2016 Jeep Wrangler Power Train

WHEN STARTING FROM A STOP THE TRANSMISSION POPS OUT OF 1ST GEAR.

THERE IS ALREADY A RECALL ON THE DRIVER SIDE AIR BAG POSTED ON 1/9/2019 WHICH MY DEALERSHIP HAS NOT YET FIXED AS OF 1/24/19. THERE IS ANOTHER ISSUE WITH A "COLD START" PUT INTO REVERSE AND THUS WHEN DONE IT IS STALLING. NO CODES ... NO WARING LIGHTS. MY 2016 HAS BEEN DOING THIS NOW FOR ALMOST 6 MONTHS.

WHILE DRIVING UNDER NORMAL CONDITIONS AT APPROXIMATELY 5-10 MILES AN HOUR ON A CITY STREET THE SHIFT LEVER (PART OF THE MANUAL NSG370 TRANSMISSION) DISLOCATED FROM THE SHIFTER MECHANISM. THE SHIFT LEVER (P/N 52060064AG ) WAS ALLOWED AN UNSAFE AMOUNT OF PLAY AND WAS ABLE TO TURN SEVERAL DEGREES IN BOTH CLOCK AND COUNTER CLOCK WISE DIRECTIONS. THIS PREVENTED ACCESS TO SOME GEARS WHILE DRIVING. UPON INSPECTION, IT WAS NOTED THAT THE RUBBER BUSHING WITHIN THE METAL CYLINDER HOUSING OF THE SHIFT LEVER WAS CRACKED AND NO LONGER PROVIDED ADEQUATE TENSION TO HOLD THE SHIFT LEVER IN PLACE. AS A TEMPORARY FIX, I REMOVED THE SHIFT LEVER FROM THE SHIFTER MECHANISM AND WRAPPED A SINGLE STRIP OF DUCT TAPE AROUND THE RUBBER BUSHING. AFTER REINSTALLING THE SHIFT LEVER THERE WAS ENOUGH TENSION FOR ME TO ENGAGE EVERY GEAR WITHOUT ANY NOTABLE PLAY.

VEHICLE HAS DEVELOPED A RATTLE IN THE CLUTCH/TRANSMISSION ASSEMBLY. SEARCHES FOR OTHER PEOPLE AFFECTED BY THIS YIELD NUMEROUS REPORTS OF CLUTCH THROW OUT BEARING FAILURES. IT AFFECTS SHIFTING AND CLUTCH ENGAGEMENT NEGATIVELY. MAKES IT HARD TO POSITIVELY ENGAGE SHIFTS AT SPEED. MINE HAS NOT YET FAILED BUT THE DEALERSHIP AND JEEP HAVE BOTH BEEN VERY RESISTANT TO ACKNOWLEDGE A SAFETY ISSUE THAT CLEARLY AFFECTS NUMEROUS MANUAL TRANSMISSION WRANGLERS DATING BACK TO ~2008. A PERSONAL ACQUAINTANCE ALSO HAD A CLUTCH THROW OUT BEARING FAIL ON THE HIGHWAY (SAME MAKE MODEL AND YEAR VEHICLE). HE IS CURRENTLY PURSUING REPLACEMENT OF VEHICLE AFTER MASSIVE DAMAGE DONE FROM THROW OUT BEARING FAILURE. PLEASE BE AWARE THAT MY VEHICLE HAD ALREADY HAD THE SHIFTER REPLACED (RECALL FAILURE). THIS ISSUE IS SEPARATE FROM THE SHIFTER LINKAGE RECALL. I'VE ATTACHED SOME DOCUMENTATION BELOW (A SMALL SAMPLING OF THE USERS WHO ARE EXPERIENCING THIS ISSUE FOR YEARS)

TL* THE CONTACT OWNS A 2016 JEEP WRANGLER. WHILE DRIVING 50 MPH, THE GEAR SHIFTER FAILED TO WORK WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TOWED TO THE LOCAL DEALER (FIRST CHRYSLER DODGE JEEP RAM LOCATED AT 280 E WASHINGTON ST, NORTH ATTLEBOROUGH, MA 02760; (508) 316-8400), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 6,640.

SHIFT LEVER ROTATES 180 DEGREES LEFT AND RIGHT WHEN SHIFTING FROM GEAR TO GEAR MAKING IT VERY DIFFICULT TO DRIVE. THIS OCCURS WHEN THE VEHICLE IS STATIONARY AND IN MOTION.

TL* THE CONTACT OWNS A 2016 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE FAILED TO SHIFT TO FOURTH, FIFTH OR SIXTH GEAR. IN ADDITION, THE CONTACT STATED THAT VEHICLE ALSO FAILED TO SHIFT THE REVERSE. THE CONTACT MENTIONED THAT THE FAILURE RECURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFTER ASSEMBLY WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 8,000.

MANUAL TRANSMISSION WILL NOT STAY IN REVERSE AND POPS OUT OF GEAR. WHEN BACKING UP YOUR HAVE TO HOLD IT IN WHICH TAKES ALOT OF FORCE BUT STILL POPS OUT 95% OF THE TIME. BEEN THIS WAY SINCE WE BOUGHT IT. ONLY 3500 MILES ON THE VEHICLE.

WHILE DRIVING ON CITY STREETS THE MANUAL TRANSMISSION'S SHIFT LEVER BECAME LOOSE MAKING IT DIFFICULT TO SHIFT INTO ANY GEAR. THE LEVER WOULD ROTATE 360 DEGREES AROUND ITS CENTER AND EVENTUALLY COME COMPLETELY OFF OF ITS MOUNT. WHEN ROTATED, THE OFFSET IN THE SHIFT LEVER BEING AT A NEW ANGLE WOULD LEAD TO SHIFTING BEING OBSTRUCTED BY THE DRIVER OR PASSENGER'S LEGS AND SEATS. AFTER COMING OFF OF ITS MOUNT WHILE STATIONARY GEAR SELECTION BECAME IMPOSSIBLE WITHOUT REPAIR. DEALER WOULD EVENTUALLY COMPLETE A REPAIR UNDER WARRANTY. ITEMS NOTED ON THE SERVICE ORDER: LEVER: 52060064AG, SCREW: 6506668AA, PCM UPDATE FLASHED

THE CONNECTION OF THE GEAR SHIFTER TO THE MANUAL TRANSMISSION BREAKS, LEAVING YOU STUCK IN WHATEVER GEAR IT WAS LAST IN, AND BASICALLY STRANDED. I PERSONALLY WAS IN A PARKING GARAGE WHEN IT OCCURED, OTHERS HAVE BEEN ON AND OFF ALL KINDS OF ROADS. SEE THIS LINK FOR THE COLLECTION OF OTHERS HAVING THIS PROBLEM: HTTP://WWW.WRANGLERFORUM.COM/F202/16-JKU-MANUAL-6-SPEED-BROKEN-SHIFTER-1625138.HTML

MANUAL TRANSMISSION GEAR SHIFT LEVER GETS REALLY SLOPPY GEAR SHIFT ALMOST HITS FLOOR AND ROTATES

MY 2016 MANUAL JEEP RUBICON UNLIMITED (APPROX 14K MILES) DROVE/SHIFTED FINE ON MY WAY TO WORK (ABOUT 3 MILES, VERY LIGHT TRAFFIC) LAST NIGHT, BUT WHEN I GOT BACK IN THE JEEP TO HEAD HOME, THE STICK-SHIFT WAS ALL CADDY WOMPUS AND I STRUGGLED TO GET IT INTO GEAR TO BACK OUT OF MY PARKING SPACE. IT FELT LIKE IT HAD TWISTED SIDEWAYS AND FALLEN DOWN. TO GET IT INTO 1ST GEAR, I HAD TO SHOVE IT FAR TO THE LEFT TOWARD THE STEERING WHEEL, AND FOR 2ND GEAR, I HAD TO PRACTICALLY JAM THE SHIFTER INTO MY LEG. FINDING NEUTRAL AND REVERSE WAS TRICKY--THE WHOLE SHIFTER MECHANISM FELT LIKE BROKEN BONES AND MUSH. I WAS ABLE TO GET IT HOME (THANKFULLY A SHORT DRIVE ON BACK ROADS WHERE I COULD GO SLOW AND THERE WAS NO TRAFFIC) BUT WAS BAFFLED BY HOW IT WAS FINE EARLIER, THEN SUDDENLY JUNK. THANKFULLY I WAS NOT ON THE HIGHWAY OR ON A TRIP SOMEWHERE WITH MY DAUGHTER IN THE JEEP. A TOW TRUCK PICKED IT UP THIS MORNING AT OUR HOME BECAUSE DRIVING IT 16 MILES TO THE DEALER IN THE CITY IN HEAVY TRAFFIC (NOT KNOWING IF SHIFTING WOULD BE AN OPTION) SEEMED VERY DANGEROUS. THE REP AT THE JEEP DEALER SAID HE HAD NEVER SEEN THIS BEFORE, HOWEVER I DISCOVERED MANY PEOPLE ON WRANGLERFORUM.COM HAVE REPORTED THE EXACT SAME ISSUE. WITHOUT HEARING BACK FROM THE DEALER YET TO VERIFY, IT APPEARS TO BE THE 52060064AG LEVER GEARSHIFT / BUSHING THAT HAS MALFUNCTIONED/BROKEN. I AM VERY DISAPPOINTED THAT MY FIRST EVER AMERICAN MADE VEHICLE FEELS LIKE CHEAP JUNK. IN ADDITION TO THIS POTENTIALLY VERY SERIOUS ISSUE, THERE HAVE BEEN OTHER MINOR IRRITATING ISSUES SUCH AS THE DRIVER SIDE MIRROR SIMPLY FALLING OFF WHILE DRIVING, AND THE FENDER OVER THE REAR WHEEL FALLING OFF. THINGS LIKE THIS SHOULD NOT HAPPEN WITH A NEW "TOUGH" (AND RELATIVELY EXPENSIVE) VEHICLE. I AM DISAPPOINTED AND, FRANKLY, PISSED. DOES QUALITY EVEN EXIST ANYMORE?

BROKEN SHIFTER. WAS OUT IN THE COUNTRY AND AFTER LUNCH I WAS ABOUT TO START DRIVING BACK HOME AND FELT THE SHIFTER KINDA LOOSE. AS I PULLED INTO THE HIGHWAY I NOTICED I WASN'T ABLE TO SHIFT 5TH OR 6TH GEAR AND THEN NOTICED THE SHIFTER WAS ABLE TO ROTATE... CRAZY. IT WAS VERY DIFFICULT TO SELECT A GEAR, GOOD THING IS THAT I WAS ALREADY ON THE HIGHWAY AND NO NEED TO DOWNSHIFT ALTHOUGH HAD TO DRIVE ONLY IN 5TH GEAR AS IT WAS IMPOSSIBLE TO SELECT 6TH GEAR. I AM CLOSE TO THE HIGHWAY SO AS SOON AS I PULLED OFF THE HIGHWAY, I DROVE HOME; IT WAS A BIT SCARY; I THOUGHT I HAD BROKEN SOMETHING. AS SOON AS I GOT HOME AND PARKED MY JEEP I CONTACTED A COUPLE OF FRIENDS AND TOLD ME TO EITHER TAKE IT TO THE DEALER THE NEXT DAY OR CALL ROADSIDE ASSISTANCE AS MAYBE A TOW TRUCK WOULD BE NEEDED. NEXT DAY IN THE MORNING, DECIDED TO GIVE IT A TRY AND DROVE IT, VERY CAREFULLY, TO THE DEALER (IS LIKE 3 MILES AWAY FROM MY PLACE). ONCE THERE, THE TECHNICIAN TOLD ME SHE HADN'T SEEN OR KNOWN OF A SIMILAR ISSUE AND THAT YES, THE SHIFTER WAS EITHER LOOSE OR BROKEN. FIXED UNDER WARRANTY IN 4 DAYS, NO EXPLANATION. I TOLD HER WHEN I PICKED IT UP THAT TO ME IT WAS A SAFETY ISSUE AND I HAD DROVE IT WITHOUT KNOWING THE FULL EXTENT OF THE ISSUE.

TL* THE CONTACT OWNS A 2016 JEEP WRANGLER. THE CONTACT STATED THAT WHILE ATTEMPTING TO ACCELERATE AT 15 MPH, THE VEHICLE BECAME STUCK IN LOW GEAR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER HOWEVER, THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED THREE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 725.

THE SHIFTER ON MY MANUAL 2016 JEEP WRANGLER BROKE TODAY WHILE I WAS GETTING ON THE HIGHWAY. IT ALMOST CAUSED A BAD ACCIDENT. THERE ARE 4,000 MILES ON THE CAR. IT FELT LIKE IT BECAME DISENGAGED AND WAS TURNING SIDEWAYS AND MAKING CRACKLING SOUNDS, LIKE BROKEN BONES. IT BECAME DIFFICULT TO PUT INTO GEAR OR TO KNOW WHICH GEAR THE CAR WAS IN. I MANAGED TO PULL OVER AND AM WAITING FOR ROADSIDE ASSISTANCE. A QUICK GLANCE THROUGH A JEEP FORUM AND I FOUND MANY OTHERS WITH THE SAME EXACT DESCRIPTION. ALL 2016 JEEP WRANGLERS. THEY MENTION HAVING TO REPLACE A FAULTY PART (52060064AG). ISSUES ARE STARTING TO BECOME WELL DOCUMENTED HERE: HTTP://WWW.WRANGLERFORUM.COM/SHOWTHREAD.PHP?P=27212978

2016 JEEP WRANGLER UNLIMITED BLACK BEAR EDITION 6 SPEED MANUAL. SHIFT LEVER IS MAKING CLICKING SOUND WHEN SHIFTING. SHIFTER CAN ROTATE 360 DEGREES. FEELS LOOSE WHEN SHIFTING AND INTERFERES WITH PUT JEEP INTO GEAR. UNABLE TO DRIVE VEHICLE UNTIL IT GETS FIXED. IS COVERED UNDER POWER TRAIN WARRENTY. ONLY HAD THE JEEP FOR 6 MONTHS.