2004 Toyota RAV4 Power Train

The transmission slips suddenly, even during highway driving conditions, which almost resulted in a terrible crash. I found out that the electronic control module for these vehicles is defective and must be repaired to correct the transmission issues.

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. WHILE DRIVING AT ANY SPEED AND WHEN THE GEAR SHIFTER WAS PLACED INTO THE DRIVE POSITION, THE VEHICLE HESITATED AND ALL OF THE INSTRUMENT PANEL INDICATORS ILLUMINATED, ALONG WITH "TAKE THE VEHICLE FOR SERVICE" MESSAGE APPEARED. THE VEHICLE WAS DRIVEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE TRANSMISSION WAS REPLACED, BUT THE FAILURE RECURRED. THE DEALER DIAGNOSED THAT THE COMPUTER WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

THE POWER OF THE CAR IS IN TROUBLE AT START, JUMPS LIKE IS LOCKED, OR LOSE POWER, THAN, WHEN I GIVE GAS IS RUNNING OK IN THE STREET OR IGHWAY, TILL STOP AND RENEW RUNNING THE CAR.EVERY TIME THAT I STOP IS THE PROBLEM. THE PROFETIONAL MECHANIS LOOK AT IT, AND HE SAY THE TRANSMITION (SELENOID) IS NOT WORKING.

AS MY FAMILY AND I WERE LEAVING MY HOUSE TO GO TO THE COAST, MY 2004 TOYOTA RAV4 SUDDENLY, WITHOUT ANY PRIOR WARNING OR INDICATION, JERKED AND SPUTTERED AND FELT AS IF IT WERE DOWNSHIFTING, AS IF THE TRANSMISSION WERE SLIPPING OR NOT ENGAGING OR MAINTAINING GEAR. UPON TAKING IT TO THE DEALERSHIP, I WAS TOLD THAT THE DIAGNOSTIC REVEALED THAT THE TRANSMISSION HAD TO BE REPLACED. I WAS ALSO INFORMED THAT TOYOTA WOULD NOT ALLOW IT TO BE OPENED UP, ONLY REPLACED. I MENTIONED THE ECM AND WAS TOLD THAT THEY FOUND NOTHING TO INDICATE ANYTHING OTHER THAN THE TRANSMISSION NEEDED TO BE REPLACED. WERE IT NOT A HIGHER POWER CARING FOR ME AND MY LOVED ONES THAT DAY, I BELIEVE IT COULD HAVE BECOME AN EVEN MORE DANGEROUS SITUATION THAN IT ALREADY WAS.

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. AFTER STOPPING, THE VEHICLE JERKED FORWARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,000.

I HAVE A 2004 TOYOTA RAV4. THE CHECK ENGINE LIGHT AND VSC LIGHT CAME ON WHILE DRIVING AT 30 MPH. NOTICED THAT AS I CONTINUED TO DRIVE HOME AT APPROXIMATELY 65 MPH, THE CAR WAS NOT SHIFTING INTO OVERDRIVE AND THE RPM'S WERE VERY HIGH. TOOK IT TO THE DEALER, AND THEY SAID THE CODE SHOWED THAT THE SOLENOID WAS BAD. THE PART WAS REPLACED AT A COST OF $750. THEN TOLD THAT DID NOT CORRECT THE PROBLEM, NEEDED A NEW TRANSMISSION AND ANOTHER $4300. I KNOW THERE WAS A CLASS ACTION LAWSUIT FOR THE 2001-2003 TOYOTA RAV4 TRANSMISSIONS, THINK IT SHOULD HAVE BEEN EXPANDED TO INCLUDE THE 2004 AS THE PROBLEMS SEEM TO BE THE SAME. THIS PROBLEM IS DANGEROUS AND COULD HAVE CAUSED SERIOUS ACCIDENT AND DAMAGE TO MYSELF OR OTHERS. BOUGHT A TOYOTA FOR RELIABILITY AND WHAT I THOUGHT WERE GREAT VEHICLES. VERY SAD WHEN I READ ALL OF THE COMPLAINTS WITH THIS VEHICLE. I KNOW WHAT MY NEXT CAR WILL NOT BE. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA RAV 4. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE SHIFTED FROM FOURTH GEAR TO NEUTRAL INDEPENDENTLY. THE FAILURE RECURRED THE FOLLOWING DAY. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS ADVISED THAT THERE WERE COMPLAINTS ON THE VEHICLE AND PROVIDED NO FURTHER ASSISTANCE. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE TRANSMISSION. THE FAILURE AND THE CURRENT MILEAGE WAS 94,000. UPDATED 8/29/12 *CN

I HAVE A 2004 TOYOTA RAV4. THE CHECK ENGINE LIGHT CAME ON AND AFTER ABOUT 20 MILES THE CAR STARTED SHIFTING HARD AND FINALLY WOULDN'T GET IN GEAR. TOOK IT TO THE DEALER, AND THEY SAID THE ELECTRONIC CONTROL MODULE (ECM) IS AT FAULT (ERROR P0766- SHIFT SOLENOID D STUCK). THEY REPLACED THE ECM BUT THE PROBLEM PERSISTED. THE DEALER TOLD ME THE ONLY WAY TO FIX THE PROBLEM IS TO REPLACE THE TRANSMISSION. I SPOKE TO TOYOTA CORP BUT THEY TOLD ME THE PROBLEM WITH THE SHIFT SOLENOID IS A "WHOLLY" SEPARATE ISSUE. I TOLD THEM ABOUT THE 2001-2003 EXTENSION OF WARRANTY THAT TOYOTA DID THE RAV4 BUT THEY REFUSED TO COVER THE TRANSMISSION REPLACEMENT. THIS PROBLEM IS VERY DANGEROUS BECAUSE THE TRANSMISSION CAN JUST DISENGAGE FROM THE MOTOR AND LEAVE YOU STUCK IN THE MIDDLE OF THE ROAD WHEN YOU PULL OUT OF DRIVEWAY OR ON THE RAMP ENTERING A HIGHWAY. *TR

VEHICLE WAS NOT SHIFTING PROPERLY ON THE HIGHWAY. THE RPMS WERE ABOVE 3000. HAD TO SLOW DOWN TO 50 -55 MILES PER HOUR AND REMAIN IN THE SLOW LANE. REST OF THE TRAFFIC WAS TRAVELING AT 65 MPH.

TL*THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE JERKED VIOLENTLY WHILE THE GEARS WERE CHANGED AND THERE WAS TROUBLE ACCELERATING. THE FAILURE OCCURRED AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION FLUID WAS BLACK; THE FLUID WAS REPLACED. THE FAILURE OCCURRED INTERMITTENTLY. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000 AND THE CURRENT MILEAGE WAS 62,600.

I DROVE MY 2004 (6 1/2 YEAR OLD) RAV4 SPORT AWD TODAY AS USUAL TO WORK (16 MILES). IT HAS JUST SHORT OF 50,000 MILES ON IT AND IS READY FOR THE NEXT OIL CHANGE IN MORE THAN 1000 MILES. I HAVE DONE THE MAJORITY OF MAINTENANCE AT THE DEALERSHIP. I DROVE THE CAR FROM MY OFFICE AT 169 AND 62, ON 62 THEN NORTH ON I35W TO MINNEAPOLIS AND THEN ON I94E TO ST. PAUL. SOON AFTER I GOT ON I94 I NOTICED SUDDEN FAILURE TO ACCELERATE WITH A JERKING AND HIGH REVS (TO ABOUT 4500) WHEN GOING FROM 55 TO 60. THE GEARS DID NOT FULLY ENGAGE AND RUMBLED AND DID NOT CHANGE OR DRIVE FULLY IN ANY GEAR. I WAS CONCERNED ABOUT TRANSMISSION PROBLEMS AND STOPPED AT A SERVICE STATION (MIKE'S BP IN ST. PAUL DOWNTOWN) THAT HAD DONE AN OIL CHANGE ON MY CAR. THE SERVICE PERSON CHECKED MY TRANSMISSION FLUID AND SAID IT WAS "FILTHY" BUT FULL. HE SAID IT MAY NEED A NEW TRANSMISSION. I CHOSE TO CANCEL MY TRIP OUT OF STATE FOR WORK, AND DROVE DIRECTLY HOME AFTER SETTING UP WITH MY REGULAR MECHANIC FOR NEXT TUESDAY, THE EARLIEST OPEN APPOINTMENT. I WAS SURPRISED TO HAVE THIS ISSUE COME UP SO SUDDENLY AND IT IS A CLEAR DANGER SINCE I MOSTLY WOULD DRIVE ON INTERSTATE HIGHWAYS IN RUSH HOUR TRAFFIC OR LONG DISTANCE FOR WORK AND IT COULD CAUSE A CRASH. I WILL NOT DRIVE THE VEHICLE. THIS CAR HAD NO ISSUES AT ALL SO FAR - ONLY REPLACED THE WIPERS A YEAR AGO. I AM CONCERNED TO HAVE FURTHER DAMAGE TO THE TRANSMISSION AS THE CAR DROVE SO UNPREDICTABLY AND MAKES STRANGE NOISES NOW IF IT IS SHIFTING. I HAVE A TOYOTA PURCHASED EXTENDED WARRANTY GOOD UNTIL END OF JUNE 2011 AND I'LL WORK ON GETTING THIS COVERED. IT IS FRIGHTENING TO HAVE THIS HAPPEN TO MY VEHICLE AS I DEPEND ON MY CAR FOR WORK TRIPS AND FOR COMMUTING. I'M GLAD I HAVE THE WARRANTY AND WILL HAVE THE WORK DONE TO FIX THE PROBLEM IF THAT IS POSSIBLE. MY CAR GOES THROUGH REGULAR MAINTENANCE AT A TOYOTA DEALERSHIP AND THEY RUN CHECKS FOR ANY RECALLS EVERY TIME IT IS IN THE SHOP. THERE HAS BEEN NOTHING AT ALL ON THE VEHICLE THUS FAR. *TR

TRANSMISSION ISSUES, NOT SHIFTING PROPERLY ALL THE TIME! DEALER TELLS ME TRANS NEEDS $3000.00 IN REPAIRS! *TR

WAS DRIVING DOWN THE ROAD AND THE TRANSMISSION STARTED MAKING NOISES. IT CRACKED REAL LOUD ONE TIME AND I HAD NO POWER. WHEN I CAME TO A RED LIGHT AND TRIED TO GO AGAIN IT WOULDN'T TAKE OFF. TOOK ME 3 HRS TO DRIVE 55 MILES TO GET MY RAV HOME. CONTACTED A GARAGE THAT SPECIALIZES IN TRANSMISSION. WAS TOLD THEY JUST RECEIVED A NOTICE FROM TOYOTA THAT THE COMPUTER CHIP IN THE TRANSMISSION WAS FAILING BUT THAT I HAD TO MANY MILES TO QUALIFY. THE GARAGE PUT IN A NEW COMPUTER CHIP (RECOMMENDED BY TOYOTA) AND IT DIDN'T COMPLETELY TAKE CARE OF THE PROBLEM SO THEY ENDED UP PUTTING A WHOLE NEW TRANSMISSION IN TO THE PRICE OF $4611. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA RAV 4. THE VEHICLE WOULD ONLY DRIVE NORMALLY WHEN THE ENGINE WAS WARM. WHILE IDLING ON TOP OF A HILL THE VEHICLE WOULD ALSO ROLL BACKWARDS. THE DEALER HAS NOT DIAGNOSED THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

2004 RAV 4 AUTOMATIC TRANSMISSION BEGAN SHIFTING VERY HARD. I HAVE RESEARCHED THE INTERNET AND THERE ARE MANY COMPLAINTS ON THIS SAME ISSUE. TOOK IT TO AAMCO FOR TESTING. IT IS RELATED TO THE COMPUTER MODULE AND CAUSED INTERNAL DAMAGE TO THE TRANSMISSION. *TR

AUTOMATIC TRANSMISSION SHIFT CABLE BROKEN WHILE SELECTING TO PARK, THIS VEHICLE COULD ROLL FORWARD OR BACKWARD UPON RELEASING THE BRAKE. IF IN CASE THE CABLE BROKEN WITHOUT KNOWING WHILE CRUISING I HAVE NO OPTION TO DOWNSHIFT IN CASE OF EMERGENCY ON A DOWNHILL ROAD OR BRAKE SYSTEM FAILURE. I'VE REPLACED THE PART AT A COST OF $196.00 + LABOR. *NM