2020 Lincoln Navigator Power Train

Faulty Transmissions even after replacement. Fluid leaks and abrupt starting / stopping with it. Dealers can't seem to figure it out and have become a safety issue

Category: Power Train -> Automatic Transmission Subject: 2020 Lincoln Navigator – Repeated Missed Warranty Repairs – Transmission Neutral-Out & Violent Downshift at Highway Speed Description: On [XXX], while traveling at approximately 70 mph on [XXX], my 2020 Lincoln Navigator suddenly downshifted, free-wheeled into neutral, then violently re-engaged into a lower gear, chirping the rear tires and nearly causing a collision. The vehicle displayed a "Shift System Fault" warning. This defect matches TSB 23-2120 (momentary neutral-out) and TSB 24-2101 (harsh/delayed engagement) for the Ford/Lincoln 10R80 transmission used in the Navigator. TSB 23-2123 (harsh/delayed engagement/shift) also applies to my model year and transmission. I purchased this vehicle in December 2023 from Performance Lexus RiverCenter (Covington, KY) with the original Lincoln 6-year/70,000-mile powertrain warranty still in effect. According to Carfax, the vehicle was owned by Airport Ford, a Ford/Lincoln dealer, for six months prior. No transmission-related repairs were performed during that period despite applicable TSBs. In March 2024, I reported abnormal shifting to Lincoln of Cincinnati. The concern was dismissed without inspection or repair, even though the TSBs applied to my VIN at that time. The [XXX] incident is the direct result of two separate failures by Lincoln/Ford dealerships to act on a known defect while the vehicle was under warranty. This is a serious safety hazard that can cause sudden loss of power and traction at highway speeds. Vehicle Details: - Year: 2020 - Make: Lincoln - Model: Navigator - Transmission: 10-speed automatic (10R80) - Mileage at Incident: 48000 - VIN: [XXX] - Date of Incident: [XXX] - Dealers Involved: Airport Ford (prior owner), Lincoln of Cincinnati (service visit March 2024) The dealer is working on the car currently will send any repair items when they are in hand INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Had transmission problems before this final issue. With that said the dealership ended up replacing the transmission as it was under warranty. Not even 2000 miles later we are coming back from vacation and I lost total power of the vehicle but since I was going around 70 mph we made it to the shoulder of the highway. Once there the vehicle was already smoking so we all got out of the vehicle and that’s when I saw the fire, and not even 3 minutes later it was totally in gulfed in flames.

The transmission system failed, causing jerking during acceleration. The original transmission was replaced by the dealer, so it may be available for inspection if retained by the dealer or returned to Ford/Lincoln. Jerking during acceleration can create safety risks including: unpredictable vehicle behavior during merging or passing, potential loss of control in traffic situations, and compromised ability to maintain consistent speed or smoothly accelerate away from hazards. Yes - the dealer confirmed the problem and determined the transmission required replacement, indicating they reproduced and verified the issue. Ted Britt Ford Lincoln, Chantilly, VA inspected the vehicle. No dashboard lights.

Was on Interstate when there was a loud bang, the transmission shifted harshly and I lost power where the vehicle would not go faster when i hit the pedal. I was basically pumping the gas for about 3-5 seconds before transmission re engaged. It was a dangerous situation in that I was at highways speeds about 65-70mph and i had no throttle control for several seconds. There was no warning when it happened and it re engaged and I was able to drive the vehicle home. Ford did replace the CDF drum under warranty but there should be a recall on this transmission. The the same thing happened in my other truck, an f150 which uses the same tranmission and engine combo.

The contact owns a 2020 Lincoln Navigator. The contact stated while at a complete stop, the vehicle shut off inadvertently. The contact stated that the vehicle restarted upon pressing the Push to Start button. The contact stated upon depressing the accelerator pedal, the vehicle jerked, was sluggish, and made an abnormal crackling sound. The vehicle then responded as needed and the contact continued driving. There was no warning light illuminated. The contact stated that while driving at an undisclosed speed and depressing the brake pedal to come to a stop, the vehicle shut off inadvertently. The contact was able to restart the vehicle and continue driving. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated that the failure had been recurring. The vehicle was taken back to the dealer. The dealer test-drove the vehicle and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

Frequently while traveling at 35 mph to highway speeds, while needing to accelerate slightly to avoid traffic, change lanes, pass, etc. the Navigator needs to downshift. It drops out of gear and seems to fail to find a lower gear resulting in a neutral like gear, loss of power, engine revving sometimes to redline. This was happening frequently during a family Thanksgiving trip in 2023. It is very scary when this happens, especially at interstate speeds in traffic. It is very unsafe!

Transmission hard shifting when shifting down 3-1 and up 1-3 I see there is a recall for 2020-2024 navigator but mine doesnt show recalls when i looked for it

The contact owns a 2020 Lincoln Navigator. The contact stated that while driving 50-55 MPH and depressing the accelerator pedal, the transmission shifted into neutral(N). The contact was able to veer to the side of the road. The contact turned off and restarted the vehicle. The contact was able to continue driving; however, the failure recurred while driving. The vehicle was taken to the dealer, where the contact was informed that the transmission fluid was 2-quarts low after driving 100 miles. The contact stated that the failure had been recurring more increasingly. The contact stated while driving 75 MPH and depressing the accelerator pedal, the engine revved, but the vehicle failed to respond and jerked. The contact stated that the vehicle also experienced hard shifts while attempting to shift into gear. The contact stated that the vehicle shifted into Neutral(N) while the gear shifter was in drive(D), and the vehicle started losing motive power. The contact stated that the transmission was making abnormal grinding sounds. The contact continued to drive to the dealer however, there was smoke coming from underneath the vehicle and the vehicle lost motive power at the dealer. The dealer diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and was considering buying back the vehicle. The failure mileage was approximately 45,600.

Driving vehicle for an approximately 70 miles highway trip, the vehicle was experiencing some hard shifts/poor shift quality prior to overheating. Temperature in vehicle for the transmission was reading 237 degree Fahrenheit when we stopped at a light after exiting the highway. We noted smoke and saw oil on the exhaust, which is a concern for fire. We noted a burning smell as well. Rear hatch of vehicle was sprayed with fluid, which we think is transmission fluid, causing a visibility concern out the rear windshield. The transmission had been previously rebuilt and a prior complaint filed. There were no error messages displayed in the vehicle. I have attempted to contact the dealership but they are closed on 1/1/24. I reached out to Lincoln Concierge and filed a complaint.

Vehicle set on adaptive cruise control, car accelerated to get back up to set speed and had a hard "clunk" sound. Driver turned off cruise control and attempted to accelerate vehicle. Vehicle tachometer revved up, transmission didn't shift properly, still shifting hard or not shifting at all. Once stopped, driver of vehicle found the back of the car covered in what appeared to be ATF and what appeared to be ATF leaking under the car. Took car to dealership for inspection, transmission rebuilt. Per tech that rebuilt transmission, it overheated. No warning lights came on, the transmission temperature displayed on the vehicle was 215 degrees Fahrenheit at time of incident.