2006 Toyota Sienna STRUCTURE,LATCHES/LOCKS/LINKAGES

I HAVE A 2006 TOYOTA SIENNA THAT I BOUGHT IN 2009. I HAD TO TURN OFF MY ELECTRICAL RIGHT BACK SIDE PASSENGER DOOR BECAUSE IT SLIDES OPEN BY ITSELF WHILE I'M DRIVING. THE DOOR OPENS AND CLOSES WITH THE PUSH BUTTON BUT DUE TO THE DOOR FLYING OPEN WHILE I'M DRIVING I HAD TO TURN THE AUTOMATIC OPTION OFF. I TAKE MY VEHICLE IN FOR ALL RECALLS BUT I'M NOT SURE IF THIS HAS BEEN ONE OF THEM AND IF IT HASN'T IT SHOULD BE. IT JUST HAPPENS OUT OF NOWHERE AND YOU NEVER KNOW WHEN IT'S GOING TO HAPPEN YOU JUST SEE THE DOOR FLY OPEN IN TRAFFIC. I HAVE KIDS AND A DOG THAT RIDES IN MY VAN ON A DAILY BASIS SO THIS PROBLEM NEEDS ATTENTION.

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE'S REAR DOOR WAS NOT LOCKING AND THE DOOR AJAR WARNING INDICATOR ILLUMINATED. ONCE THE DOOR WAS AJAR, IT DID NOT LOCK AND TOOK SEVERAL ATTEMPTS. THE CONTACT WAS CONCERNED THAT THE DOORS WOULD OPEN WHILE DRIVING. THE DEALER REPAIRED THE VEHICLE TWICE, BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 45,000. UPDATED 01/26/2017*CT CONSUMER STATED BOTH DOORS HAD THE ISSUE OF NOT LOCKING MULTIPLE TIMES. ALL AUTOMATIC DOOR FEATURES HAVE HAD TO BE DISENGAGED AND THE RIGHT REAR (PASSENGER) DOOR WILL NOT ENGAGE THE LOCK. UPDATED 7/10/18*JB

NHTSA ACTION NUMBER : EA06020 THE REPLACEMENT STRUT FOR THE REAR LIFT GATE UNDER THE RECALL NHTSA ACTION NUMBER : EA06020 ARE FAILING AGAIN. THEY WERE ALREADY REPLACE ONCE UNDER THE RECALL. IF IT'S A NORMAL WEAR ITEM THEN SHOULD BE LISTED UNDER MAINTENANCE. *TR

PASSENGER SIDE SLIDING DOOR FAILED TO LOCK. THE "DOOR OPEN" LIGHT ON THE DASHBOARD REMAINED LIT. THIS IS A POTENTIAL SAFETY ISSUE SINCE THE DOOR COULD OPEN WHILE DRIVING. I TOOK IT TO TOYOTA DEALERSHIP SERVICE DEPARTMENT WHICH IDENTIFIED FAULTY REAR LATCH AND GAVE ME AN ESTIMATE OF REPAIR COST OF $526. THIS IS AN EXPENSIVE REPAIR COST WHICH THE CONSUMER SHOULD NOT HAVE TO PAY SINCE THE FAULTY LATCH MECHANISM IS NOT A RESULT OF USAGE OF THE VEHICLE, RATHER IT IS PROBABLY DUE TO A FAULTY DESIGN. TOYOTA SHOULD HAVE ISSUED A RECALL OF THIS FAULTY LATCH MECHANISM. *TR

2006 TOYOTA SIENNA AUTOMATIC SLIDING DOOR ON PASSENGER SIDE WILL NOT OPEN AND CLOSE WHEN USING REMOTE, OR CONSOLE BUTTONS. THIS STARTING OCCURRING AUGUST 1, 2011. *TR

SLIDING DOOR WON'T CLOSE ON TOYOTA SIENNA MINIVAN. THE DEALER CLAIMS THAT THIS IS NOT COVERED UNDER THE PLATINUM EXTENDED WARRANTY, BUT ALSO STATES THAT IF IT IS NOT FIXED, "THE DOOR WILL EVENTUALLY FALL OFF." *TT

OUR 2006 TOYOTA SIENNA VAN HAS ONE OF THE AUTOMATIC SIDE DOORS THAT OPENS BACK UP ON ITS OWN BECAUSE IT DOES NOT CLOSE PROPERLY. THIS HAS BEEN A PROBLEM SINCE THE CAR WAS FAIRLY NEW WITH A LITTLE OVER 36,000 MILES. TOYOTA DOES NOT CONSIDER A DOOR THAT OPENS ON ITS OWN A SAFETY ISSUE, THEREFORE THEY WOULD NOT FIX THE PROBLEM WITHOUT CHARGE. I CONSIDER THIS DANGEROUS BECAUSE A DOOR THAT CONTINUES TO OPEN ON ITS OWN IS CLEARLY NOT SAFE. *TR

MY DRIVERS SIDE POWER SLIDING PASSENGER DOOR CABLE JAMMED WITHOUT WARNING WHILE OUT WITH MY FAMILY. I HAD 2 SMALL CHILDREN IN THE BACK SEAT. I WAS UNABLE TO CLOSE THE DOOR, EVEN AFTER TURNING OFF THE POWER SWITCH TRYING TO USE IT "MANUALLY". HAD TO CALL A FRIEND TO TAKE US HOME, AS I COULD NOT DRIVE THE VEHICLE WITH THE DOOR OPEN. MY HUSBAND WAS ABLE TO PULL ON THE DOOR HARD ENOUGH TO SNAP THE STRIPPED CABLE, AND THE DOOR WILL NOW FUNCTION MANUALLY. UPON INSPECTION, IT APPEARS THAT THE PROTECTIVE COATING ON THE CABLE WORE OFF, EXPOSING THE BARE WIRE WHICH STARTED TO UNCOIL...THUS CAUSING THE DOOR TO JAM. I HAVE BEEN TOLD THE REPAIR WILL COST ME $1800.00. THIS IS UNACCEPTABLE, AND I AM INSISTING ON A RECALL FOR THE POWER DOOR CABLES. *TR

THE DOOR STOP WELD BROKE AFTER WARRANTY EXPIRED. THIS IS A COMMON TOYOTA PROBLEM AND NEEDS A RECALL. THE REPAIR IS VERY EXPENSIVE AND TOYOTA REFUSES TO CONTACT CUSTOMERS ABOUT THIS ISSUE. *KB

THE 2006 TOYOTA SIENNA PASSENGER POWER SLIDING DOOR DOES NOT HAVE A MANUAL OVERRIDE. WHEN THE POWER SIDING DOOR MECHANISM FAILS THE PASSENGER(S) IS (ARE) TRAPPED IN THE VEHICLE OR ARE FORCED TO EXIT INTO TRAFFIC OR CLIMB TO THE FRONT TO EXIT THE VEHICLE. ALTHOUGH THIS INCIDENT DID NOT RESULT IN AN ACCIDENT OR INJURE, IT DOES CREATE A SAFETY ISSUE, ESPECIALLY IF CHILDREN ARE IN THE VEHICLE. *TR

THE PASSENGER SIDE SLIDING DOOR ON MY 2006 TOYOTA SIENNA WILL NOT OPEN, EITHER MANUALLY OR ANY OTHER WAY. *TR

DOOR VERY HARD TO OPEN AND CLOSE. PLASTIC SHEETING COMES OFF THE CABLE MAKING IT NON FUNCTIONAL. BAD DESIGN IF YOU ASK ME. $1800 TO REPLACE THE MOTOR WHICH IS OUTRAGEOUS. $1100 FOR THE MOTOR, WHICH AGAIN SHOULD NOT COST AS MUCH. HIGHWAY ROBBERY. I CAN UNDERSTAND IF IT COUPLE HUNDRED FOR THE MOTOR. THIS NEEDS TO GO ON A RECALL. TOO MANY SIENNA OWNERS HAVE SIMILAR PROBLEM. JUST GOOGLE AND YOU WILL FIND ALL THE FORUMS. MY FIRST AND LAST TOYOTA....... *TR

OUR AUTOMATIC SLIDING DOOR IS NOT WORKING AT 55,000 MILES. THE TOYOTA COMPANY REFUSES TO PAY TO FIX THE SLIDING DOOR. I AM SURPRISE WITH TOYOTA'S REPUTATION THAT THE AUTOMATIC SLIDING DOOR HAS STOP WORKING. I AM VERY CONCERNED ABOUT THE AUTOMATIC DOOR NOT WORKING. RIGHT NOW THE DOOR IS ON MANUAL. IT IS VERY DIFFICULT TO OPEN AND CLOSE FOR MY FAMILY. MY SPOUSE AND MY HANDS HURT WHEN WE PULL TO OPEN AND CLOSE THE SLIDING DOOR. OUR THREE KIDS ARE UNABLE TO OPEN AND CLOSE THE DOOR ON THEIR OWN. I AM VERY CONCERNED BECAUSE GOD FOR BID IF WE WERE TO GET INTO AN ACCIDENT MY KIDS MAY NOT BE ABLE TO GET OUT. *TR

2006 TOYOTA SIENNA MINIVAN. BOTH SIDE SLIDING DOORS FAIL TO CLOSE PROPERLY. UNABLE TO MANUALLY CLOSE. DOOR WILL SLIDE OPEN. REPAIRED DRIVER SIDE SLIDING DOOR IN 2008. NOW IN JULY 2010, PASSENGER SIDE SLIDING DOOR DID NOT CLOSE BUT HAD BEEN REPAIRED BUT NOW AGAIN IN DECEMBER 2010 DOOR CONTINUES TO NOT CLOSE PROPERLY. *TR

WHILE STARTING FORWARD AFTER LOADING GRANDSON IN DRIVER SIDE SECOND ROW OF SEATS DRIVERS SIDE SLIDING DOOR OPENED HALF WAY(DOORS ARE ELECTRICALLY OPERATED). I STOPPED AND ATTEMPTED TO CLOSE DOOR AUTOMATICALLY. DOOR WOULD NOT CLOSE BUT REMAINED HALF OPEN. TRIED MANUAL OPERATION TO NO AVAIL. CALLED TOW TRUCK. TOW TRUCK OPERATOR EXAMINED DOOR AND SAID THAT THE CABLE THAT OPERATES DOOR WAS JAMMED AND THE ONLY WAY TO CLOSE DOOR WAS TO CUT CABLE. AFTER CUTTING CABLE DOOR CLOSED MANUALLY. DROVE HOME. IF DOOR HAD OPENED AT SPEED ON HIGHWAY IT WOULD HAVE CAUSED GREAT DANGER AS MY GRANDSON WAS SITTING NEXT TO DOOR. CALLED CUSTOMER SERVICE AT TOYOTA TO COMPLAIN. WAS GIVEN NO EXPLANATION. *TR

2006 TOYOTA SIENNA PASSENGER POWER SLIDING DOOR WILL NOT WORK. DRIVERS SIDE MANUAL SLIDING DOOR WORKS INTERMITTENTLY. *TR

MY 2006 TOYOTA SIENNA RIGHT REAR POWER SLIDING DOOR WOULD NOT CLOSE. IT ROLLED ALMOST SHUT, THEN OPENED AGAIN. THE CABLE THAT PULLS THE DOOR SHUT WAS LOOSE ALONG THE TRACK AND I NOTICED IT SEEMED TO BE FRAYED. I HAD MY 3 CHILDREN IN THE CAR AND IT WAS RAINING. I HAD TO FORCEFULLY PULL THE DOOR CLOSED AND STILL COULD NOT GET IT CLOSED BECAUSE THE CABLE WAS KEEPING IT FROM CLOSING. I WAS FORCED TO GET PLIERS AND CUT THE CABLE SO I COULD KEEP MY CHILDREN SAFE AND DRIVE BACK HOME WITH THE DOOR CLOSED. THE CAR HAS JUST OVER 60,000 MILES ON IT. NOW I HAVE REMOVED THE CABLE AND USE THE DOOR AS A MANUAL DOOR BECAUSE THE COST TO REPLACE IT IS TOO HIGH. THIS IS UNACCEPTABLE. *TR

POWER SLIDING DOOR ON PASSENGER SIDE DOES NOT ALWAYS LATCH. IT APPEARS THAT THE MOTOR IS TOO WEAK TO MAKE THE DOOR LATCH FULLY. THIS DOES NOT HAPPEN ALL THE TIME, AND IT SEEMS TO BE RANDOM. HAVE NOTICED THAT THE DOOR SEEMS TO MOVE MORE SLOWLY WHEN IT HAS THE LATCHING PROBLEM. *TR

I OWN A 2006 TOYOTA SIENNA VAN AND THE PASSENGER SIDE SLIDING DOOR IS NOT WORKING CORRECTLY. THE SLIDING AUTOMATIC DOOR DOES NOT CLOSE COMPLETELY ON A CONSISTENT BASIS. IT REQUIRES ASSISTANCE TO CLOSE AND WHEN SHUT, IT DOESN'T SEEM TO BE FULLY/SAFELY LATCHED. WE CAN HEAR MORE ROAD NOISE NOW THAT BEFORE. WE CONTRACTED THE LOCAL TOYOTA DEALERSHIP WHERE WE PURCHASED THE VAN AND THEY KNEW RIGHT AWAY THAT THE DOOR MOTOR WAS STARTING TO FAIL AND WE WERE TOLD IT COULD NOT BE FIXED WITHOUT REPLACEMENT. WE WERE QUOTED $1800 TO REPAIR WITHOUT ANYONE EVEN WANTING TO LOOK AT THE PROBLEM. THEY INDICATED THAT THIS IS A PRETTY COMMON PROBLEM WITH THESE VANS. AFTER REVIEWING SOME WEB POSTINGS ON THIS PROBLEM, I AM IN THE SAME BOAT AS A LARGE AMOUNT OF CONSUMERS THAT HAVE PURCHASED THIS MAKE/MODEL/YEAR OF VAN. SAFETY IS OF UTMOST CONCERN TO ENSURE MY CHILDREN ARE SAFELY RIDING IN THE PASSENGER AREA OF MY VAN. I AM CONCERNED THAT THIS DOOR CLOSING PROBLEM COULD LEAD TO AN ACCIDENT. TOYOTA IS REFUSING TO PAY FOR THE NECESSARY REPAIRS AND I FEEL THAT THEY SHOULD STAND BEHIND THEIR PRODUCT BETTER. *TR

SIDE SLIDING DOOR CABLE/MOTOR BROKE. THERE IS NO WAY TO MANUALLY CLOSE DOOR WHEN THIS HAPPENS. I HAD TO DRIVE A CONSIDERABLE DISTANCE WITH 3 LITTLE KIDS IN THE CAR AND THE SIDE DOOR OPEN. TOYOTA HAS TO REPLACE THE CABLE AND MOTOR ASSEMBLY AND WILL CHARGE $1800 TO DO THAT. *TR

2006 TOYOTA SIENNA TWO POTENTIAL SAFETY FAILURES: (1) THE DRIVERS SIDE SLIDING DOOR WHEN OPENING WILL SLIDE INTO THE GAS FUEL DOOR WHILE ANOTHER PERSON IS FUELING THE VEHICLE. THERE IS NO STOP THAT PREVENTS THE DOOR FROM STRIKING THE GAS DOOR WHEN A PERSON IS EXITING THE VEHICLE. WHEN THIS HAPPENED, THE FUELING NOZZLE WAS JARRED LOOSE AND FUEL WAS SPLASHED ON THE VEHICLE. ALSO, THE FUEL MESSAGE STAYED ON FOLLOWING THIS EVENT ON THE DASHBOARD. (2) DRIVER'S SIDE AND PASSENGER'S SIDE FRONT DOOR POWER LOCKS BOTH FAILED(DRIVER'S SIDE AT 37,000MILES & THE PASSENGER'S SIDE AT 58,000 MILES.) THIS MAY OR MAY NOT BECOME A SAFETY FAILURE; HOWEVER, IF THE DOORS ARE NOT LOCKED MANUALLY, THE LACK OF LOCKED DOORS COULD PROVE TO BE DANGEROUS WHEN THE CAR IS MOVING. *TR

DESCRIPTION OF PROBLEM: 2006 TOYOTA SIENNA SLIDING DOOR ON DRIVER'S SIDE WON'T CLOSE. EVENTS LEADING UP TO PROBLEM: DROVE VEHICLE ABOUT 25 MILES FROM HOME, OPENED SLIDING DOOR FOR CHILD TO EXIT VEHICLE, DOOR WOULD NOT CLOSE AFTER THAT. FRONT LATCH CAN BE SECURED WITH GREAT FORCE, HOWEVER THE REAR LATCH WILL NOT ENGAGE. DOOR REMAINS OPEN AND IS A VERY SERIOUS SAFETY RISK AS THE FRONT LATCH SECURITY/RELIABILITY IS INSUFFICIENT. SLIDING DOOR COULD OPEN WITHOUT WARNING WHILE DRIVING 70 MPH. LIGHTS IN VAN STAY ON, PRESENTING ANOTHER RISK AT NIGHT BECAUSE VISION IS INHIBITED GREATLY BY INTERIOR LIGHTING. HAD TO DRIVE HOME WITHOUT DOOR FULLY CLOSED AT NIGHT. THIS LACK OF VISIBILITY NEARLY RESULTED IN SEVERAL ACCIDENTS. PROBLEM STEMS FROM THE MECHANISM THAT GRABS THE METAL LOOP THAT IS CONNECTED TO THE REAR DOOR FRAME. THE C SHAPED LATCH IS COVERED WITH A PLASTIC COATING WHICH WHEN WORN OR DAMAGED ALLOWS MOISTURE IN AND THE METAL CLAMP SWELLS UP AND BINDS THE LATCH. NO AMOUNT OF LUBRICATION WILL HELP. TOYOTA MADE A BIG MISTAKE BY PLASTIC COATING A METAL THAT WOULD RUST AND SWELL UP THE OUTER COATING FROM THE INSIDE MAKING THE LATCH NOT FUNCTION PROPERLY. THIS IS A SERIOUS DESIGN DEFECT. THERE MAY BE OTHER DESIGN FLAWS CONTRIBUTING TO THE MALFUNCTION OF THIS CRITICAL MECHANISM. *TR

2006 TOYOTA SIENNA POWER SLIDING DOOR JAMMED (PARTIALLY OPEN). WAS UNABLE TO MOVE DOOR EITHER DIRECTION. POWER DOOR DISABLE SWITCH DID NOT RELEASE DOOR. HAD TO DRIVE CAR WITH DOOR PARTIALLY OPEN. FORTUNATELY THIS WAS IN A PARKING LOT AND NOT DURING AN EMERGENCY. *TR

2006 SIENNA MANUAL REAR HATCH LIFT\STRUTS ARE NO LONGER WORKING. HAVE TO MANUALLY HOLD THE DOOR UP, WHICH IS VERY HEAVY. WAS TOLD IT WOULD COST $270 FOR ONE SIDE. *TR

THE PASSENGER SIDE ELECTRIC SLIDING DOOR HAS FAILED. THE DOOR KEPT GOING OPEN AND SHUT ONE EVENING AND THEN STAYED SHUT AND HAS BEEN INOPERABLE SINCE. THE DOOR WILL NOT OPEN MANUALLY NOW AND HAS CREATED A SAFETY HAZARD. TOYOTA HAS REFUSED TO FIX THE PROBLEM AND SAYS THAT IT CAN ONLY REPLACE THE MOTOR WHICH WILL COST OVER $2000. THE FAILURE IS THAT THE DOOR WILL NOT OPEN AT ALL. IT IS A SAFETY HAZARD FOR THE PASSENGERS. THE DOOR HAS A MANUAL MODE, AND SHOULD THEREFORE BE ABLE TO OPERATE MANUALLY WITHOUT THE MOTOR. THE DEALERSHIP WOULD DO NOTHING TO HELP BESIDES CHARGE OVER $2000 FOR WHAT WILL SURELY BE A TEMPORARY REPAIR. *TR