2020 Kia Optima POWER TRAIN,ENGINE

Accelerating at a normal rate to get on the highway and the check engine light starts flashing out of nowhere and car goes into limp mode. Made it to local shop and they informed me it was a P1326 code and that a knock sensor would have to be replaced, but that Kia has recalled the older models for this same reason.

Engine knocking and stalling on interstate

The engine in my 2020 Kia Optima S (2.4L GDI Theta II) has been experiencing excessive oil consumption, engine knocking, and loss of power, consistent with known issues in earlier model years of this engine. This component is still in my vehicle and is available for inspection upon request. The issue puts my safety at risk due to unpredictable power loss while driving and the potential for engine seizure or fire, especially during high-speed travel. I’ve had to top off oil multiple times between regular oil changes, and the vehicle showed signs of low oil without any dashboard warning. No KSDS (Knock Sensor Detection System) software was ever installed on the vehicle. I have not yet had a full diagnosis from the dealer, but I have opened a case with Kia Consumer Affairs, who informed me that I do not qualify for recall repair based on the vehicle’s manufacture date — despite the engine matching those in previous lawsuits and recalls. The vehicle has not yet been inspected by the dealer, manufacturer, police, or insurance representatives. However, I can provide receipts for oil purchases and logs documenting how often I’ve had to refill the oil. I am also filing a claim with my third-party powertrain warranty provider. Symptoms first appeared at approximately 85000 miles Engine knocking/ticking noise Oil light flashing briefly or low oil found without warning Needing to add 1–2 quarts of oil between oil changes Rough acceleration or loss of power This issue is widespread, has been previously acknowledged in other model years, and should be formally investigated in the 2020 Optima as well. I am concerned for the long-term safety and reliability of this vehicle

When the vehicle was about 3 years old and at 60,000 miles, the fuel injector went out. Kia took weeks to approve the replacement under warranty. Since then the engine light came on and said cylinder 3 has leak and fouls the plug. We've had it repaired 3 times. The mechanic said it would be too costly to repair and the engine should be replaced.

I started having clicking sound in engine around 50k miles . Then my check engine light came on and my engine has been using so much oil. I have to get an additional 3 quarts in between oil changes. The clicking sound is getting louder and my car is now having issues accelerating. . My engine is failing and I bought this car brand new and have regularly maintained it .

On July 4th 2023, I was driving with my son in car, when unexpectedly the check engine light came on and car lost power. We were on a highway with a 65mph speed limit. I was able to pull over to side of road. Car did Start back up, however was missing and misfiring. Shaking especially under acceleration. My engine has been consuming oil for many thousands of miles, it is documented; however only an oil consumption test was performed. Hyuandai and Kia has serious engine issues and they know it. This could've been worse. Luckily I still had some brake pressure to get off the road. With this stalling on the highway, it is very dangerous.

My 2020 Kia Optima had engine failure and engine is being replaced now. I've had this car for 1yr/84k miles. It went limp on the freeway 2 mos ago and I could've caused an accident when it shut down. Would not go over 30 mps, engine light kept blinking and had knocking sound. Diagnostic code as the other recalls, Engine is same for the other recalls 2.4 Theta, oil was black and almost empty & just had oil changeI called kia corporate and they told me that they are not covering it since its not a recall. I have extended warranty but CNA National Warranty will only approve a used engine and a new one I would have to pay $3,000! I have made 2 car payments for a car that is immobile, $200+ for deductible, and $600+ for car service, this is not right at all. How can I get Kia to correct this. I do not want this car or any other kia! I cannot afford xmas this year all because I chose the wrong car maker!!