2012 Toyota Prius Brakes

Brakes failed

ABS pump and master cylinder malfunction. Pump is running very often. Hard braking makes it sound abnormally.

The brakes on this Prius started to make weird noises. Because it is a hybrid, I wasn't sure if it was normal. After searching online, it is a known issue. The car has just under 76,000 miles on it. It might be worth $7000 on a good day. Toyota wants to replace two brake parts, numbered 47050-52020 and 04006-74152 to a tune of $2700. According to a Toyota bulletin, this job should take 2.3 hours. For that amount of work, my local Toyota shop wants almost $2000 in labor. My car was seen by the local shop (being on an island, it is literally the only Toyota shop that this car can be seen) when the "customer support program" 21TE01 was in place and they did nothing. Now, the time window has disappeared, even though we only have half of the maximum number of miles to get the repair. Toyota should be ashamed of themselves.

I accidentally slid out into traffic as my brakes failed as I pulled up to stop at the edge of the parking lot. I was nearly hit driver's side on a pickup. Fortunately, it was able to swerve around me and there was no immediate following vehicle. I was able to pull out and back into a nearby parking lot to address the problem with my brakes. Upon speaking to my mechanic and local Toyota Dealership I was informed that the brake booster/accumulator had failed and that this was a known issue on my vehicle. Toyota extended a special warranty on these parts several times but did not notify owners of the safety risk. That warranty coverage has expired for my vehicle. I believe it is an inherent safety risk and they obscured it by covering the parts under this extended warranty. I believe they should be recalled and at the least owners should be warned of the risks. All communications were done over the phone or in person, I have no electronic records. I submitted an identical request on my 2011 Prius by accident, as I used it's VIN when I meant to use the VIN on my 2012 Prius. Regardless, I am now concerned for my safety in both vehicles.

My wife was driving home and four dashboard error lights illuminated (Brakes, ABS, SLIP and a yellow light_) The brakes suddenly "went soft" (in her words), and it freaked her out. I now learn that I need to have the brake master cylinder and a booster pump assembly replaced at a cost of over $4,000. Ouch!

Failure in ABS system

Vehicle has good break pads and rotors. Also the vehicle turn on the ABS the Break and the slippery lights on. When the car was scanned is show code C1391" which indicates a problem with the brake accumulator within the system, often requiring replacement of the brake booster and accumulator assembly. I can't drive the car and other people with same car on 2011 year has the same issue

Brake system went out suddenly making the car brakes not work

While driving suddenly the ABS and vehicle traction lights came on and the car became very slippery, was unable to stop without an excessive amount of space between the car in front of me and me. While looking at the car, I realized the actuator brake booster pump. I then found multiple websites and forums dedicated to people with the same problem ( brakes suddenly not functioning correctly while driving) with the same model car as I have, and there was a service bulletin that shows Toyota acknowledged there was a problem ( and a fix) but with the date of the bulletin and the date it was to be fixed within, it was near impossible to actually have it fixed. My car has 87,000 miles and the brake system is dangerous

My Brakes almost caused me to crash on Jan 18th. I'm driving down the highway and traffic comes to a complete stop. I started braking but my abs, stability control and brake light come on. When this occurred I had to push the brakes to the floor just to stop. My brakes were very unsafe and unpredictable. I had to drive way below the speed limit to make it home, keeping at least 8 car lengths between me. I inspected the vehicle when I made it home. Their is noise coming from the driver side firewall. Something is consistently turning on and off and a slight click after each cycle, every 5 seconds approximately. I was told that it was my abs pump or brake actuator. This is unacceptable and dangerous to all consumers. The fact there was no warning that occurred in a safer environment. I'm so thankful my kid wasn't driving it. Why isn't this a recall? I don't understand how something this dangerous is not a factor to the consumers. I have researched and found many cases that consumers have had a similar issue. This issue is not like brake pads. Their is a clear warning when its time to change brake pads. I honestly would like to see toyota to fix this issue.

My ABS actuator failed. Turns off the boosted braking and cruise control. This is a known issue in Toyotas and it always happens outside the warranty window. This is putting my safety at risk as the brakes don’t work as they’re supposed to

Brake booster pump assembly. Toyota has sent a notice of extended warranty for this vehicle which has expired. Without repair, the brakes will loose compression and stop working.

The brake actuator has failed in this 2012 Prius with 135,000 miles. No issues were noticed while braking, however, when starting the car, the ABS, Brake and Traction Control warning lights lit up. The Toyota Dealership said this is a failed Brake Actuator and quoted $3,800. We have learned there is a secondary warranty on this part due to constant failures that Toyota issued, however, this warranty only applies to Prius up to 150,000 miles or 10 years from initial use, whichever comes first. This is unfair to most Prius users as this is a common problem happening, but typically happening after the 10 year mark.

The ABS, Brake, and Traction Control lights all illuminated while driving. I took it into a local shop, the computer scanned "brake accumulator leak". The accumulator is buzzing every 10 seconds and the brake fluid needs topping up. Now there is a brake fluid puddle under the car. The fix is to repair the brake master cylinder and replace the brake booster pump. The car is a 2012 with 110,000 miles. This is a known Toyota Prius vehicle issue but they decline to service it and can the brakes can fail.

The issue is my brakes failed on me all of a sudden. My abs light, traction control light, and brake light came on out of nowhere. Suddenly didn't have brake pressure. Had to pump the brakes a few times before the car would stop. Luckily I didn't hit anything or anyone. I brought the car to Prius specialist and they diagnosed it saying it was the ABS Actuator Pump Assembly and Master Cylinder. They said it is quite common in the 3rd generation of Prius'. I contacted Toyota North America and they said they had a recall on the parts but it ended Dec 31st, 2021. I bought the car in 2022 unknowingly. Was quoted around $4000 to repair it parts and labor. This is a safety issue that should not be limited to time. Luckily I was not on a Freeway or anywhere where I could have done damage. This issue is a hazard to myself and other people on the road. Toyota needs to resolve this.

2012 Toyota Prius 5 with 105k miles. ABS, Brake, and Traction Control lights all illuminated while driving to work. Drove to the dealership and had their service department run a diagnosis for 200$. Their scanner reported CODE C1391, and that a new BRAKE PUMP and MASTER CYLINDER ASSEMBLY would need to be replaced for a total cost of $4,000. Toyota has a Customer Support Program Bulletin indicating that certain 2010-2015 Toyota Prius will experience internal malfunctions and require repair for BRAKE BOOSTER AND BRAKE BOOSTER PUMP ASSEMBLIES. Since this is a safety issue, Toyota should extend the program indefinite and repair their faulty systems.

ABS Pump and Actuator failed at 100,000 miles. Traction control, ebrake, ABS light came on while driving. Many other stories of Toyota vehicles with the same failure.

I was driving down the interstate with my cruise control on when all of a sudden the cruise control disabled and warning lights came up on my dash board. It still drove fine for several weeks. On Friday December 6th, I was going down the road and had to press the brake slightly for a car turning. When I pressed the brake, the car went into a spin. It spun a couple of rotations. Luckily I was on a wide part of the highway and no oncoming cars were approaching. Toyota had a recall for the same code and parts for the 2010 Prius but did not include the 2012 Prius. They just had an alert which I did not receive because the notice went to the former owner. However, I did take my car in for oil change and diagnostic but they did not tell me that there had been a problem with these parts. They want almost $4,000 to repair it. Why would they not include ALL vehicles with this same part. If it fail on one, it will fail on another. I think Toyota should make them all good. Please make them issue a recall for all of these parts. I took my car to a mechanic but because of special tools needed, you have to take your car to the dealership for repairs. When I called the dealership, I was told I needed a break booster pump and a brake master cylinder for a total of $3, which is ridiculous on a $7,000 car.

The Toyota Prius of this generation has a known defect in the brake booster pump assembly. About 2 weeks ago the dash lights came on for ABS, Traction control, general warning light. The brakes work but feel soft, and a motor sound pulses behind the steering column every 8-10 seconds. My mechanic pointed out it is a known problem where the ABS booster pump has a faulty valve that doesn’t allow proper pressure to build to engage ABS system. I cannot afford the Repair: $3890 for master cylinder and brake booster. My concern is that most people can’t afford this repair and without a functioning ABS system, people are put at risk from this generation of Prius. Toyota did offer a customer service program acknowledging the issue, but that program only helped if these issues occurred before 2022. With the known issue, why wasn’t a recall required? Toyota should be required to address this safety issue. How many of these Prius are on the road where customers are expected to perform a $4,000. Repair to keep up the safety standards. The car is available for inspection upon request. Thank you.

while driving i lost the power braking on my vehicle and the abs, traction and another exclamtion point symbol came on. my brakes had to be pushed really hard all the way down to the floor board increasing my braking distance.

Brake booster has gone out. This is a known, dangerous issue that Toyota knows will occur, It is a dangerous and expensive risk to those driving these ticking time bombs, and those potentially in the path of these vehicles. This is a pure safety risk item. No one asking for these brake actions are gaining anything materially other than the use of their cars safely. To make matters worse, Toyota doesn’t even make these in volumes that don’t generate volume pricing efficiency, meaning replacement runs upward of $4k to $5k at their dealerships to replace. Criminal…. Please help.

Code C1391 shows in which the accumulator and the brake booster assembly need to be changed. This is a known defect and was covered through an ‘extended warranty’ due to a lawsuit. Since it results in less than optimal braking, and can result in crashes since function disappears suddenly, it should have warranted a recall. This issue is also known to happen in multiple Toyota hybrid vehicles.

I write to add my voice to the litany of complaints in support of NHTSA investigation DP23005. While on an road trip recently the ABS, Traction Control, and Brake warning lights all came on. The brake felt squishy and didn't seem to be functioning as confidently as before. I altered my driving (giving plenty of distance, lowering my speed) so that in the event the brakes quit working I would have an exit strategy. I took it to my Independent Service Center as soon as possible who found the code C1391 and diagnosed the need to replace the master cylinder / booster assembly for several thousand dollars. Of course I must do this in order to remain safe but this is clearly a safety issue that could have been catastrophic. Meanwhile I am out of a car for several weeks until the part arrives and out of at least $2000 as quoted by my mechanic ($1640 for the part). The car only has 146,500 miles on it so otherwise would have plenty of life left in it. I'm filing this complaint to add my voice to the open petition and toward the NHTSA's investigation in strong support of holding Toyota responsible for PREVENTING injury and death through a proper recall, as well as against burdening the car owner with the costs of making up for Toyota's negligence on this issue. At the least they need to cover the cost of these necessary safety repairs when they are warned by the lights and reinstate their warranty extension for this issue

I write to add my voice to the litany of complaints in support of NHTSA investigation DP23005. While on an interstate road trip recently the ABS, Traction Control, and Brake warning lights all came on. The brake felt squishy and didn't seem to be functioning as confidently as before. I altered my driving (giving plenty of distance, lowering my speed) so that in the event the brakes quit working I would have an exit strategy. I took it to my Independent Service Center as soon as possible who found the code C1391 and diagnosed the need to replace the master cylinder / booster assembly for several thousand dollars. Of course I must do this in order to remain safe but this is clearly a safety issue that could have been catastrophic. Meanwhile I am out of a car for several weeks until the part arrives and out of at least $2000 as quoted by my mechanic ($1640 for the part). The car only has 146,500 miles on it so otherwise would have plenty of life left in it. I'm filing this complaint to add my voice to the open petition and toward the NHTSA's investigation in strong support of holding Toyota responsible for PREVENTING injury and death through a proper recall, as well as against burdening the car owner with the costs of making up for Toyota's negligence on this issue. At the least they need to cover the cost of these necessary safety repairs when they are warned by the lights and reinstate their warranty extension for this issue ("POL18-03") which expired for my vehicle in August of 2021.

have suddenly brake failture, w code c1391, it problem persist car do not stop by pressing brake , it is too dangerous to drive this car!!!! what you can help me w this recall or rebate option for brake repair?