2004 Hyundai Santa Fe Suspension

IT HAD 124 RECALL NHTSA 14V43500 I CALL HYUNDAI OFF GOVERNMENT SITE TOLD THEM ABOUT 124 AND BROKEN SPRING THEY SET UP APPOINTMENT SO THEY ONLY PUT ON BRACKETS BUT NO SPRING WANTED $1004 FOR THE STRUT SPRING ON THEY TOLD ME ON CALL CENTER THEY REPLACE SPRING AS IT SAID ON NHTSA SITE THEY WOULD NOT DO IT CALL BACK TO HYUNDIA AS NUMBER ON GOVERNMENT SITE THEY MADE A CASE NUMBER 16604156 AMBER AT 714 594 1764 SHE SAID SPRING WAS NOT IN RECALL I SEND PICTURE OF IT BEFORE UP THERE TO DEALER SHE HAD NO CLUE WHAT WAS SO I DONT WHO RIGHT ON RECALL SHE SAID GOVERNMENT NHTSA SITE ARE NOT CORRECT BROWN LEESBURG HYUNDAI LEESBURG VA 20176

I JUST GOT IT A FEW MONTHS AGO AND HAPPENED TO LOOK UP RECALLS,AND SEEN 3 I TOOK IT TO A HYUNDAI DEALERSHIP AND THEY SAID THERE WERE JUST 2 BUT ONE WAS SUSPENSION AND THEY HAVEN'T CALLED ME ABOUT IT IN AROUND A MONTH NOWB

THIS WAS COVERED BY HYUNDIA RECALL CAMPAIGN 124. I FILLED UNDER CASE # 9878948. SPRING REPAIR 2/12/14, SOLD CAR 4/5/14, RECALL 2/4/15. THEY ONLY WOULD PAY FOR $318 OF THE $917 TOTAL REPAIR AND SAID IT HAS TO GO TO A HYUNDIA DEALERSHIP. THEY REFUSED TO PAY FOR THE SENSERS, STRUT MOUNTS , SWAY BAR LINK ETC PER THE INVOICE. I CONTACTED THE PERSON I SOLD IT TO AND MADE A DEALER APPMT BUT THEY DIDN'T SHOW. HYUNDIA CONSUMER AFFAIRS 800-633-5151 TOLD ME TO FILE A DISPUTE WITH BBB AUTOLINE WHICH I DID UNDER CASE # HYU1713624. THEY NEVER RESPONDED. BBB AUTOLINE NOW SAYS THAT THEY DON'T HANDLE RECALLS DISPUTES BUT YOU DO. I JUST TALKED TO THEM AND THEY REFERRED ME TO YOU. WITHOUT EVER TALKING TO ME, WHILE I WAS TRYING TO GET THE CAR INTO A DEALER AND WAITING FOR THE BBB AUTOLINE RESPONSE HYUNDIA CLOSED OUT THE CASE. IRONICALLY HYUNDIA WOULD HAVE REPLACED BOTH SPRINGS WITH OEM, ALL OTHER DAMAGED PARTS AND ANY DAMAGED TIRES PER THEIR RECALL. IT WOULD HAVE COST THEM 2X AS MUCH AS THE $917. THEY WOULDN'T EVEN CALL MY MECHANIC WHO THE LOCAL HYUNDIA DEALER ACKNOWLEDGED AS REPUTABLE. IN OUR CASE, THE BROKEN SPRING BENT THE STRUT, DAMAGED THE SWAY BAR AND TORE THE ABS SENSOR WIRE. THE LANGUAGE IN THE RECALL INFORMATION ACTUALLY CALLS FOR THE DEALER TO REPLACE INSTALLED NON-OEM STRUTS WITH OEM STRUTS SO THE NEW BRACKET WILL FIT PROPERLY. GIVEN THIS, I AM SURPRISED THAT YOU CHOSE NOT TO PAY FOR THE COST OF THE ONE STRUT AND MOUNT ($62.1 6 +$135.88) & REPAIR ($37.20) AND THE SPRING REPAIR ($37.20). LIKEWISE HYUNDIA CHOSE NOT TO PAY FOR THE DAMAGED ABS SENSOR ($175.94) AND ITS REPAIR ($55.80). IN MINNESOTA, LIKE MOST STATES, PARTS ARE SUBJECT TO SALES TAX OF 7.125%. IN THIS CASE IT ADDED UP TO ($45.25) WHICH HYUNDIA CHOSE NOT TO PAY. LIKEWISE HYUNDIA CHOOSE NOT TO PAY THE SHOP SUPPLIES ($13.18) AND THE ENVIRONMENTAL FEE ($4.93) WHICH ARE PRETTY TYPICAL.

I GOT A LETTER BY MAIL SAING MY CAR HAS A RECALL FOR * COIL SPRING FRACTURE* AND I HAD TO TAKE IT TO CHECK IT OR REPAIR IN CASE IT NEEDED TO BE REPAIRED. I WONDER IF THIS WILL HAVE A COST FOR ME OR I NEED TO WAIT TILLL THIS IS FRACTURED? THANKS IN ADVANCED FOR YOUR HELP

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. IN OCTOBER OF 2014, THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE VEHICLE WAS INSPECTED AND A PROTECTOR PLATE WAS INSTALLED ON THE FRONT COIL SPRING. IN APRIL OF 2016, WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE CONTACT WAS INFORMED THAT THE FRONT COIL SPRING WAS CORRODED AND RUSTED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 176,000.

I RESPONDED TO HYUNDAI'S RECALL EMAIL AND WHEN I TRIED TO SIGN UP TO HAVE MY VEHICLE'S ISSUES RESOLVED AND SCHEDULE ELECTRONICALLY I COULD NOT DO SO UNLESS I AGREED TO ALSO SCHEDULE A RECOMMENDED SERVICE SUCH AS AN OIL CHANGE. THE SITE I WAS SENT TO IS HTTPS://AUTOSERVICE.HYUNDAIUSA.COM/CAMPAIGN124/MICROSITETEMPLATE/MICROSITETEMPLATEVINVALIDATE/1424

2004 HYUNDAI SANTA FE. CONSUMER REQUESTS REIMBURSEMENT FOR COIL SPRINGS RECALL REPAIRS. *SMD

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 30 MPH, A LOUD NOISE EMITTED FROM THE FRONT PASSENGER SIDE AND THE PASSENGER SIDE OF THE VEHICLE SUDDENLY LOWERED. UPON INSPECTION, THE CONTACT DISCOVERED THAT THE FRONT COIL SPRING HAD FRACTURED AND PART OF THE SPRING HAD PUNCTURED THE FRONT PASSENGER TIRE CAUSING THE TIRE TO DEFLATE. THE VEHICLE WAS TOWED TO THE DEALER WHO INDICATED THAT THE COIL SPRING WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

HYUNDAI RECALL CAMPAIGN 124/THE DEALER ORDERED THE FRONT COIL SPRING ON 12/16/2014 AND HAS NEVER RECEIVED IT. HYUNDAI CAN NOT TELL THEM WHERE THE PART IS AND HAS NOT BEEN HELPFUL IN LOCATING ANOTHER PART. A TIRE BURST DUE TO THE RECALLED PART SO THE CAR HAS BEEN SITTING UNDRIVEABLE AT THE MAGUIRE DEALERSHIP IN ITHACA NY FOR OVER A MONTH. AS A CONSUMER WE HAVE NOT BEEN ABLE TO GET ANY ANSWERS FROM HYUNDAI. THIS IS A RECALLED PART AND THEY ARE NOT MAKING ANY EFFORT TO FIX THE VEHICLE. *TR

GOT INTO CAR MORNING OF THE TENTH. CAR WAS MAKING NOISE. PARKED CAR. HUSBAND TOOK LOOK AT IT NOTICE HEAT SHIELD LOSE. THAT DID NOT TURN OUT TO BE NOISE.ON CLOSER INSPECTION NOTICE BROKEN COIL SPRING FRONT DRIVERS SIDE. FUNNY THEY ARE RECALLING THIS MODEL CAR FOR THIS POTENTIAL PROBLEM, BUT MY 2004 SANTA FE ACTUALLY HAD THIS FAILURE AND IT IS NOT COVERED ! *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THERE WAS A LOUD NOISE COMING FROM THE FRONT END AS THE VEHICLE VEERED TO THE RIGHT. THE VEHICLE WAS SHIFTED TO PARK TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FRONT DRIVER'S SIDE COIL SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. ADDITIONALLY, THE CONTACT NOTICED THAT THE COIL SPRING OF THE FRONT PASSENGER'S SIDE FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V350000 (SUSPENSION). THE FAILURE MILEAGE WAS 92,000.

I WAS COMING HOME FROM THE STORE AND HAD JUST TURNED INTO MY DRIVEWAY WHEN MY CAR SUDDENLY VEERED TO THE RIGHT AND STOPPED. I HEARD A LOUD NOISE AND THE ENTIRE SIDE OF MY CAR COLLAPSED ON THE RIGHT SIDE. SOMETHING WAS STICKING INTO THE TIRE. I HAD TO HAVE IT TOWED TO THE DEALERS AND REPAIRED. IT COST US OVER $500. IT WAS STILL UNDER THE DEALERS WARRANTY, BUT WAS NOT COVERED. WE FEEL WE SHOULD BE REIMBURSED. *TR

TOOK MY HYUNDAI SANTA FE IN FOR THE RECALL ON THE SPRING ISSUE. AFTER RETURNING HOME AND LOOKING AT THE WORK ORDER THAT LISTED THEIR ACTIVITY AS INSTALLING A ?FRONT SPRING PROTECTOR INSTALLATION,? I CALLED THEIR NATIONAL CONSUMER HELP NUMBER AND ASKED ABOUT THE PARAMETERS USED IN EVALUATING THE REPAIR DECISION. HER ANSWER WAS: THE DEALER WILL INSPECT AND DO EITHER A SPRING REPLACEMENT IF SEVER DAMAGE IS FOUND OR INSTALL A FRONT SPRING PROTECTION KIT AND SPRAY APPLICATION (OF SOMETHING) IF MODERATE DAMAGE IS FOUND. I QUESTIONED THE PARAMETERS FOR LEADING TO A DECISION, THE FIRST PERSON I TALKED TO SAID IT WAS THE DEALERS RESPONSIBILITY. I RESPONDED BY ASKING FOR A SUPERVISOR, AFTER TRANSFER SHE REPEATED THE PREVIOUS ANSWER. I HAVE BEEN INVOLVED IN MANY STRUCTURAL EVALUATIONS OF RUSTY STRUCTURAL ELEMENTS. ONE CANNOT JUST EYEBALL A SITUATION LIKE THIS, THERE ARE PARAMETERS FOR THE REPAIR OR REPLACEMENT. I FOUND THE SUPERVISORS ANSWER, THAT SHE COULD NOT DIRECT ME TO A CORPORATE ENGINEERING OFFICE FOR SPECIFIC DESIGN PARAMETERS AND THAT THE DEALERS WOULD BE MAKING THE DECISIONS WAS QUESTIONABLE AT BEST IN TERMS OF THEIR ANSWER, WITH NO DEFINED EVALUATIVE CRITERIA AND THEIR RELIABILITY ON THE DEALERS TO MAKE A SAFETY CHOICE OVER A ECONOMIC ONE. THE RECALL WAS FROM HYUNDAI NOT THE DEALER I PURCHASED FROM. THERE WERE TWO OTHER INSTANCES RELATING TO RUST ON THIS CAR, THE CAR NEEDED TO HAVE ITS FUEL TANK REPLACED A FEW YEARS AGO BECAUSE IT WAS RUSTING AND LEAKING GASOLINE, I HAVE THE EXTENDED BUMPER TO BUMPER 100,000 MILE WARRANTY. LITTLE DID THAT HELP, THEY CLAIMED IT WAS NOT COVERED (WHAT DOES BUMPER TO BUMPER MEAN) AND DENIED COVERAGE. A SEPARATE ISSUE OCCURRED WHEN THE CAR DIED ABOUT 100 YARDS FROM MY SERVICE GARAGE, PUSHED IT IN, THEY FOUND A CORRODED WIRE (WHAT EVER) AND REPLACED IT. WHEN I CALLED FOR REIMBURSEMENT, THEY DENIED IT. *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH OVER RAILROAD TRACKS, HE HEARD A POPPING SOUND. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE FRONT PASSENGER'S COIL SPRING HAD FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 101,000. UPDATED 06/17/14 MA UPDATED 8/17/17*CN

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, A LOUD NOISE EMITTED FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FRONT COIL SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 40 MPH, A LOUD NOISE EMITTED FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FRONT COIL SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

2004 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARDS TO FRONT COIL SPRING RECALL. *SMD THE CONSUMER STATED SHE WAS DRIVING AT A SLOW SPEED, WHEN THE FRONT COIL SPRING FAILED AND THE VEHICLE IMMEDIATELY CAME TO STOP WITH THE COIL SPRING PUSHING AGAINST THE RIGHT TIRE . THE CONSUMER IS SEEKING REIMBURSEMENT FOR THE DECEMBER 19, 2011 INCIDENT. *JB

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE FRONT END OF THE VEHICLE SWAYED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

2004 HYUNDAI SANTAFE BROKEN COIL SPRING RUBBING AGAINST THE FRONT TIRE. VEHICLE WAS PARKED IN MY DRIVEWAY WHEN I HEARD A VERY LOUD BANG THAT SOUNDED LIKE A SHOTGUN. I WENT OUT TO INVESTIGATE BUT COULD NOT FIND ANYTHING WRONG. THE NEXT MORNING I ATTEMPTED TO LEAVE FOR WORK WHEN I NOTICED A STRANGE NOISE. I COULD NOT IDENTIFY THE SOUND SO I TURNED AROUND AN PARKED THE VEHICLE BACK IN THE DRIVEWAY. IT WAS THEN I NOTICED A CURVED SHAPE PIECE ON THE GROUND WHICH LOOKED LIKE A HOTDOG WHERE MY VEHICLE HAD BEEN PARKED. I PICKED THE HOTDOG SHAPED PIECE OF STEEL APPROXIMATELY 3/4" DIAMETER. IT APPEARED TO HAVE BEEN BROKEN ON ONE END. AFTER FURTHER INVESTIGATION I FOUND IT TO BE A PIECE OF THE COIL SPRING ON THE FRONT DRIVERS SIDE STRUT. THE COIL SPRING WAS NOW RUBBING AGAINST THE FRONT TIRE. LUCK FOR ME THIS DID NO HAPPEN WHILE I WAS ON THE HIGHWAY. *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE FRONT COIL SPRINGS DEVELOPED CRACKS. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE DEALER COULD NOT PROVIDE A SPECIFIC TIMEFRAME FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

WHILE BACKING OUT OF DRIVEWAY, HEARD A LOUD POPPING AND CRACKING SOUND. GOT OUT TO LOOK. THERE WAS A LARGE "C" SHAPED PIECE OF METAL LAYING IN DRIVEWAY WHERE DRIVERS SIDE WAS. TOOK CAR TO HYUNDAI DEALERSHIP. COIL SPRING HAD BROKEN. SPRING AND TIRE WAS REPLACED UNDER EXTENDED WARRANTY. CONCERNED ABOUT PASSENGER SIDE NOW THAT UTE NOW HAS 88,000 MILES THAT WILL NOT BE COVERED IF OCCURS OUT OF 10 YEAR, 100,000 MILE WARRANTY. *TR

I DROVE TO WORK WITHOUT INCIDENT ON A MAJOR INTERSTATE AT 6AM. MY CAR WAS PARKED IN A SECURE LOT FOR 8.5 HOURS. WHEN I WENT TO LEAVE FOR THE DAY, I STARTED THE CAR, PUT IT DRIVE AND BEGAN TO ROLL FORWARD. WHEN THE CAR BEGAN TO MOVE I HEARD A LOUD GRINDING NOISE AND STOPPED IMMEDIATELY. I CALLED MY HUSBAND AND HAD HIM LISTEN TO IT BY PHONE. WE HAD THE CAR TOWED TO OUT LOCAL HYUNDAI DEAL WHO INFORMED US THAT THE DRIVERS SIDE SPRING HAD BROKEN WHICH BROKE THE STRUT, PINCHED THE BRAKE LINE AND BENT THE SWAY BAR. TOTAL REPAIR COST WAS 1053.31 WITH TAX. WE OPTED TO REPLACE BOTH FRONT SPRINGS AND STRUTS BECAUSE WE FELT THIS WAS THE SAFEST THING TO DO AFTER RESEARCHING ON THE INTERNET AND DISCOVERING THAT THERE WERE HUNDREDS OF THE SAME COMPLAINT IN ALL SANTA FE'S NO MATTER WHAT THE YEAR ESPECIALLY AFTER READING THAT MANY OF THEM OCCURRED ON AN INTERSTATE TRAVELING AT 65 MPH RESULTING IN FURTHER DAMAGE AND INJURY ACCIDENTS. *TR

WHILE BACKING OUT OF MY DRIVEWAY, I HEARD A "CLUNK" SOUND IN THE FRONT OF MY VEHICLE. UPON INSPECTION, I FOUND A "C" SHAPED PIECE OF METAL ON THE DRIVEWAY. I IMMEDIATELY DROVE TO MY MECHANIC'S SHOP, WHERE HE TOLD ME THAT THE COIL SPRING ON MY SANTA FE HAD BROKEN ON THE PASSENGER'S SIDE. THE COIL SPRING ON THE DRIVER'S SIDE WAS ALSO CRACKED. HE HAD TO REPLACE BOTH COIL SPRINGS. HE LATER TOLD ME THAT IT WAS UNUSUAL TO HAVE THESE SPRINGS BREAK FOR NO APPARENT REASON. I DECIDED TO GO ONLINE TO SEE IF HYUNDAI HAD ISSUED A RECALL OR WHETHER THIS WAS A PROBLEM FOR OTHER CONSUMERS WHO OWNED THIS VEHICLE. I FOUND NUMEROUS SITES WHERE PEOPLE HAD WRITTEN IN STATING THAT THEY HAD THE EXACT SAME PROBLEM - IN MOST CASES, THE COIL SPRING BROKE AS THE OPERATOR WAS PUTTING THE 2004-2006 CAR INTO GEAR TO EITHER BACK OR, PULL OUT OF A PARKED POSITION. I WOULD APPRECIATE YOUR LOOKING INTO THIS ISSUE, AND GETTING BACK TO ME ON ANY FURTHER INFORMATION YOU MAY NEED FROM ME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT AFTER STARTING THE ENGINE AND SHIFTING INTO DRIVE, A LOUD POPPING AND GRINDING NOISE EMITTED FROM OUTSIDE OF THE VEHICLE. UPON INSPECTION, IT WAS FOUND THAT THE FRONT PASSENGER'S TIRE HAD EXPLODED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE COIL SPRING AND DEFECTIVE TIRE WERE REPLACED. THE IDENTICAL FAILURE OCCURRED MOST RECENTLY WHERE THE FRONT DRIVER'S SIDE COIL SPRING FRACTURED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.