2021 Toyota Highlander UNKNOWN OR OTHER

Transmission. I believe the transmission is defective. A lot of customers has complained that toyota Highlander 2021 transmission is defective I was driving my car and the transmission went bad, I could not move my car again. I had to tow it to a mechanic and they diagnose that the transmission is bad

Glass in sunroof exploded, loudly, while driving on interstate, at 65 miles an hour, showering passenger and driver in shards of glass. There was no impact to the sunroof. Just a loud explosion. Heavy traffic at high speed while covered in glass had to make emergency stop. Glass could have easily gotten in our eyes. Thank goodness the two of us were wearing a ball cap and a visor. Would gladly have car available for inspection upon request. We will take pictures.

My car has been making a grinding and whining noise. I took it to the dealership and the service manager stated Toyota has been having a known issue on transmission and it will have to be replaced. The vehicle can stop working while i am driving and cause a very bad accident.

The sunroof glass on our 2021 Highlander unexplainably shattered on our ride home on 7/20/25 at approximately 12:30PM. Sky was overcast, and the temperature was in the mid 80's. We had just entered the highway and were still accelerating to highway speed. We were not near a pedestrian overpass where a rock could have been tossed from above. Broken glass edges are pointing upward. The sunroof was in the fully closed position and not tilted. Safety would have been at extreme risk if we did not have the inner slide closed. The vehicle has not yet been inspected by the Toyota dealership or insurance.

Transmission is making a wheezing noise

Air conditioning lines eroded and needed to be repaired after 26,000 miles/ 3 or 4 years. A/C line repair cost was $2500. Vehicle is garage kept and cleaned regularly during winter, it should not be having rusting problems, especially in this good of condition.

My 2021 Toyota Highlander, purchased with 16k miles, has a leak in the AC system in the rear of the vehicle (as of May 2025, at 3 years 10 months into the vehicle's service, with 28k miles). This pipe runs the length of the car and costs $2000-$3000 to repair. This was confirmed at an independent service center that used leak detection dye to identify the problem. I am finding multiple reports of people having this problem in young Toyota vehicles (<4 years old) and with low miles. I believe this is a design flaw and not indicative of normal corrosion, as the vehicle does not exhibit corrosion elsewhere in the under carriage.

MY TRUNK WILL NOT OPEN OR CLOSE PROPERLY FAULTY SENSORS

Started with a transmission whining. Now is setting check engine light and jerking. Toyota knows there is a manufacturing defect in the UA80 transmission in these vehicles, but continued to sell them even after the released TSB# T-SB-0008-21, and refuses to repair this under warranty. Toyota is the only company offering replacement transmissions and therefore can set there own price to scam consumers. Please help us get a resolution.

The rear hatch has been causing me issues for quite a while. Last year, I would have to hit the close button once or twice for it to close. It would close a few inches, beep, and then stop. It has become much worse the last six months. I have to manually close the hatch myself because it won't go down all the way using the button. We took it to Cedar Rapids Toyota and they said this is a very common issue in this vehicle. They adjusted the hatch and lubricated it. Once they were done, they said it doesn't work any better. It costs over $1,000 to replace the parts and they can't get the parts until June because so many people are having the same issue. This vehicle needs to be recalled. Thanks,

While pulling onto highway I heard a loud pop and scratching noise. Pulled off road and looked at vehicle from outside. When I looked on top I saw that the glass from sunroof had a hole and had shards like it had exploded from inside pressure.

Infotainment system, this system comes with talk to text abilities. However, the system will say it is not compatible with the device which isn’t true as this same device work from day one of owning this vechile. About a year after owning this vechile I began to start having issues with talk to text through Bluetooth. The only option now to respond to a text through the infotainment system is with a predefined group of messages. This is not the only case of this issue occurring as many models within the 2020-2021 Toyota have had the same issue.

The navigation has failed to perform properly since the car was new. I have complained about it/taking it in on more than one occasion. Now the car is three years old and has 23,000 miles on it. I am told I must pay to repair the navigation system which never worked properly in the first place. It directs me to roads that are closed;, finds the store I wish to go to, but then says I can’t navigate there;, sends me to a residential neighborhood when I have put in the address of a school;, changes the address I input while I am enroute. It is supposed to navigate to addresses in my contact list, but when I select a contact it then asks me to choose from a similar name in a different state than I have entered in my contacts. I am very curious to know if there have been other complaints or technical service bulletins.

On 2023, the bumper of my car fell while I was driving on the highway. At that time, I took my vehicle to the Toyota Dealership to get inspected and they inspected the vehicle and recommended me to take it to a Body Shop to get it repaired. I paid for the repairs from my pocket since they did not take any responsibility of the damages. On December 2023, I received a letter from Toyota telling me that my highlander has a recall due to bumpers felling off and needed to add some clips from the manufacturer. I opened a case and provided all the information requested by Toyota. At the end they asked me for a CCR document where none of the representatives I've spoke were able to explain what is this document. I provided receipts, Dealership inspection document, my car documents. Today 11.27.2024, I receive a letter telling me that they are not going to move forward with the reimbursement. The body shop that they recommended me does not provide a letter with the specific information they are asking me for. Toyota contacted them and confirmed they did the repairs and they still refused to pay for the manufacturer damages.

We were driving across the Texas panhandle at the posted speed limit of 75 mph. It was about noon, the outside temperature was about 60 fahrenheit & there was a cross wind of about 30 mph. There were no vehicles in front of me & the closest approaching vehicle was a good half mile away. No vehicles had recently driven past us from the approaching lane. There was a sudden explosion above us & through the 1-2" gap in the motorized retractable sunshade of our moonroof, I could see broken glass. Through that gap, some glass fragments fell in on us. I pulled over to stop, got out & inspected the roof, & the front glass panel was completely shattered & 75% gone. Many of the fragments were on the sunshade & I removed those. Going at about 40 mph we went to the closest small town where a mechanic removed some residual loose glass, vacuumed as much off the shade as he could, & patched the hole with cardboard held in place by duct tape so we could get home for a repair. If the shade had not been almost closed, we would have been showered with glass with risk of bodily & eye injury.

Sunroof shattered while vehicle was parked. Nothing touched the vehicle. We were just sitting in the car when it happened.

The sunroof exploded in 75 degree weather. My safety was put at risk by the sunroof exploding and others were put at risk that were following on highway from flying glass. The problem was confirmed by safelite. Toyota refuses to take any responsibility. The sunroof was inspected and repaired by safelite. There was no warning that the sunroof was going to explode. The vehicle maintenance is at the highest level.

This is my new car certified

The sun roof on this car spontaneously combusted. I was able to pull up many other complaints regarding the same issue on this car. This needs to be recalled. My [XXX] baby could have had shattered glass had we not had it closed. These sun roofs need to be recalled and inspected! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had been driving for about 20 minutes at approximately 50-55 MPH when the check engine light came on. Seconds later, the red hybrid malfunction message displayed and I lost the ability to accelerate. I was able to pull over and I saw grayish smoke and flames coming from under the hood on the right side. I exited the vehicle and called 911. It took moments from the start to being completely engulfed in flames. Several loud pops or explosions happened during this period. The police and fire department arrived and extinguished it.

Driving back from lunch with a friend we heard a pop and loud shattering sound as my sunroof glass exploded for no apparent reason. I called the dealer where I purchased the car 40 days ago with every extended warranty that I could. Toyota denied the claim stating that there was not any bulletins stating material defect and that the glass was not part of any warranty and I will have to file an insurance claim.

I have noticed that my vehicle tends to jolt forward as I’m applying the brakes to come to a complete stop.

The Passenger rear tire burst automatically today around 8 AM morning. Unsure if this automatic burst is part of any recall or not but it was a scary burst with big noise with no warnings of low air pressure. A lot of time was wasted today and spent money to fix a new tire.

Driver side mirror glass started shaking all the time. The mirror frame is stable, but the mirror glass is shaking when car is idling and driving. Makes it almost impossible to use that mirror when driving

Driver side view mirror shakes a lot making it impossible to make things out in your mirror while driving. Very dangerous to see what is in your mirror.