2002 Toyota RAV4 Engine

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE DRIVING LOW SPEEDS, THE VEHICLE WAS ABNORMALLY LOUD WHILE IDLING AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE UNINTENTIONALLY ACCELERATED ON OCCASION. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 91,789.

COMPUTER FAILS. *TR

MY CHECK ENGINE LIGHT CAME ON IN NOVEMBER. I HAD IT CHECKED OUT BY NUMEROUS PLACES. THEY ALL TOLD ME IT WAS MY OXYGEN SENSOR (BANK 1 SENSOR 1), SO I REPLACED THAT TWICE. MY CHECK ENGINE LIGHT HAS STILL NOT SHUT OFF. I HAVE BEEN HAVING TO PURCHASE GAS DAILY AND CAR IS NOT RUNNING AS WELL. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT HEARD A GRINDING SOUND COMING FROM THE FRONT END OF THE VEHICLE FOLLOWED BY THE VEHICLE STALLING. THE VEHICLE WAS TOWED TO THE CONTACTS HOME AND WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT HAD PREVIOUSLY TAKEN THE VEHICLE TO THE DEALER FOR A SIMILAR FAILURE WHERE THE TECHNICIANS REPLACED THE FLYWHEEL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 128,000. UPDATED 04/19/12*LJ UPDATED 04/25/12

I HAVE TAKEN MY 2002 RAV4 TO TOYOTA ON A FEW OCCASIONS. EVERY TIME IT HAS BEEN AN OXYGEN SENSOR OR FUEL SENSOR. WE HAD THESE REPLACED AND NOW TOYOTA IS TELLING US WE NEED TO REPLACE THE ENTIRE CATALYTIC CONVERTER ($1000). THE TRANSMISSION, ACCORDING TO THEM, IS NOT FULLY FUNCTIONAL. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED, AND SHE WAS UNABLE TO SHIFT GEARS. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE FAILURE WAS WITHIN THE ELECTRIC CONTROL UNIT. THE VEHICLE WAS TAKEN TO A FOREIGN GARAGE SPECIALIST WHO REPLACED THE ELECTRONIC CONTROL UNIT. THE CONTACT RECEIVED A LETTER FROM THE MANUFACTURER CONCERNING A WARRANTY ENHANCEMENT FOR THE ECU FAILURE, BUT THE MANUFACTURER DENIED REIMBURSEMENT SINCE THE VEHICLE WAS OVER THE 150,000 MILE WARRANTY ENHANCEMENT PROGRAM. THE FAILURE MILEAGE WAS 172,000. THE CURRENT MILEAGE WAS 188,000. UPDATED 03/07/11*LJ UPDATED 11/28/11 *CN

I WAS ENTERING THE HIGHWAY AND MY CAR WOULD NOT ACCELERATE... WAS ALMOST KILLED AND HAD TO DRIVE IN EMERGENCY LAND BEFORE BUILDING UP SPEED..... THE PROBLEM IS THE ECM IN MY 2002 TOYOTA RAV4 FAILED. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT WAS DRIVING LESS THEN 5MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE DEALER PERFORMED A DIAGNOSTIC AND ADVISED THAT THE ENGINE CONTROL MODULE WOULD NEED REPLACING. THE VEHICLE WAS REPAIRED YET THE FAILURE RECURRED. THERE WERE ADDITIONAL REPAIRS MADE TO THE THROTTLE POSITION SENSOR YET THAT DID NOT REMEDY THE FAILURE. THE DEALER THEN ADVISED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE AND ADVISED THEY WERE UNAWARE OF HOW TO CORRECT THE FAILURE. THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS 87,178 AND THE CURRENT MILEAGE WAS 88,515.

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 30-40 MPH, THE OIL PRESSURE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE FAILURE WOULD OCCUR AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN WAS UNABLE TO LOCATE A PROBLEM. THE FAILURE PROGRESSED OVER A PERIOD OF TIME. RECENTLY, THE "SERVICE ENGINE" WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DETECTED AN ENGINE OIL SLUDGE AND LOW OIL PRESSURE. ALSO, HE RECOMMENDED THE ENGINE BE REPLACED. THE CONTACT STATED THAT THE MANUFACTURER SHOULD BE LIABLE FOR THE REPAIR; HOWEVER, THE MANUFACTURER REFUSED TO TAKE FINANCIAL RESPONSIBILITY. THE VEHICLE WAS AT THE DEALER AND HAD NOT BEEN REPAIRED. THE CONTACT PLANNED TO HAVE THE VEHICLE TOWED TO HIS RESIDENCE. THE FAILURE MILEAGE WAS APPROXIMATELY 33,000.

2002 TOYOTA RAV4 STARTED HESITATING ON INITIAL ACCELERATION AND BOLTING WHEN THE GEAR CAUGHT 2ND. WAS PULLING OUT INTO INTERSECTION AND NEARLY T-BONED BY FORD EXPEDITION. BROUGHT TO TRANSMISSION SPECIALIST. NO ENGINE LIGHT, NO CODE. READ ABOUT POTENTIAL ECM PROBLEM. BROUGHT TO TOYOTA AND SPENT $1400.00 TO REPLACE ECM. *TR

IN 2003 WE BOUGHT A BRAND NEW 2002 TOYOTA RAV4. IN 2007, THE ENGINE SEIZED UP AT 56,000 MILES. WE TOOK IT TO TOYOTA AND THEY TOLD US IT WOULD COST $7,000 BECAUSE THEY NEEDED TO REPLACE THE ENGINE. AFTER GATHERING ALL OUR MAINTENANCE HISTORY AND MUCH DELIBERATION TOYOTA AGREED TO REPLACE THE ENGINE BUT WE HAD TO PAY FOR THE LABOR ($2500); WE AGREED. AFTER THEY DID THE WORK, WE HEARD A SOFT CONSTANT BEATING SOUND COMING FROM THE ENGINE. WHEN WE TOOK IT BACK, WE WERE TOLD THAT SOUND WAS NORMAL WHEN A NEW ENGINE IS INSTALLED AND IT WILL GO AWAY -- IT DIDN'T. 18 MONTHS AND 10,000 MILES LATER, THE ENGINE DIED AGAIN. BAFFLED AT HOW TWO SEPARATE ENGINES CAN DIE WE TOOK IT TO OUR PERSONAL MECHANIC. HE EXPLAINED TO US THAT THE ENGINE WAS NEVER REPLACED, BUT REBUILT. WE TOOK IT BACK TO THE DEALERSHIP AND THEY REFUSED TO HELP US. SO DID TOYOTA CORP. THEY HAVE A SETTLEMENT FOR DEFECTIVE ENGINES FOR THE SAME GENERATION ENGINES (1997-2002) FOR ALMOST EVERY MODEL. EXCEPT THE RAV4. WHAT MAKES IT WORSE WAS I WAS TOLD I WAS GETTING A NEW ENGINE. AT THE SAME TIME MY PERSONAL MECHANIC HAD FOUND ME A USED ENGINE (12,000 MI) FOR 2300 INCLUDING INSTALLATION. HAD I KNEW THEY WERE GOING TO REBUILD IT, I WOULD HAVE WENT WITH THAT OPTION. SO THEY SCREWED ME OUT OF 2500, A CAR, AND A CHANCE AT ACTUALLY FIXING THE CAR. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. ON MARCH 14, 2010, THE CONTACT WAS DRIVING AT APPROXIMATELY 20-25 MPH WHEN SHE DEPRESSED THE ACCELERATOR PEDAL AND THE ENGINE SUDDENLY BEGAN TO REV. THE VEHICLE WOULD ALSO NOT SHIFT INTO GEAR. SHE NOTICED THE PROBLEM STARTED TO OCCUR ON AN INTERMITTENT BASIS FOLLOWING THE INITIAL FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE SHE WAS INFORMED THAT THE ELECTRONIC CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT THAT TIME. THE FAILURE MILEAGE WAS 73,747. THE CURRENT MILEAGE WAS APPROXIMATELY 73,800.

ENGINE SEIZE AT 162K MILES. THIS VEHICLE HAS HAD REGULAR MAINTENANCE. OIL CHANGES EVERY 3-5K MILES. APPARENTLY OIL PUMP WENT OUT AND TOOK THE ENGINE WITH IT. OWNED THIS VEHICLE SINCE IT HAD 7 MILES ON IT. IT LEFT ME STRANDED IN THE MIDDLE OF NOWHERE. PUT IN REMAN. JASPER ENGINE. AFTER ABOUT $7,000.00 THE ENGINE LIGHT IS STILL ON. THE MECHANIC SAID I COULD TAKE IT TO A TOYOTA DEALER AND THEY'D "FLASH" IT TO GET IT TO GO OFF, BUT IT WOULD COST ME A FEW HUNDRED. THE ENGINE LIGHT HAS BEEN ON SINCE ABOUT 28K MILES. TOOK IT TO THE DEALER FOR THAT AND THEY JUST UNDO THE BATTERY AND PUT IT BACK ON. THAT "RESETS" IT. WITHIN 100 MILES IT GOES BACK ON. I JUST LEAVE IT AND IF THE CAR BLOWS UP I'LL LEAVE IT WHERE IT DIES THIS TIME. I PAID 28K FOR THE CAR IN 2002, 8 YRS AGO. 28K+7K(ENGINE)=$35,000.00 $35,000.00/8(YRS)=4375(PER YEAR TO OWN.MINIMUM) 4375.00/12(MOS)=364.58 PER MONTH. VERY EXPENSIVE TO OWN AND REGULAR MAINTENANCE ISN'T EVEN INCLUDED..... TOO MANY PEOPLE HAVE HAD THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 35-45 MPH ON NORMAL ROAD CONDITIONS, PROCEEDING TO A TRAFFIC STOP SIGNAL. THE ENGINE REVED EXCESSIVELY HIGH. THE TRANSMISSION EXHIBITED A HARSH SHIFT AS A RESULT OF AN UNEXPECTED ACCELERATION. THE DRIVER WAS ABLE TO CONTINUE IN OPERATION WITH CAUTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE FAILURE WAS CONTRIBUTED TO THE ENGINE CONTROL MODULE (ECM). THE VEHICLE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 104,000. UPDATED 11/16/10. *LJ

TL*THE CONTACT OWNS A 2002 TOYOTA RAV 4. WHILE ACCELERATING FROM AN IDLE POSITION, THE VEHICLE BEGAN HESITATING AND STALLED. THE VEHICLE ALSO HESISTATED 30 TO 45 SECONDS WHEN SHIFTING INTO SECOND GEAR AND ENGAGING THE ACCELERATOR TO IT'S FULL CAPACITY. THE DEALER FLUSHED OUT THE TRANSMISSION FLUID AND REPLACED IT; HOWEVER, THE FAILURE RECURRED. THE MECHANIC LATER STATED THAT THE ELECTRONIC CONTROL MODULE (ECM) WAS DEFECTIVE. THE MANUFACTURER WILL NOT ASSUME THE REPAIR COSTS; HOWEVER, THE CONTACT STATED THAT SINCE THERE IS A DEFECT THE REPAIR SHOULD BE FREE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 96,000.

I PURCHASED A NEW 2002 TOYOTA RAV 4 IN 2002. LAST YEAR, A FEW YEARS AFTER THE PURCHASE DATE, TOYOTA HAD A RECALL FOR THE CHECK ENGINE LIGHT. I TOOK IT BACK TO THE DEALER AND THE LIGHT WAS FIXED. MAYBE A YEAR OR TWO AFTER, THE LIGHT BEGAN TO COME ON AND HAS STAYED OFF AND ON FOR YEARS. LAST YEAR, MY TRUCK BEGAN TO "HESITATE" WHILE DRIVING AND FINALLY IT BEGAN TO STOP ALL TOGETHER. I TOOK IT TO A TRANSMISSION SHOP AND AN AIR CONDITIONER BELT WAS REPLACED AND THE AGENT TOLD ME THAT HE COULD NOT FIND A PROBLEM WITH IT. FOR A DAY OR TWO, I HAD NO PROBLEMS WITH THE TRUCK. BUT SHORTLY AFTER, THE PROBLEM CAME BACK AND I WAS STUCK WITHOUT TRANSPORTATION. I WAS TOLD IT WAS A $2,500 COMPUTER ENGINE PROBLEM. I DO NOT HAVE THAT KIND OF MONEY. SO, I HAD TO RENT A CAR. MY INSURANCE WOULD NOT PAY RENTALS. EXTERNALLY, IT IS A BEAUTIFUL TRUCK, EVEN TODAY. BUT, INTERNALLY, IT COMPLETELY LET ME DOWN. WHEN I PURCHASED MY TRUCK, I THOUGHT I WAS GETTING A DEPENDABLE TRUCK THAT WOULD LAST FOR YEARS AFTER IT WAS PAID OFF. I PAID OFF THE CAR IN JANUARY OF THIS YEAR AND IT IS SITTING IN FRONT OF MY HOUSE. HOW BAD CAN THIS GET? MY TRUCK HAS OVER 140,000 MILES WHICH ACCORDING TO MY RESEARCH, EXCEEDS WARRANTY DATES. IF THE REPAIR COST IS HIGH, I WILL HAVE NO OTHER CHOICE BUT TO TRY TO SELL THE TRUCK. I WENT OUT AND BOUGHT AN AMERICAN MADE USED CAR THE OTHER DAY. IT CANNOT COMPARE WITH MY TOYOTA WHEN IT WAS IN GOOD CONDITION. NOW I AM BACK IN DEBT AGAIN. THIS TIME I GOT A THREE YEAR WARRANTY. TO MAKE A LONG STORY SHORT, I AM SO DISAPPOINTED IN THE TOYOTA RAV4 TRUCKS. ACCORDING TO THE WEB, A LOT OF US ARE. *TR

CAR TRIES TO STALLS. *TR

I BOUGHT A TOYOTA RAV4 2002 AT THE DEALER "TOYOTA OF ALAHAMBRA" AND I BEEN HAVING A PROBLEM TO MANY TIMES WITH THE COMPUTER ENGINE LIGHT COME ON. WHEN I TAKE THE CAR TO THE DEALER THEY TOLD ME THAT NOTHING WAS WRONG. THEY TURNED OFF THE LIGHT AND SAID AND SAID THAT EVERYTHING WAS OK, THIS HAPPENED THREE TIMES. RECENTLY I HAD PROBLEMS AGAIN WITH THE COMPUTER ENGINE AND THEY CHARGED $1,200.00 DOLLARS TO FIX IT AND THEY TOLD ME THAT WAS MY FAULT THAT I WAS TAKING OFF IN 2ND GEAR BUT I NEVER USE THE 2ND GEAR. WHAT I KNOW THIS CARS HAD PROBLEMS WITH THE ENGINE COMPUTER. THE NAME OF THE DEALER IS "TOYOTA-SCION OF GLENDALE" 1260 S. BRAND BLVD. GLENDALE, CALIFORNIA 91204. AS I KNOW WE HAVE 170 COMPLAINTS ABOUT THIS RAV4 TOYOTA CARS. FORTUNATELY I HAVE NOT ANY PROBLEM WITH DEATH, OR FIRE, OR CRASH, BUT I AM WORRY ABOUT THIS COMPUTER PROBLEMS, WHEN I AM DRIVING THE CAR I AM NOT COMFORTABLE DRIVING ANY MORE, CAN YOU TELL ME THAT CAN I DO ABOUT. THANK YOU VERY MUCH FOR YOUR ATTENTION. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. THE VEHICLE WAS SERVICED FOR A RECALL REGARDING THE ENGINE LIGHT. A NHTSA CAMPAIGN ID NUMBER WAS NOT FOUND. AFTER THE VEHICLE WAS RETRIEVED FROM THE DEALER, THE VEHICLE SHOOK WHILE DRIVING BETWEEN 2-50 MPH. THERE WERE NO PRIOR FAILURES OR WARNING INDICATORS. THE DEALER STATED THAT THE ECM NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 144,000 AND CURRENT MILEAGE WAS 144,411.

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 55 MPH AND DEPRESSING THE ACCELERATOR PEDAL, THE SPEED REDUCED. THE VEHICLE BEGAN JERKING AND HESITATING WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE ENGINE CONTROL MODULE FAILED. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 141,000.

MY 2002 RAV4 HAS BEEN DIAGNOSED AS HAVING ENGINE OIL SLUDGE AND NEEDS TOTAL REPLACEMENT. OIL CHANGES HAVE BEEN PERFORMED BETWEEN 3,000 - 4,000 MILES. *TR

THIS IS MY THIRD TOYOTA. I HAVE NEVER OWNED A TOYOTA THAT SMOKES. I PARK MY TOYOTA RAV 4 FOR A WHILE, AND CRANK IT UP IT AND SMOKE COMES OUT OF THE EXHAUST. THIS PROBLEM STARTED WITH ONLY 61, 000 MILES. I AM TOTALLY DISSATISFIED WITH THIS TOYOTA, AND DISGRUNTLED WITH THE POOR QUALITY OF MANUFACTURING OF TOYOTA'S VEHICLES. UNFORTUNATELY THIS WILL POSSIBLY BE MY LAST. *TR

CHECK ENGINE LIGHT CAME ON INTERMITTENTLY. DEALER SAID NYLON GEAR ON CAMSHAFT HAD DAMAGED TEETH, ALLOWING TIMING CHAIN TO JUMP BACK AND FORTH, AND THEREBY CHANGING IGNITION TIMING. COST OF REPAIR WAS $1,600. *JB

OIL WAS CHANGED REGULARLY ON THE CAR. OIL AND ENGINE LIGHT CAME ON BUT MECHANIC COULD NOT FIND A PROBLEM AND STATED THERE WAS PLENTY OF OIL IN THE CAR. DRIVING ON THE EXPRESSWAY. THE ENGINE, THEN OIL LIGHTS CAME ON, AS I PULLED OVER THERE WAS A LOUD NOISE, AND EVERY THING FROZE. I WAS TOLD THE ENGINE HAD SEIZED AND IT WOULD HAVE TO BE REPLACED (FOR $6000). *NM

DT*: THE CONTACT STATED WHILE DRIVING 45 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE THE DEALER ENCOUNTERED SLUDGE IN THE ENTIRE ENGINE. THE DEALER DETERMINED THE SLUDGE WAS FROM POOR MAINTENANCE. THE CONTACT STATED THE VEHICLE WAS REGULARLY MAINTAINED BY SERVICE DEALERS. UPDATED 9/22/2006 - *NM