2024 Hyundai Santa Fe Electrical System

I tried to open the doors of my locked vehicle with the key fob and there was no response. I tried several times and nothing happened. I called AAA and they opened the door with my valet key and was able to pop the trunk. He checked the battery and it was working fine. He then noticed that the wire connecting the battery to the fuse box has melted at the point of contract with the fuse box and actually melted part of the plastic fuse box. There was nothing he could do, so I had to have the car towed to the dealer. I was lucky that the total meltdown of the electrical system did not occur when I was driving or I would not have been able to see any of the controls on the inside of the auto and not be able to use the gear shift to put the car in park.

The Forward Attention Warning device located on the steering column (camera) cannot be disengaged. This device does not allow me to wear dark or polarized sunglasses, which I need since I have eye issues. This is a safety issue for me and others, especially since I am [XXX] [XXX] and there are times when the visor doesn't cover the sun. You can 'disengage' it in the Driver Assistance settings but it does not stop the warnings nor does it stop it from disengaging your cruise control. If you look to the side of the vehicle, look up to pull the visor down, or wear polarized or dark sunglasses, it will also shut off your cruise control. I have taken the vehicle in to the Gainesville GA Hyundai and told them about this issue but they have said that there is no fix for this. BTW -- there are a bunch of posts on Reddit about this issue. This problem isn't a failure of the system, it is a design flaw. I noticed it on the day I bought the vehicle. Now, it is an annoyance to the point that I am looking at buying a new vehicle. I have only had the vehicle a year....not happy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle has a digital instrument panel. Today the instrumental panel started flickering, sometimes all warning lights will flash, and then the panel will go completely black/blank while driving. Sometimes a red "NO SIGNAL" warning will flash across the screen. When this happens, there's no speedometer, engine temperature, or any information about the vehicle. This vehicle is 1-month old and has about 1300 miles.

The digital gage cluster went black on my 2024 Hyundai Santa Fe Calligraphy (AWD) while I was driving on September 5, 2024. There were no prior warnings or indicators to alert me that anything was going to fail/not operate properly. I was entering a school zone and could not determine what speed I was traveling at to ensure that I was not moving too fast and endangering children, as well as walking parents; I pulled over and activated my Heads-Up-Display (HUD) to see if I could utilize it to safely continue my journey. I was able to use the HUD to know my speed. I initially had the HUD turned off because my daughter, who is a new driver, said that it was distracting to her. This occurred first yesterday. I thought that it may have been due to my system conducting a software update, but the issue appears to be intermittent. It sometimes comes back on, but it only remains on for no more than 10-15 minutes before going black again. Since it is a new vehicle and under warranty, I scheduled an appointment with the local Hyundai dealership the same night the issue first occurred to have the problem evaluated. When I arrived the next morning I was told that it would take about two (2) weeks for it to be diagnosed!?! I then went to a friend, who is a certified mechanic specializing in electronics, to take a quick assessment. She didn't discover anything during her observation, but decided to check online to see if there were any reports of this issue occurring prior to my incident. She found a technical report stating that the issue is known and probably caused by a wiring diameter issue that causes the digital gage cluster to intermittently go out and come back on. I believe that this could be a serious condition in certain situations. Besides not knowing your speed, you don't know if a turn signal is activated, how much fuel you have left, engine temps, oil pressure, tire pressures (TPMS), etc.

When driving the cluster panel with speedometer etc goes black for a bit and then comes back on. Also, all the warning lights will come on sporadically at the same time and stay on for a few seconds then go away, or just stay on until car is turned off. Heads up display also goes away and sometimes can't even locate in their settings area. After about 10 min of my phone being on wireless charger it gives me a warning message that my phone is getting hot and to remove the phone. Bought vehicle new on April 13th and this all started within the first week and continue.

16 warning lights came on. Blinkers are t working, side cameras not working and many other features. Then the check engine light came on.