1998 Toyota Avalon Visibility

1998 TOYOTA AVALON - WITHOUT WARNING, THE AIR CONDITIONER/HEATER & FANS QUIT WORKING. THIS IS INTERMITTENT. YOU NEVER KNOW WHEN IT IS GOING TO GO OUT. THIS CAN BE A SAFETY ISSUE IF WE ARE DRIVING ON THE FREEWAY, OR ANYWHERE FOR THAT MATTER, DURING A COLD SPELL AND THE DEFROSTER SUDDENLY GOES OFF. SEARCHING THE INTERNET THERE ARE NUMEROUS PEOPLE WITH THE SAME PROBLEM.....AND WHAT IS TROUBLING IS THAT TOYOTA IS AWARE OF IT AND HAS ISSUED A TECHNICAL SERVICE BULLETIN BUT EVEN THAT YOU HAVE TO PULL TEETH TO GET A COPY. IN FACT TO GET THEM TO TELL ME THERE WAS AN ISSUE I HAD TO TELL THEM THE TSA NUMBER I HAD FOUND. THEY ORIGINALLY TOLD ME THEY HAD NO INFORMATION. THEY ARE NOT MAKING THIS KNOWN TO THEIR CUSTOMERS. *TR

THE ENTIRE HVAC SYSTEM OF THE CAR SHUTS DOWN. BLOWER, HEATER, DEFROSTER, A/C ARE ALL INOPERATIVE. CANNOT BE ACTIVATED MANUALLY. WINDSHIED QUICKLY FOGS. HOURS OR DAYS LATER, OPERATION RETURNS TO NORMAL. PROBLEM RECURS WITHOUT PATTERN.*AK

INTERMITTENT OPERATION OF AUTOMATIC CLIMATE CONTROL SYSTEM. NO AIR CONDITIONING, HEATER OR FAN OPERATION. COMPLETE SHUTDOWN OF SYSTEM. WILL SOMETIMES WORK AFTER THE CAR IS TURNED OFF AND RESTARTED. THIS BECOMES VERY SERIOUS BECAUSE FRONT WINDSHIELD WILL NOT DEFOG. TOYOTA RELEASED A TECHNICAL SERVICE BULLETIN ON DEC. 3, 1999. BULLETIN AC005-99 THEY KNEW THAT THE SYSTEM HAD A FLAW SO THEY REDESIGNED AND UPDATED THE (ECU) A/C AMPLIFIER. ITS THE BRAIN FOR THE COMPLETE HEATING AND A/C SYSTEM. I PLEAD MY CASE WITH THE DEALER AND THEY SAID THAT THEY CALLED TOYOTA AND TOYOTA REFUSED MY REQUEST TO HAVE THE PARTS AND LABOR COVERED BECAUSE OF A BAD DESIGN. *NM

WHILE DRIVING, THE ENTIRE CLIMATE CONTROL SYSTEM FAILED WITHOUT WARNING. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB

1998 TOYOTA AVALON. THE CLIMATE CONTROL RANDOMLY QUITS WORKING. NO HEAT,NO AIR, NO DEFROST NO BLOWER. CAUSES A DANGROUS SITUATION IS YOU NEED THE DEFROSTER AND IT DOESN'T WORK

AN ALLDATA TECHNICAL SERVICE BULLETIN ISSUED 12/03/1999: "A/C - ATC SYSTEM INTERMITTENTLY FAILS/BECOMES INOPERATIVE. AUTO A/C SYSTEM IMPROVEMENT. INTRODUCTION: A PRODUCTION CHANGE HAS BEEN MADE FOR THE 1998-1999 AVALON A/C AMPLIFIER. THE INTERNAL LOCIC HAS BEEN CORRECTED TO ELIMINATE EXCESSIVE AIR INLET SERVO MOTOR TRAVEL, WHICH MAY EFFECT THE MOTOR AND/OR THE SERVO LINK. VEHICLES WITH AUTOMATIC A/C MAY INTERMITTENTLY EXPERIENCE ONE OR MORE OF THE FOLLOWING CONDITIONS: 1)THE AMBIENT TEMPERATURE DISPLAY MAY GO BLANK; 2)FRESH/RECIRC INDICATOR LIGHT INOPERATIVE; 3)MODE INDICATOR LIGHT INOPERATIVE; 4)BLOWER INDICATIOR INOPERATIVE. NOTE: A/C SYSTEM MAY RESTORE TO NORMAL CONDITION UPON CYCLING THE IGNITION SWITCH. ALL APPLICABLE VEHICLES: ALL 1998 MODEL YEAR AVALON XLS PRODUCED BEFORE VIN:4T1BF18B*WU273780." I FIRST EXPERIENCED THIS PROBLEM IN SUMMER OF 2003. A LOCAL TOYOTA DEALER DENIED KNOWLEDGE OF THE PROBLEM. EVENTUALLY ISOLATED THE PROBLEM AND ALLDATA BULLETIN WITH THROUGH AN INDEPENDENT MECHANIC. NOTIFIED TOYOTA CORPORATE, WHO IS AWARE OF THE PROBLEM AND UNWILLING TO COVER THE COSTS TO CORRECT: $800 PER INDEPENDENT MECHANIC & $1,000 PER LOCAL TOYOTA DEALERSHIP. DURING THE SUMMER, THE ATC FAILURES CREATED POTENTIALLY DANGEROUS DRIVING CONDITIONS AS WINDOWS QUICKLY FOGGED AND VISIBILITY DROPPED TO ZERO. CURRENTLY, THE ATC SYSTEM HAS FAILED AND HAS NOT RESTORED BY ALLOWING THE CAR TO SIT AND CYCLING THE IGNITION SWITCH, CREATING INABILITY TO DE-ICE AND DE-FOG THE CAR WINDOWS. ALL EVIDENCE INDICATES: 1)PROBLEM IS CAUSED BY INCORRECT INTERNAL LOGIC OF THE A/C AMPLIFIER, NOT NORMAL USE/WEAR OF THE VEHICLE; 2)TOYOTA IS AWARE OF THE PROBLEM AND IS UNWILLING TO BE HELD ACCOUNTABLE; 3)THE PROBLEM QUICKLY AND UNPREDICABLY HAS CREATED DANGEROUS DRIVING CONDITIONS FOR THIS AND OTHERS DRIVERS, AS INDICATED BY THEIR NHTSA COMPLAINTS. PLEASE INITIATE AN INVESTIGATION AND RECALL, HOLDING TOYOTA ACCOUNTABLE FOR THE DEFECTIVE NATURE AND FAILURE OF THIS PRODUCT. *AK

THE HEAT DEFROSTER BLOWER HAD CUT COMPLETELY OFF AND DID NOT TURN BACK ON. SCC

CONSUMER STATES WHILE TRAVELING AT HIGHWAY SPEED CONSUMER NOTICE A LOUD NOISE FLOWING WITH GLASS IN REAR SEAT OF VEHICLE WITHOUT ANY INDICATION REAR WINDOW BLEW OUT. PLEASE PROVIDE FURTHER INFORMATION. TS

PROBLEM WITH VENTILATION SYSTEM--BURNTOUT WIRES IN THE AUTOMATIC CLIMATE CONTROL MODULE CAUSED TOTAL FAILURE OF THE ENTIRE VENTILATION SYSTEM

NO, SUMMARY LISTED FOR ABOV EVEHICLE. *AK

THE COMPLETE SHUTDOWN OF THE ENTIRE AIR CIRCULATING SYSTEM INCLUDING FRONT DEFROST/DEFOG, HEAT AND AIR CONDITIONING IS DOCUMENTED IN A SERVICE BULLETIN TO TOYOTA DEALERS FROM TOYOTA, YET TOYOTA REFUSES TO PAY FOR THE REPAIR THE VEHICLE IF IT IS PAST THE WARRANTY PERIOD. EVEN THOUGH IT CREATES A DANGEROUS CONDITION IN NOT BEING ABLE TO DEFOG OR DEFROST THE FRONT WINDSHIELD.*AK

ELECTRONIC CLIMATE CONTROL AND DASH LIGHTS/WARNINGS CUT OFF WITHOUT NOTICE AND CANNOT BE RESTARTED UNLESS IGNITION TURNED OFF AND ALLOWED TO SIT >1MIN, DEALER CANNOT IDENTIFY SPECIFIC PROBLEM RECOMMENDS TRYING TO REPLACE MODULE FOR $1200 ALTHOUGH THAT MAY OR MAY NOT FIX PROBLEM, MORE FREQUENT FAILURE IN SUMMER MONTHS

DRIVERS SIDE POWER WINDOW RELAY FAILED. NLM

WINDSHIELD GLASS FLAWED DUE TO IMPROPER INSTALLATION. YH

FRONT WINDSHIELD CRACKED.