPENS IF THE VEHICLE IS IN AN ACCIDENT AND DRIVER AND/OR PASSENGERS NEED TO GET EGRESS THE VEHICLE QUICKLY BUT THE DOOR RELEASES WILL NOT WORK. THIS IS AN UNSAFE CONDITION CAUSED BY A MANUFACTURER DEFECT.

REAR LOCKS STOPPED WORKING. FIRST STARTED ON DRIVERS SIDE SO THAT IT WOULDN'T LOCK AUTOMATICALLY NOT EVEN WHEN PUTTING IN DRIVE SO IT MAKE IT UNSAFE TO PUT A CHILD ON THAT SIDE THAT MAY UNLOCK THE DOOR IF THE CHILD LOCK WAS NOT ENGAGED. THEN IT STARTED DOING THE SAME THING ON THE REAR PASSENGER SIDE LOCK AS WELL. IT IS RANDOM WHETHER IT WILL UNLOCK OR LOCK AND IT HAS TO BE MANUALLY LOCKED OR UNLOCKED FROM THE INSIDE OF THE VEHICLE. WHEN TRYING TO ENGAGE SECURITY FEATURE TO LOCK UP ALL LOCKS MUST BE LOCKED SO IF THEY DON'T LOCK AUTOMATICALLY YOU HAVE TO OPEN EACH DOOR AND MANUALLY LOCK SO THAT YOU CAN SECURE THE VEHICLE.

GETTING INTO THE CAR AFTER SHOPPING AT A STORE, I CLOSED THE DOOR AND THEN HAD TO REOPEN THE DOOR TO HELP MY PASSENGER WITH SHOPPING BAGS WHEN I NOTICED THAT I COULD NOT GET OUT OF THE CAR. I HAD TO ASK MY PASSENGER TO COME AROUND AND OPEN THE DRIVER'S DOOR. I DID NOT NOTICE ANY DEFECTS WITH THE DOOR. AFTER RESEARCHING THIS ISSUE THROUGH ONLINE FORUMS, I SAW MANY COMPLAINTS ABOUT HONDA'S DOORS AND PROBLEMS WITH ACTUATORS. THE NEXT DAY I NOTICE A LATCH ON THE SIDE THE DOOR AND ATTEMPTED TO MOVE THE LATCH TO SEE IF THIS AFFECTS THE OPENING OF THE DRIVER'S DOOR . WHEN I MOVED THIS LATCH, THE DRIVER'S DOOR NO LONGER CLOSED AND COULD NOT BE CLOSED BY THE KEY OR ATTEMPTING TO MOVE LATCH AGAIN. SO I HAD TO DRIVE THE CAR TO THE HONDA DEALERSHIP WITH THE DOOR WIDE OPEN, HOLDING THE DOOR TO PREVENT IT FROM FLYING OPEN ON TURNS WHILE STEERING THE CAR. THANK GOD THE DEALERSHIP IS LESS THAN 2 MILES AWAY FROM MY HOUSE. I DEFINITELY THINK ITS A SAFETY CONCERN WHEN A PERSON CAN GET LOCKED IN THEIR CAR OR CAN MOVE A LATCH MANUALLY AND IT PREVENTS THE DOOR FROM CLOSING ALL TOGETHER. *TR

MY 2006 HONDA RIDGELINE LOWER TRUNK COMPARTMENT LID WILL NOT OPEN. IT CLICKS LIKE IT WANTS TO OPEN BUT NOTHING. THE KEY WILL ONLY TURN TO ABOUT THE 1O'CLOCK POSITION AND WILL NOT TURN TO THE LEFT AT ALL, IF IS SUPPOSED TO AT ALL. THE CLOVE COMPARTMENT SWITCH WORKS BECAUSE WHEN I PUT IT ON LOCK THE MECHANISM WILL NOT CLICK AT ALL...WHICH IS WHAT'S SUPPOSED TO HAPPEN. *TR

TL* THE CONTACT OWNS A 2006 HONDA RIDGELINE. THE CONTACT STATED THERE WAS A GAP ON THE FRONT OF THE INSTRUMENT PANEL CAUSING WATER TO SEEP INTO THE INSTRUMENT PANEL MAKING THE ENTIRE AIR BAG SYSTEM INOPERABLE. THE AIR BAG LIGHTS CONTINUED TO ILLUMINATE CONTINUOUSLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE SEAT BELT CONNECTOR, THE FRONT AIR BAG APRON, THE REAR AIR BAG APRON, THE AIR BAG REAR MODULE AND THE ENTIRE COMPUTER SYSTEM BUT THE FAILURE CONTINUED TO RECUR FOR THE PAST THREE YEARS. THE MANUFACTURER GAVE HIM AN EXTRA WARRANTY PACKAGE BUT THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2006 HONDA RIDGELINE TRUCK. THE CONTACT STATED THE REAR TAILGATE LATCH FAILED TO RELEASE IN AN OPEN POSITION. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

BROKEN INNER CABLE FROM DOOR HANDLE. FRONT PASSENGER DOOR CAN'T BE OPENED FROM INSIDE. REPAIRING COST IS NOT COVERED BY WARRANTY. *TR

WHILE DRIVING APPROXIMATELY 50MPH, THE BACK PART OF MY ROOF (A 5FT BY 8INCH PIECE OF STEEL!) BROKE LOOSE AND FLEW OFF COMPLETELY. IT BARELY MISSED THE CAR BEHIND ME AND THE ONCOMING TRAFFIC. THE DEALERSHIP SAYS THIS IS NOT A SAFETY ISSUE. MAYBE NOT FOR THE DRIVER OF THE RIDGELINE BUT THE DRIVER BEHIND ME COULD HAVE EASILY BEEN DECAPITATED... THIS IS NOT AN ISOLATED INCIDENT AS THE DEALERSHIP SAID THEY HAVE SEEN THIS A FEW TIMES (AND I LIVE IN A SMALL TOWN)! *TR

WATER LEAKING FROM EXTERIOR OF VEHICLE TO INTERIOR OF VEHICLE AND SOAKS CARPET CREATING MOLD AND MILDEW. *TR

WHILE LOWERING THE BACK SEAT TO MAKE ROOM FOR PEOPLE TO RIDE TO LUNCH I NOTICED THE BACK FLOOR WAS WET. WE HAVE HAD MODERATE RAINS IN THE AREA OVER THE PAST TWO-THREE DAYS. FURTHER EXAMINATION REVEALED WATER PUDDLED ALL THE WAY ACROSS THE ENTIRE BACK FLOOR BOARD, UP THE SIDES TO BOTH DRIVER AND FRONT PASSENGER FLOOR BOARDS. WHEN I GOT HOME I PULLED THE TRUCK IN THE GARAGE AND USED A 5 GALLON WET/DRY VAC AND REMOVED ABOUT 7.5 - 8 GALLONS OF WATER FROM THE TRUCK. THE CARPET IS STILL WET AND RUINED HIGH LIKELY HOOD OF MOLD AND MILDEW UNLESS THE CARPET IS REMOVED AND REPLACED. HIGH POTENTIAL FOR RUST/CORROSION UNLESS THE CARPET IS REMOVED AND THE AFFECTED AREA IS DRIED COMPLETELY. I PLAN TO TAKE THE TRUCKIN TO THE DEALER ASAP. *TR

WATER IS LEAKING INTO CAB AND ACCUMULATING UNDER DRIVER'S SIDE CARPET. AND SLOWLY MAKES ITS WAY TOWARDS THE REAR AND PASSENGER SIDE OF THE VEHICLE OVER TIME. *NM

TRUCK BED SCRATCHES CONTRARY TO ADVERTISING OF SCRATCH RESISTANCE. HONDA ADVERTISING NO BED LINER REQUIRED. IF YOU DO NOT USE DROP CLOTHS THE BED LOOKS LIKE A CHILD WAS LEFT ALONE WITH A WHITE CRAYON. *NM

DT*: THE CONTACT STATED MOLD WAS OBSERVED ON THE REAR BRAKE LINE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE VEHICLE WAS WASHED AND REPAINTED DUE TO THE MOLD ON THE VEHICLE. AFTER THIS INCIDENT, THE UNDERSIDE OF THE VEHICLE WAS INSPECTED AND CORROSION WAS DISCOVERED ON THE PIECES THAT HOLD THE BRAKE LINE TO THE VEHICLE. DURING THE INSPECTION, THERE WAS NO LEAK IN THE BRAKE LINE, BUT THE CONTACT EXPRESSED CONCERNS THAT THIS COULD OCCUR IN THE FUTURE DUE TO THE CORROSION. THE VEHICLE HAS NOT BEEN TAKEN TO A MECHANIC SINCE THE CORROSION WAS OBSERVED.

2006 HONDA RIDGELINE MAJOR PRODUCTION DEFECT.***NO ANSWER REQUIRED***. *MR OUTSIDE WATER SOMEHOW ENTERED THE VEHICLE THROUGH THE CHASSIS INTO THE PASSENGER COMPARTMENT OF THE VEHICLE. CURRENTLY THE DEALER IS WORKING ON THE VEHICLE TO CORRECT THE PROBLEM. THE CONSUMER WAS INFORMED THAT THE FENDER OF THE CHASSIS WOULD REQUIRE DISASSEMBLING IN ORDER TO ACCESS THE PROBLEM AREA. HE WAS ALSO TOLD THE THIS PROCEDURE INVOLVED SEALING CERTAIN AREA THAT WERE NOT SEALED PROPERLY DURING PRODUCTION. THE CONSUMER HAS SPOKEN WITH OTHER RIDGELINE CONSUMER WHO ARE EXPERIENCING THE SAME PROBLEM. *NM