2020 Hyundai Sonata Structure

White pain is pealing off and it’s pretty bad especially when going through car wash

I own a 2020 Hyundai Sonata with factory-applied paint. The vehicle developed paint peeling/clear-coat failure on the driver-side rear quarter panel without any prior damage, accident, or repainting. The paint began separating from the body, exposing the underlying surface. I brought the vehicle to an authorized Hyundai dealer. The dealer acknowledged a paint adhesion failure and submitted the issue to Hyundai. Hyundai declined to fully cover the repair, stating the model year was not included in their paint warranty extension, even though similar peeling paint defects have been acknowledged and covered by Hyundai on earlier Sonata model years. The dealer ultimately repainted both rear panels due to the nature of the failure, but Hyundai required me to pay approximately 20% of the repair cost as a goodwill arrangement. I was not offered a full repaint or full reimbursement. I have also observed early signs of potential paint adhesion issues around the rear window frame, raising concern that the defect may progress to other areas of the vehicle. This appears to be a manufacturing paint adhesion defect rather than normal wear, and similar issues have been widely reported on Hyundai vehicles. I am reporting this issue to document a recurring paint adhesion defect on the 2020 Hyundai Sonata and to assist in identifying a potential pattern affecting additional vehicles.

The contact owns a 2020 Hyundai Sonata. The contact stated that upon exiting the vehicle during a rainstorm, she became aware that water had filled the interior of the rear driver's side door panel, which began to leak when the door was open. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine how the water was entering the door panel. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 47,000.

Exterior paint is peeling and stripping. Hood, doors, front and rear bumper, side skirts, and front lip.

On Nov. 2020 my husband and I purchased a new 2020 Hyundai Sonata with 2mls.off the showroom floor at Daytona Hyundai dealership, Daytona Beach,Fl. We moved to Ga.One day in December, I opened the driver side back door to put groceries in the backseat and I noticed water on the door frame at the bottom ,I thought maybe I might have left the window part of the way down and rain came in. a few weeks after that I went into town I was going to put groceries again in the driver side back door and water sitting on the bottom of the frame inside the door . The window was up .So this went on every time it rained. I drove my car to Rome GA at Heritage auto group they sell Hyundai’s And also service them. [XXX] in service department he’s the manager I told him about the door where I was finding water at every time that it would rain. So he told me to bring it back when I was able to leave it. For the next couple months I had a medical emergency with our son that lives in Florida when he lost eyesight. With the specialist diagnosis he had uveitis in both eyes. The first trip was in April 2021 and I 95 southbound in Florida maybe past Saint Augustine we were driving 60 miles an hour the traffic was very heavy and all three lanes, I was in the center. It was within seconds that I seen something rubber in front of me in my lane ,it could not be avoided or I would have caused a accident with other vehicles. I ran over it on the right side front bumper so my son and I decided to drive it on down to Daytona Hyundai in Daytona where we purchased it at. The manager in the service department there inspected my car all the way around and told me the damages to the right front bumper and the plastic air dam he also said that I could leave it there but they didn’t have a loaner for me & they couldn’t give me a timeframe I told him I had to get back to Georgia take care of my husband. He said that I could have it repaired up there. He did finish cutting off the plastic air-dam . INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

THE VEHICLE'S DRIVER SIDE WINDOW IS NOT SEATED PROPERLY AND HAS EXCESSIVE WIND NOISE WHEN DRIVING. DEALERSHIP CONFIRMS THIS ISSUE ACROSS MULTIPLE MODELS IN THE 2020 AND 2021 HYUNDAI SONATA.

I LOOKED UP UNDER THE HOOD, IT START RUSTING IN FRAME IN DRIVER SIDE. I CHECKED OTHER 2020 SONATA FROM DEALERSHIP AND THOSE CAR ARE EVEN WORST. THOSE CAR RUSTING DRIVER AND PASSENGER SIDE TOO. *TR