2007 Toyota RAV4 Engine

BURNING MULTIPLE QUARTS OF OIL OVER SEVERAL THOUSAND MILES OF NORMAL HIGHWAY DRIVING. 1000 MILE DRIVE RESULTS IN BEING 1.5-2 QUARTS LOW.

EXCESSIVE OIL CONSUMPTION

ON JULY 24, 2018; I CONTACTED TEMECULA VALLEY TOYOTA REGARDING MY 2007 TOYOTA RAV 4 WITH 122,00 MILES ON IT. I CONTACTED THEM TO SPEAK REGARDING THE EXCESSIVE USE OF OIL THAT MY VEHICLE WAS RECENTLY USING. I HAVE BEEN DILIGENT ABOUT BRINGING MY CAR IN FOR ALL RECALLS AND HAVE INQUIRED EACH TIME IF THERE WAS ANYTHING THAT SHOULD BE FIXED UNDER WARRANTY OR RECALL THAT NEEDED TO BE ADDRESSED ON MY VEHICLE. BEFORE CONTACTING TOYOTA, I LOOKED ONLINE TO SEE IF ANY OTHER VEHICLES WERE HAVING THIS SAME PROBLEM. I FOUND OUT THAT THERE WAS A LAWSUIT FOR THIS EXACT ISSUE. IT WAS TITLED THE ECONOMIC LOSS CLASS ACTION SETTLEMENT. IT READS THAT TOYOTA RAV 4 WITH THE YEARS 2006-2008 RAV 4 SHOULD BE ENTITLED TO BE REPAIRED IF THEY ARE BROUGHT IN FOR REPAIR WITHIN 10 YEARS OR 150,000 MILES. IT DOES NOT STATE WHICHEVER IS LESS. HOWEVER TOYOTA IS IMPLYING BECAUSE MY CAR IS OVER 10 YEARS OLD THAT THIS IS NOT THEIR RESPONSIBILITY. AS STATES PREVIOUSLY, MY VEHICLE HAS 122,000 MILES ON IT. IT IS UNDER THE AMOUNT REQUIRED FOR THE LAWSUIT. IN ADDITION I HAVE BROUGHT THE VEHICLE IN BEFORE THE 10 YEAR WARRANTY EXPIRED AND IT WAS NEVER MENTIONED TO ME THAT THIS COULD BE COVERED AT THE TIME OF REPAIR FOR OTHER RECALLS. I WAS BRINGING THIS VEHICLE IN TO BE REPAIRED PRIOR TO A FAMILY EMERGENCY THAT I WOULD HAVE TO USE MY VEHICLE TO DRIVE THROUGH SEVERAL STATES. THE VEHICLE HAD AN OIL CHANGE BEFORE I LEFT. MY VEHICLE USED UP ALL OF THE OIL BEFORE I MADE IT HALF WAY. THE PRESSURE IN THE ENGINE WAS SO HOT THAT IT BLEW THE OIL CAP OFF AND NEARLY BLEW UP MY ENGINE AND THE OIL LIGHT NEVER CAME ON. THIS OCCURRED WITHIN APPROXIMATELY 1,000 MILES BEING DRIVEN. I WAS TRAVELING ON THE I70 WEST TOWARDS KANSAS. THERE ARE FEW PLACES TO TURN OFF, NEAR VAIL, COLORADO. IT ENDANGERED MY LIFE AND THE LIFE OF OTHERS DURING THE TIME THAT I WAS STOPPED ON A FREEWAY ON A MOUNTAIN.

THE MOTOR MOUNT ARE BROKE FROM CORROSION. AND MY MUFFLER WAS REPLACED FOR THE SAME THIS...

ENGINE OIL CONSUMPTION ON THIS VEHICLE IS UNACCEPTED, TOYOTA KNEW THIS PROBLEMS AND SHOULD MAKE A RECALL YEARS AGO ABOUT THIS ISSUE

MY TOYOTA RAV4 (2007) STARTED SHOWING SIGNS OF EXCESSIVE OIL COMBUSTION. I STARTED HAVING OIL CHANGES EVERY 2-3K MILES. 1200 MILES AFTER MY LAST OIL CHANGE THE ENGINE SEIZED DUE TO A LACK OF OIL. THE VEHICLE WAS STATIONARY AT A CONVENIENCE STORE WHEN IT DIED. I'VE SINCE LEARNED THAT THE ISSUE IS KNOWN AND THEIR IS A TSB THAT WAS ISSUED TO DEALERSHIPS.

WE WERE DRIVING ON THE AUTOBAHN IN GERMANY (MIL FAMILY) WHEN THE ENGINE STALLED WITHOUT ANY WARNING. OUR OIL LEVEL WAS FINE THE DAY BEFORE WE STALLED. WE CHECK OUR OIL EVERY WEEKEND SINCE OUR RAV4 HAS A VERY HIGH OIL CONSUMPTION RATE. OUR EGGINE SEIZED WHILE WE WERE GOING ABOUT 90 MPH WITH OTHER CARS AROUND US GOING EVEN FASTER. WE ARE LUCKY TO HAVE NOT CAUSED AN FATAL ACCIDENT. WE WOULD LIKE SOMETHING DONE ABOUT THIS.

MY RAV4 TRUCK WAS TAKEN TO THE DEALERSHIP FOR SERVICE AS OIL LIGHT CAME ON, HOWEVER, TRUCK WAS NOT DUE FOR AN OIL CHANGE AS SERVICE WAS DONE MAY 2018. TECHNICIAN INFORMED ME THAT THE TRUCK WAS BURNING OIL AND REQUIRED THE REPLACEMENT OF PISTONS INSIDE ENGINE. AT THAT TIME, I WAS INFORMED THAT UNDER THE EXCESSIVE ENGINE OIL CONSUMPTION WARRANTY, IT WOULD BE COVERED AT NO CHARGE TO CUSTOMERS. UNFORTUNATELY, THE WARRANTY IS EXPIRED FOR MY TRUCK AND NOTHING CAN BE DONE BY TOYOTA. HOWEVER, REGULAR MAINTENANCE ON THE TRUCK NEVER INDICATED A PROBLEM AND NO MENTION OF THIS ISSUE WAS EVER ADDRESSED BY THE TECHNICIANS. A YEAR AGO THE TRUCK WOULD HAVE BEEN COVERED AND NOW MY SAFETY AND THE SAFETY OF OTHERS IS BEING COMPROMISED. OF COURSE, ENGINE FAILURE DID NOT OCCUR UNTIL AFTER THE WARRANTY PERIOD EVEN THOUGH REGULAR OIL CHANGES WERE BEING DONE. JUST BECAUSE THE WARRANTY IS EXPIRED DOESN'T MEAN THE ISSUE DOESN'T EXIST! WHY IS A COMPANY ALLOWED TO PUT LIVES IN DANGER? TOYOTA IS QUICK TO ADDRESS A RECALL ISSUE YET DOESN'T SEEM TO THINK THIS IS SUCH AN ISSUE. IN NO TIME, YOU COULD BE OUT OF A CAR/TRUCK WITHOUT YOU EVEN KNOWING WHY ESPECIALLY WHEN SERVICES ARE BEING DONE IN A TIMELY MANNER. HOW IS IT THAT DEALER SERVICE CENTERS KNOW WHEN YOU HAVEN'T DONE A RECALL ON YOUR CAR YET DON'T ADDRESS/ADVISE AN ISSUE THAT POTENTIALLY BE A PROBLEM IF NOT TAKEN CARE OF IN THE LONG RUN. I GUESS THE CUSTOMERS SAFETY IS NOT A PRIORITY.

MY CAR BURNS MASSIVE AMOUNTS OF OIL. I GET REGULAR CHANGES AT GOODYEAR. I TOOK IT IN TO TOYOTA WOLFCHASE MEMPHIS FOR NOT 1 BUT 2 RECALLS AND ASKED ABOUT THE AMOUNT OF OIL IT WAS BURNING. THEY INFORMED ME THIS VEHICLE PER VIN# HAD A WARRANTY ENHANCEMENT ON IT B/C PISTON DOES NOT SIT PROPERLY AND THAT IS WHY THE LARGE CONSUMPTION OF OIL. THEY ALSO INFORMED ME I WAS "TOO LATE" THAT IT EXPIRED 5/6 MONTHS PRIOR. I MADE THEM AWARE I WAS NOT NOTIFIED OF ANY WARRANTY ENHANCEMENT AND THEY SAID THEIR HANDS WERE TIED. NOTHING THEY, TOYOTA SERVICE DEPT. COULD DO. I CALLED TOYOTA AND A REP SAID IT WAS NOT THE LAW TO LEGALLY NOTIFY ME OF THE WARRANTY ENHANCEMENT SINCE I WAS NOT ORIGINAL OWNER. AFTER MUCH DISAGREEMENT I ASKED FOR A SUPERVISOR WHO CALLED ME BACK AND INFORMED ME LEGALLY THERE WAS NOTHING I COULD DO AND THEY COULD NOT HELP ME WITH THE BILL IF I GOT THIS PISTON FIXED. I ASKED HER IF THE ORIGINAL OWNER WAS NOTIFIED BC I COULD NOT IMAGINE NOT GETTING IT FIXED. I SAID THIS ONE MODEL HAS SO MANY RECALLS! IT IS A LEMON. THEN AGAIN SHE EXPLAINED THEY COULD DO NOTHING. SHE NEVER STATED IF THE ORIGINAL OWNER WAS NOTIFIED. (THIS WAS ONE OWNER CAR) I AM NOW USING ABOUT 7 QTS OF OIL PER 5K MILES. YEAP 7 QUARTS. I BEGAN BUYING IN 5 GALLONS AND WRITING MILEAGE ON THE BOTTLE BEFORE I ADD ANY. (IT WAS 3 PER 5K AND HAS INCREASED TO THE LATEST HIGH OF 7 IN THE 2 YRS. SINCE I PURCHASED. I AM AN OLDER DRIVER AND BABY THIS VEHICLE. AT THE DATE I FOUND OUT ABOUT THE PISTON UNDER WARRANTY ENHANCEMENT I WAS IN FOR 2 RECALLS!!! SEAT BELT AND REAR SUSPENSION! TOYOTA SAID IF I HAD MY OIL CHANGED THERE, I WOULD HAVE BEEN NOTIFIED OF WARRANTY ENHANCEMENT?? BUT I WAS TOO LATE. THIS WAS 12/6/17

IN DEC 2014 MY CAR EXHAUST WAS LOUDER THAN USUAL, THE REPAIR SHOP NOTED THAT THE FRONT CENTER CATALYTIC CONVERTER WAS RUSTED AND PERFORATED AND REPLACE IT AT AT COST OF $1844.11. IN JAN 2017 TOYOTA ISSUED SPECIAL SERVICE CAMPAIGN G0Y REGARDING THIS EXACT ISSUE, CLAIMING IT WILL EITHER FIX RUSTED SYSTEMS OR REIMBURSE THOSE WHOSE SYSTEMS WERE ALREADY RUSTED AND REPLACED. I SUBMITTED MY REQUEST FOR REIMBURSEMENT, RESPONDED FOR A REQUEST FOR MORE PAPERWORK, AND WAS SUBSEQUENTLY DENIED WITHOUT EXPLANATION. TODAY WHEN I CALLED FOR MORE INFO, I WAS TOLD THAT THE DECISION CANNOT BE APPEALED (NFI). SHE FINALLY SAID THAT THE REPAIR SHOP NOTE DID NOT MENTION RUST. WHEN I POINTED OUT IT SAID HOLES, SHE WAS UNMOVED AND SAID THEIR DECISION IS FINAL. THIS IS DISHONEST AND RIPPING OFF CUSTOMERS. I WOULD APPRECIATE YOUR ASSISTANCE IN THIS MATTER. I BELIEVE I FULLY MEET THE REQUIREMENTS AS SPELLED OUT IN THEIR SERVICE CAMPAIGN NOTICE. I CAN PROVIDE ADDITIONAL PAPERWORK AS NEEDED

AT 94K MILES MY CAR STARTED BURNING ALOT OF OIL, AND I AM TOLD BY TOYOTA THAT THIS IS NORMAL?? EVERY 1200 MILES I AM ADDING AT LEAST 1 1/4 QT. THIS IS NOT NORMAL AND THEY KNOW THERE IS AN ENGINE ISSUE- BUT REFUSE TO TAKE RESPONSIBILITY FOR IT!

EXCESSIVE OIL CONSUMPTION RELATING TO TOYOTA'S WARRANTY ENHANCEMENT NOTIFICATION - ZE7. I KNEW MY ENGINE CONSUMED OIL CHRONICALLY SINCE AT LEAST 75,000 MILES SO WAS NOT SURPRISED WHEN THIS WARRANTY ENHANCEMENT CAME IN THE MAIL. HOWEVER, WHEN I BROUGHT IT INTO THE DEALERSHIP TO GET TESTED, THEY SAID IT PASSED THE TEST (THIS WAS IN APRIL 2015 AT ABOUT 135,000 MILES). I WAS FRUSTRATED AND SHOCKED. I THOUGHT I WAS STUCK WITH NO OTHER OPTIONS. RECENTLY, WHEN ADDING OIL I NOTICED I WENT THROUGH 2-2.5 QUARTS IN A WEEK. THAT'S WHEN I INSISTED ON ANOTHER OIL CONSUMPTION TEST. IT FAILED THIS TIME, BUT ACCORDING TO TOYOTA, IT WAS TOO LATE FOR THEM TO COVER AS I WAS OVER THE TERM OF 150,000 MILES (CASE #1803133073). I ASKED FOR OTHER ALTERNATIVES SINCE I BELIEVED THE ORIGINAL TEST TO BE FLAWED (ALLOWING FOR 1-1.5 QUARTS OF OIL CONSUMPTION WHEN THE OWNER'S MANUAL RECOMMENDS OIL CHANGES AT 5,000 MILES. SINCE THE CAR ONLY HOLDS JUST OVER 4.5 QUARTS OF OIL, NO OIL WOULD BE LEFT AT OVER 4,000 MILES). AT THE RATE OF CONSUMPTION, I WORRY ABOUT EXCESSIVE ENGINE HEAT LEADING TO FIRES AND OBVIOUSLY EXCESSIVE WEAR ON THE ENGINE. THIS SHOULD NOT HAVE BEEN A 'WARRANTY ENHANCEMENT' AND INSTEAD A RECALL AS THE EXCESSIVE OIL CONSUMPTION IN THE 2AZ-FE TOYOTA ENGINE IS WELL DOCUMENTED AS A DESIGN FLAW OR ENGINEERING ERROR WITH THE PISTON RINGS NOT BEING LARGE ENOUGH TO DRAIN OIL OR NOT HAVING ENOUGH HOLES, TRAPPING THE OIL AND CAUSING OIL BURNING. TOYOTA SHOULD BE HELD ACCOUNTABLE FOR THEIR POOR ENGINE DESIGN AND ANY SAFETY ISSUES ASSOCIATED WITH IT. AT A MINIMUM THE WARRANTY ENHANCEMENT SHOULD BE EXTENDED FOR THE LIFE OF THE VEHICLE.

OIL BURN , EXXCESIVE

OUR 2007 RAV4 IS CONSUMING/BURNING OIL AT AN EXTREME RATE. THERE IS NO OIL LEAKING FROM THE VEHICLE. WE ARE ADDING A QUART EVERY 2-3 WEEKS. WE HAD THE DEALERSHIP PERFORM THEIR "TEST" (THREE TIMES) WHEN THE RECALL CAME OUT OVER A YEAR AGO. AT THAT TIME WE WERE TOLD OUR VEHICLE DID NOT MEET THE CRITERIA TO BE COVERED UNDER THE RECALL. (RECORDS WILL SHOW THAT PRIOR TO THE RECALL EVEN COMING OUT, WE HAD TAKEN IT IN FOR EXCESSIVE OIL CONSUMPTION...SO WHEN THE RECALL CAME OUT WE HOPED IT WOULD TAKE CARE OF THE PROBLEM.) WE WERE SHOCKED WHEN WE WERE TOLD IT DIDN'T "QUALIFY". WE HAVE JUST CONTINUED ADDING OIL...THEN IN AUGUST OF 2017 WE SPENT NEARLY $2,800 TO HAVE REPAIRS DONE THAT WE HOPED WOULD TAKE CARE OF THE PROBLEM. TO OUR SURPRISE, THE OIL HAS BEEN DEPLETING AT AN EVEN FASTER RATE THAN BEFORE! SO WE TOOK IT BACK IN TO THE DEALERSHIP WHO PERFORMED THE OIL CONSUMPTION TEST DONE UNDER THE PRIOR RECALL, AND WERE TOLD IT FAILED MISERABLY THEN! WE UNDERSTAND THE RECALL PERIOD HAD EXPIRED, BUT THE VEHICLE STILL HAD UNDER 200,000 MILES ON IT WHEN IT FAILED. HOW DOES A VEHICLE GET RECALLED ONLY FOR A CERTAIN WINDOW OF TIME, WHEN WE WERE TOLD IT DOESN'T MEET THE CRITERIA - AND AFTER THAT WINDOW IS "CLOSED" THE VEHICLE FAILS THE TEST? WE ARE APPEALING TOYOTA'S DECISION NOT TO COVER THIS PROBLEM UNDER THE RECALL. WE HAVE BEEN LOYAL TOYOTA CUSTOMERS FOR DECADES AND REQUEST YOUR CONSIDERATION IN THIS MATTER.

TAKATA RECALL I HAVE OWNED THIS CAR FOR ALMOST TWO YEARS NOW AND EVER SINCE I HAVE OWNED THE CAR THE CAR HAS HAD A OIL CONSUMPTION ISSUE . MEANING I DRIVE 40 MILES A DAY MONDAY THROUGH FRIDAY AND AT THE END OF THE WEEK I NEED TO ADD OIL TO IT. AFTER 200 MILES A CAR SHOULD NOT NEED OIL . I HAVE HAD MULTIPLE PEOPLE LOOK AT THE CAR AND IT DOESN'T HAVE A LEAK THE CAR IS CONSUMING THE OIL. I BELONG TO MANY TOYOTA CAR FORUMS ONLINE AND MANY OTHER CARS MY YEAR MODEL ARE HAVING THE SAME ISSUE . THIS IS SOMETHING THAT NEEDS TO BE

EXCESSIVE OIL CONSUMPTION, I AM ADDING 1 QUART OF OIL EVERY 10 - 13 DAYS ABOUT 300 - 400 MILE IN BETWEEN I WENT FOR THE OIL CONSUMPTION TEST 2 TIMES THE DEALERSHIP TOLD ME IT PASSED THE TEST BUT STILL THE ENGINE IS CONSUMING A LOT OF OIL

OIL CONSUMPTION, USES A LOT OF OIL AND HAVE KEEP CHECKING AND ADDING FREQENTLY

DRIVING ON EXPRESSWAY THE LOW OIL LIGHT CAME ON DOZENS OF TIMES WHILE BRAKING.. TOYOTA RAV4 2007 WITH ONLY 69K MILES STARTED TO CONSUME 1 QUART OF OIL EVERY 1000 MILES... DEALER DID AN OIL CONSUMPTION TEST - WHICH PROVED THAT ENGINE IS BURNING OIL. SINCE CAR IS MORE THEN 10 YEARS, EVEN THOUGH THE MILEAGE IS VERY LOW - TOYOTA REFUSES TO COVER REPAIR COSTS. DEALER'S QUOTE FOR REPAIR WAS $4,300.

EXCESSIVE OIL CONSUMPTION MAY LEAD TO ENGINE FAILURE

EXCESSIVE OIL CONSUMPTION CAUSED ENGINE TO LEAK OIL

EXCESSIVE OIL CONSUMPTION - USES 1 QUART OF OIL EVERY 1,500 MILES OR LESS. WE HAVE TO CONSTANTLY CHECK THE OIL LEVEL AND MY WIFE IS NOW AFRAID TO DRIVE THE VEHICLE FEARING THAT THE ENGINE WILL SEIZE UP IF WE HAVE FAILED TO CHECK THE OIL LEVEL. NOTE: I'VE HAD TO "DUMMY" A DATE BECAUSE THIS IS A CONTINUOUS PROBLEM AND NOT JUST ONE DATE.

ONGOING EXCESSIVE OIL CONSUMPTION. USING APPROXIMATELY 1 QUART FOR EVERY 1200 MILES

EXCESSIVE ENGINE OIL CONSUMPTION. DID OIL CONSUMPTION TEST AT TOYOTA AND THEY SAID THERE'S NO PROBLEM BUT STILL OIL RUNS DRY AFTER 3K MILES. TOOK IT TO ANOTHER NON TOYOTA SERVICE CENTER FOR SECOND OPINION AND WAS TOLD THAT I HAD TWO OPTIONS: TO REPLACE THE ENTIRE ENGINE AT A COST OF $5K OR TO LIVE WITH IT AND CHECK OIL LEVEL WEEKLY AND REFILL IT YOURSELF IF OIL LEVEL IS LOW. ALSO RECOMMENDED USING 10W40 OIL DUE TO HIGH MILEAGE. I CHOSE THE LATTER AND SO FAR GOING GOOD. REALLY NOT HAPPY WITH TOYOTA DEALERS RESPONSE AS THEY WERE HESITANT TO HELP AND KEPT TELLING ME TO CHANGE THE ENTIRE ENGINE THAT WOULD COST ME $$$ SINCE MY WARRANTY EXPIRED.

MY CAR HAS FAILED INSPECTION BECAUSE OF LEAKS IN THE MUFFLERS. LIVING IN A COLD WEATHER CLIMATE, THE ROADS ARE SALTED CONSTANTLY AND MY MUFFLER SHOULD NOT HAVE RUSTED AND HAVE HOLES IN. THE MATERIAL IS NOT SUFFICIENT ENOUGH FOR HEAVY SALTING. I BELIEVE THE V6 ENGINES HAVE THIS RECALL BUT NOT 4 CYLINDER.

EXCESSIVE OIL CONSUMPTION THIS IS MY SECOND COMPLAINT ON THIS ISSUE BECAUSE AFTER FINALLY FINDING A BETTER DEALER (TOWNE TOYOTA, LEDGEWOOD NJ BAD, TOYOTA OF MORRISTOWN GOOD) I HAD THE OIL CONSUMPTION TEST PERFORMED. I FAILED (DUH, BEEN ADDING EXTRA OIL BETWEEN CHANGES FOR TWO YEARS WITH NO LEAKS ON THE DRIVEWAY). I WAS A MONTH OUT OF "EXTENDED COVERAGE" FOR VEHICLES 10 YEARS FROM DATE OF FIRST USE. FRIENDLY DEALER SAID TO CALL HQ AND PLEAD MY CASE. I DID AND AFTER SOME FRIENDLY CUST SERV REP, WAS STILL TOLD SOL. I HOPE SOMEONE GETS A CLASS ACTION GOING. I WILL BE GETTING THIS REPAIRED BY MY LOCAL MECHANIC AND WILL NEVER BUY TOYOTA AGAIN. (EVEN MY BRZ SICKENS ME A BIT SINCE TOYOTA HAD A HAND IN IT).