2016 Toyota Prius Tires

Prinx HiCITY HH2 175/65R15 84H Bought this tire in November 2022. About 15000 miles into it, on Aug 6, 2024, the passenger front tire just busted. After swapping with the spare tire, and upon inspection, there was no nail nor it hit the curb, but the side wall is busted. This is a manufacturing quality issue.

See attached document for complaint

The contact owns a 2016 Toyota Prius equipped with Cooper Tires, Tire Line: Mastercraft, Tire Size: 195/65/15, DOT Number: (Not Available). The contacted stated that while driving approximately 65 MPH, the vehicle began to violently shake and vibrated. After stopping to inspect the vehicle, it was discovered that the passenger’s side rear tire had experienced sidewall steel belt separation. The cause of the failure was not determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was approximately 20,000.

2015 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO ISSUE WITH VEHICLE TIRES. *LD THE CONSUMER STATED THE TIRES HAD A BROWN SUBSTANCE ON THEM. THE CONSUMER WAS INFORMED THE TIRES WERE NOT NEW LIKE THE DOCUMENT FROM THE DEALER STATED THEY WERE. THE TIRES NEEDED TO BE REPLACED. THE DEALER WAS NOTIFIED, BUT DID NOT OFFER ANY ASSISTANCE. *JS

WE PURCHASED A NEW 2016 PRIUS FROM LONGO TOYOTA IN MARCH 2016. EVERYTHING HAS BEEN FINE UNTIL MARCH 2018 WHEN WE HAVE HAD TWO INCIDENTS WHERE THE NEXT MORNING A TIRE WAS COMPLETELY FLAT WHEN IT WAS PERFECTLY FINE THE NIGHT BEFORE. THE OE TIRES ARE TOYO NANOENERGY A29 P195/65R15. NOW IT HAS HAPPENED A THIRD TIME, APRIL 15, 2018. IT IS PARKED IN MY GARAGE OVERNIGHT SO ITS IMPOSSIBLE TO BE TAMPERED WITH. ALL THREE INSTANCES HAVE BEEN EXACTLY THE SAME. THE CAUSE HAS BEEN A SMALL HOLE IN THE OUTSIDE SIDEWALL. I HAVE TO BELIEVE THAT THESE TIRES ARE DEFECTIVE SINCE IT HAS NOW HAPPENED TO 3 OUT OF THE 4 ORIGINAL TIRES. THERE IS NO EVIDENCE OF A NAIL, SCREW, DEBRIS, ETC., THAT WOULD CAUSE THIS SMALL HOLE/TEAR. WE HAVE 30K MILES ON THE TIRES AND THE TREAD IS STILL PRETTY DECENT.

TL* THE CONTACT OWNS A 2016 TOYOTA PRIUS EQUIPPED WITH YOKOHAMA BLUEARTH S34 TIRES, SIZE: P215/45R/17 (NA). WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY BECAME UNSTABLE AND A THUMPING NOISE WAS PRESENT COMING FROM THE REAR END. AFTER STOPPING THE VEHICLE AND INSPECTING IT, THE CONTACT DISCOVERED THAT THE REAR DRIVER SIDE TIRE WAS FLAT. AFTER REMOVING THE TIRE, IT WAS DISCOVERED THAT THE SIDEWALL BLEW OUT INSIDE THE TIRE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE TIRE AND VEHICLE MANUFACTURER WERE BOTH NOTIFIED ALONG WITH THE LOCAL TIRE DEALER (LES SWAUB AND GOODYEAR). THE VIN AND DOT NUMBER WERE UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 15,900.

AT HIGHWAY SPEED TIRE TREAD SEPARATED COMPLETELY FROM SIDEWALL ON BOTH SIDES OF RIGHT REAR TIRE. VEHICLE: 2016 TOYOTA PRIUS TWO ECO. TIRES - MANUFACTURER: TOYO - MODEL: NANOENERGY A29 - DOT CODE: N39N SIZE:195/6515 TIRE - DATE OF MANUFACTURE: 1216 (DECEMBER 2016)