2006 Toyota Highlander SERVICE BRAKES, HYDRAULIC

The contact owns a 2006 Toyota Highlander. The contact stated while driving at various speeds, the brake pedal had to be pumped several times to stop the vehicle. The contact stated that the ABS warning light and several other unknown warning lights were illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was informed of the failure but offered no assistance. The failure mileage was approximately 175,000.

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THERE WAS A RECURRING FAILURE IN WHICH THE VEHICLE EXPERIENCED AN INCREASED STOPPING DISTANCE WHEN BRAKING AT LOW SPEEDS. IN ADDITION, THERE WAS A SLIGHT HESITATION WHEN ENGAGING THE BRAKES BEFORE THEY WOULD RESPOND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS IN WHICH THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE ROTORS WERE REPAIRED ONCE BUT DID NOT CORRECT THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 65,623.

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 10V499000 (SERVICE BRAKES, HYDRAULIC: FOUNDATION COMPONENTS: MASTER CYLINDER). AN AUTHORIZED DEALER WAS NOTIFIED AND THEY INFORMED THE CONTACT THAT THE PART NEEDED FOR REPAIRS WAS ON A MASSIVE BACKORDER IN WHICH A TIME FRAME COULD NOT BE PROVIDED FOR THE AVAILABILITY OF THE PART. THE CONTACT HAD NOT EXPERIENCED A FAILURE WITH THE VEHICLE.

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN THE BRAKES WERE APPLIED AND THE BRAKING DISTANCE HAD INCREASED. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO REPLACED THE MASTER CYLINDER. THE CONTACT STATED AFTER THE VEHICLE WAS REPAIRED THE BRAKES DID NOT FEEL SAFE AND THE VEHICLE WAS DRIVEN TO THE DEALER. THE DEALER STATED THE FRONT BRAKE PADS WERE REPLACED; HOWEVER, THE CONTACT DID NOT HAVE THE FRONT BRAKE PADS REPLACED. THE CONTACT STATED THE MASTER CYLINDER WAS STILL FAULTY AND THE VEHICLE WAS UNSAFE TO DRIVE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 105,000.

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THERE WAS NO HYDRAULIC PRESSURE ON THE BRAKE PEDAL AND THE PEDAL TRAVELED TOO FAR INTO THE FLOORBOARD WHEN DEPRESSED. THE CONTACT BELIEVED THAT THERE WAS EITHER AIR IN THE BRAKING SYSTEM OR A DEFECTIVE MASTER CYLINDER. THE PROBLEM WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE BRAKES WERE BLED TWICE BUT THE FAILURE CONTINUED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HIM TO TAKE THE VEHICLE TO THE DEALER BUT OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 150 AND THE CURRENT MILEAGE WAS APPROXIMATELY 35,000.

S10 DIRECT REPLY - COURTESY COPY SENT TO THE SECRETARY SENT FROM RE THE PROBLEMS EXPERIENCED WITH HIS 2006 TOYOTA HIGHLANDER. *KB THE CONSUMER STATED AFTER HE HIT A BUMP OR JUST TO SLOW DOWN, IT FELT AS THOUGH THE BRAKES WERE NO LONGER WORKING. IN ADDITION, HE EXPERIENCED AN EXTRAORDINARY NOISE FROM THE FRONT BRAKES WHENEVER THE BRAKE PEDAL WAS DEPRESSED. THE CONSUMER WAS TOLD IT WAS A TYPICAL SOUND FROM THE BRAKES FOR HIS MODEL/YEAR VEHICLE. *JB UPDATED 11/12/10.*JB

WE OWN AN 2006 TOYOTA HIGHLANDER HYBRID AND WE HAVE HAD TIMES WHERE THE BREAKS APPEAR TO CUT OUT FOR A SECOND WHEN SLOWING THE CAR TO TURN A CORNER. THE CAR WILL SURGE AHEAD WHILE THE BREAK IS BEING USED DURING THE TURN WHICH CAN BE DANGEROUS IF YOU ARE NOT EXPECTING IT. WE HAVE LEARNT TO EXPECT IT AND TAKE EXTRA CAUTION NOW WHEN MAKING TURNS. THIS HAS BEEN HAPPENING SINCE WE BOUGHT THE CAR AND IT HAPPENS A FEW TIMES EACH WEEK. *CN

WE HAVE A RECURRING PROBLEM WITH THE BRAKING SYSTEM IN OUR 2006 TOYOTA HIGHLANDER HYBRID. OCCASIONALLY, WHEN WE ARE TRAVELING BELOW 40 MPH AND HIT A BUMP, IT FEELS LIKE THE BRAKES STOP WORKING FOR 1 - 2 SECONDS. IT IS VERY DISCONCERTING, BUT SO FAR HAS NOT CAUSED ANY ACCIDENTS. IT IS DIFFICULT TO REPLICATE, SO THE DEALERSHIP HAS TAKEN NO ACTION ON IT. *TR

TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. WHILE ENGAGING THE BRAKE PEDAL AT SPEEDS OF LESS THAN 10 MPH DOWNHILL OR ON A RAMP, THE VEHICLE RESPONDED AS IF THE BRAKES HAD FAILED AND LUNGED FORWARD. WITHIN MINUTES, THE BRAKES BEGAN FUNCTIONING NORMALLY. THE DEALER WAS CONTACTED; HOWEVER, THEY WERE UNABLE TO DUPLICATE THE FAILURE. THERE WERE NO RECALLS AND NO REPAIRS WERE MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 29,118 AND THE CURRENT MILEAGE WAS UNDER 30,000.

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT WAS DRIVING AT APPROXIMATELY 40 MPH WHEN HE NOTICED THAT, ALTHOUGH HE DEPRESSED THE BRAKE PEDAL WHILE DRIVING OVER A BUMP IN THE ROAD, THE VEHICLE DID NOT SLOW DOWN. HE ALSO EXPERIENCED THE SAME BRAKE FAILURE WHEN ON FLAT PAVEMENT. ANOTHER DRIVER OF THE VEHICLE ALSO NOTICED THE BRAKE PROBLEM. THE CONTACT CALLED THE MANUFACTURER AND WAS TOLD THAT THEY COULD NOT ASSIST HIM WITH THE REPAIR COSTS. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000. THE CURRENT MILEAGE WAS APPROXIMATELY 43,000.

THIS IS AN ON-GOING OCCURRANCE. I OWN A 2006 TOYOTA HIGHLANDER HYBRID THAT IS HAVING BRAKE PROBLEMS. WHEN I PRESS ON THE BRAKE PEDAL MY VEHICLE WILL LUNGE FORWARD FOR A BRIEF MOMENT AND THEN ENGAGE THE BRAKES. IF I WOULD BE CLOSE ENOUGH TO ANOTHER VEHICLE I WOULD END UP REAR-ENDING THE VECHILE IN FRONT OF ME. *TR

BRAKE PEDAL TRAVEL LONGER TOWARDS THE FLOOR BEFORE IT WILL STOP. IT FEELS LIKE IT WILL NOT STOP. BATTERY DRAINS OUT AFTER SITTING IN A GARAGE. *TR

WE OWN A 2006 HIGHLANDER WHICH WE PURCHASED NEW. IT HAS 18,000 MILES ON IT. WHEN GOING DOWN OUR DRIVEWAY (185 FEET AT 35 DEGREE SLOPE) WHEN THE BRAKES ARE ACTIVATED TO STOP BEFORE ENTERING A CROSS STREET, ON OCCASION THERE IS LITTLE TO NO BRAKING. IT BECOMES NECESSARY TO QUICKLY PUMP THE BRAKE TO ACCOMPLISH BRAKING. THIS HAPPENS INTERMITTENTLY. DISCUSSIONS WITH THE TOYOTA DEALER RESULTED IN NO RESOLUTION. THE EXPLANATION WAS THAT THE VEHICLE'S COLLISION AVOIDANCE SYSTEM OR ABS WAS SENSING THE SLOPE AS A DECELERATION AND WAS REACTING ACCORDINGLY. THEY SAID THERE WERE NO REPORTED PROBLEMS (RECALLS) PERTAINING TO THIS ISSUE AND WE SHOULD JUST CONTINUE TO BE READY TO PUMP THE BRAKE OR PUMP THEM BEFORE WE START DOWN THE DRIVEWAY. *TR

COMPLETE BRAKE FAILURE WITHOUT WARNING ON THREE SEPARATE EPISODES IN THE PAST TWO MONTHS. BRAKE MASTER CYLINDER REPLACED BY DEALER. BRAKES AGAIN SERVICED BY DEALER, BUT I AM NOT AWARE OF WHAT WAS DONE. BY LUCK ONLY, THE FAILURES OCCURRED IN LOCATIONS WHERE TRAFFIC COULD SWERVE TO AVOID HITTING US, OR WE HAD ROOM TO GO OFF OF THE ROAD AND HIT A SNOW BANK OR COAST TO A STOP. *TR

TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHENEVER THE CONTACT ATTEMPTS TO APPLY THE BRAKES AT LOW SPEEDS, THE BRAKES BECOME UNRESPONSIVE, AND THE STOPPING DISTANCE INCREASES. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE INTERMITTENT FAILURE WAS DIAGNOSED BY THE DEALER, BUT STILL PERSISTS. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 46,000.