2012 Mercedes-Benz E-Class Suspension

The contact owns a 2012 Mercedes-Benz E350. The contact stated his wife had noticed that the steering wheel was off-center and turned to the left independently. Additionally, the contact stated while his wife was driving at an undisclosed speed and depressing the brake pedal, the vehicle flipped sideways. The contact's wife was able to exit the highway and pull into a gas station. The contact met his wife at the gas station. The contact stated that while driving approximately 20 MPH, the failure recurred, with the front end shifted to the left and the rear end shifting to the right. The contact returned to the parking lot. The vehicle was towed to the residence. The contact stated that as an independent mechanic, he inspected the vehicle and noticed that the rear subframe was corroded severely inside out and a wheel had detached. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 170,000. The VIN was not available.

Rear subframe has rust perforation causing instability and stopping issues with the vehicle.

My 2012 Mercedes E350 has rear sub-frame is starting to rust/corrode and I need to replace it within 3 months. This could cause the rear end to break free and forcing the back of the vehicle to swerve while braking. My Mercedes authorized repair shop stated that similar problems have been identified in other models using same rear subframe and they have replaced them. I have 143K miles and the car is garaged year round. It will cost $5K to repair. Mercedes USA will not fix this for free while all European Mercedes group repair this for free as a defect.

Rear sub-frame rotted out and would not pass state inspection. Repair shop contacted local Mercedes dealer and was told they were not aware of a problem. However if you perform an internet search, it is a problem. Dealer had two sub-frames in stock, however they were reserved for scheduled repairs and did not know when they. My repair shop located an after market frame and the car was repaired. In addition, the repair shops opinion is the design of the sub-frame is at fault as it retains water leading to corrosion. I performed my own internet search and it is a very known problem not only with the E350 model but also others.

A state inspection identified that the rear subframe is rusted through. Per the service advisor, the failure of the rear subframe is a safety hazard because it effects steering and braking, and complete failure can cause loss of brakes. Service advisor advised not to drive the vehicle until repairs are made due to safety concerns. Vehicle failed inspection because the issue is a safety issue.

The rear subframe is broken. I was braking and the car lost control about two weeks ago. Ever since then the car feels like it's slipping whenever I brake or on a turn. I lose control of the car and I'm endangering my life and others. I went to take my vehicle to get inspected today and the said the rear subframe is broken and no fault of my own. The car was kept in a garage for years and only has 55k miles on it. There's no reason a subframe should be broken.

I found that the subframe had been recalled in other countries, but not in the united states? The large number of failures on this subframe across multiple models is concerning. This is a gross failure of a major safety component that can cause serious injury or death. My research showed this part has been recalled in Canada; MBUSA feels the need to wait to do so until a serious injury or death has occurred. The defective subframe is known and the new part’s design has been amended to take into account this rust issue. This is especially concerning considering the recent recall on the brake boosters due to advanced corrosion. MBUSA’s decision exhibits a lack of accountability for a defective part and this issue needs to be promptly addressed for the safety of its customers.

In having maintenance on my vehicle, the dealer advised that the subframe is corroding and needs to be replaced. I searched several Mercedes forums and found a number of owners citing similar corroding subframes yet no other undercarriage components showed rust or corrosion. All owners felt that this should be remedied by Mercedes before a failure causes injuries. Forum participants suggested and encouraged to file a complaint to NHTSA for investigation.