1994 Toyota Corolla Fuel System

TL* THE CONTACT OWNS A 1994 TOYOTA COROLLA. THE CONTACT STATED THE HEAT SHIELD WAS REMOVED FROM THE FUEL TANK AND WHAT WAS FOUND UNDERNEATH THE HEAT SHIELD WAS A BUBBLE WHICH WAS LOCATED ON THE OUTSIDE OF THE FUEL TANK, WHICH WAS WHERE THE GAS LEAK WAS COMING FROM. IT APPEARED THERE WAS A DEFECT IN THE FUEL TANK. IF THE FUEL TANK WAS DAMAGED, T HEN THERE WOULD HAVE BEEN AN INWARD DENT IN THE TANK, WHICH WAS NOT THE CASE. THE FAILURE MILEAGE WAS 307,097. UPDATED 11/10/11*LJ UPDATED 06/13/12

I HAVE HAD TO REPLACE THE GAS TANK ON MY CAR TWICE. THE FIRST TIME THE TOYOTA DEALER REPLACED THE ORIGINAL GAS TANK. THE NEW REPLACEMENT TOYOTA GAS TANK DEVELOPED CRACKS ABOVE THE EXHAUST PIPE WITHIN THREE YEARS FROM THE DATE THAT IT WAS REPLACED. THESE CRACKS WERE NOT CAUSES BY EXTERNAL WEAR, ABRASIONS OR DEBRIS, BUT RATHER APPEARED AS A FISSURE IN THE METAL OF THE TANK. IN BOTH CASES, DUE TO THE LOCATION OF THE LEAKS ABOVE THE EXHAUST PIPE, GASOLINE WAS DRIPPING ONTO THE EXHAUST PIPE SHIELD, WHICH IS VERY HOT AND RISKS FIRE. DESPITE THE DEFECTIVE PART, THE TOYOTA DEALER WOULD NOT REPLACE IT WITHOUT CHARGING ME FOR THE FULL COST OF A 3RD GAS TANK PLUS LABOR. *TR

DT*: THE CONTACT STATED WHILE PARKED, A SMELL OF GASOLINE WAS PRESENT AROUND THE VEHICLE. UPON SELF INSPECTION, THE CONTACT NOTICED THAT THE GAS TANK LOCATED ON THE REAR PASSENGER SIDE WAS LEAKING FUEL. THIS WAS THE 2ND TIME, FUEL HAD LEAKED FROM THE GAS TANK. THE VEHICLE WAS TAKEN TO THE AN INDEPENDENT REPAIR SHOP IN 10/05 FOR THE SAME PROBLEM, AND THE FUEL TANK WAS REPLACED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED.

THE GAS TANK DEVELOPED CRACK/LEAK DIRECTLY OVER THE EXHAUST HEATSHIELD. THE LEAK IS IN A LOCATION TOTALLY PROTECTED FROM ANY ROAD DEBRIS IMPACT, THERE ARE ALSO NO SIGNS OF TRAUMA. THE LEAK WAS LOCATED AFTER SMELLING RAW FUEL, SEEING A DROP ON THE REAR EXHAUST HEATSHIELD THEN REMOVING THAT HEATSHIELD. ONLY THEN WAS THE LEAK LOCATION VISIBLE.*AK

FUEL TANK DEVELOPED A LEAK. CONSUMER COULD SMELL GAS, AND PRESSURE FORCED ALMOST ALL THE GAS OUT, IT DRIPPED ONTO EXHAUST HEAT SHIELD, COULD HAVE CAUSED A FIRE. HAD A NEW GAS TANK PUT IN. IN AUGUST 1999, NEW GAS TANK DEVELOPED A LEAK, DRIPPING ON EXHAUST SHIELD. *AK CONSUMER STATES THAT IN BOTH INSTANCES, THE GAS TANK SHOWED BUBBLES IN THEMETAL HULL AND CRACKS DEVELOPED AT THE MOST SEVERE BUBBLES ALLOWING FUEL TO LEAK OUT. *SLC

NOTICED AN ODOR OF GAS FROM THE VEHICLE. CHECKED THE VEHICLE AND FOUND FUEL OOZING FROM BOTTOM OF FUEL TANK. LOCATION OF LEAK WAS IN AN AREA PROTECTED FROM DEBRIS ABOVE THE HEAT SHIELD OF THE EXHAUST PIPE. NO PHYSCAL DAMAGE TO TANK NOTICED. POSSIBLE FIRE HAZARD.*AK

THE FUEL TANK CRACKED CAUSING A FUEL LEAK WHICH MAY HAVE RESULTED IN A FIRE. DEALER CANNOT DETERMINE THE PROBLEM. *YC

NOTICE WHITE SMOKE, FUEL ON THE GROUND, FIRE IN REAR OF THE ENGINE, POSSIBLE FUEL LEAK. TT

VEHICLE HESITATES/BUCKS WHEN SPEEDING AT 55 MPH OR MORE AND DRIVER TAKES FOOT OFF ACCELERATOR; ALSO, FUEL CUTS OFF SOLENOID, POSSIBLE FAILURE.