2019 Audi Q7 FUEL/PROPULSION SYSTEM

Drive System malfunction code appeared while driving. Engine then shut off immediately. Had it towed to Audi dealership. Fuel Pump and Fuel Pump Module Codes reported in diagnostics check: codes P3044, P1158, and P0148. There is a NHTSA campaign number 22V516 (Audi recall number 20DR) that has been reported on this same issue with the fuel pump, however, my model 2019 is one year shy of the 2020 Q7 to 2021 affected vehicle range. Asking NHTSA to look into other repeated fuel pump issues for the same model vehicle, but for 2019 models. I have read of other 2019 model fuel pump complaints that match the 2020-2021 recall. The 2019 models need to be included in the investigation and recall.

Faulty fuel sensor. Sensor showing low fuel warning while the tank is full

On [XXX} Friday morning, I was driving at 35 mph on local road after existing from highway. Suddenly the screen displayed this message: Drive system malfunction. The car was totally broken down. I couldn't start the engine any more so I turned on hazard light and pulled over to the curb pending AAA rescue truck. Luckily it was not happened on highway. Otherwise the car could be wrecked to cause fatal accident. It was the first time since I had this brand new Audi Q7 in November 2019 running 26,600 miles. After Audi certified tech inspected, he concluded the fuel pump defective and needed to replace a new one for $3000+. Here is the link the tech completed his walkaround video [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

During high weather temperature the fuel lines pops off and leaks fuel everywhere.

I have been told that I have a fuel rail leak, which can cause a fire in the engine compartment. This is the same as NHTSA Campaign Number 19V035000, but that campaign only covers model years 2016-2018 for the Audi Q7. This same issue has surfaced with my 2019 Q7.

The component that failed was the fuel level sender. The attachment shows that I had it repaired by Audi. They found low static resistance which is the same issue they recalled 46,000 other vehicles for including 2019, just not Q7. The car is available for inspection. My safety was put at risk because the gas and did not work on the safety of others was put at risk because I could have run out of gas anywhere and it anytime. You took over a month to get an appointment. The issue has been corrected in June 2023. Audi was the only one that inspected the vehicle. There was one warning when it failed. .

Filling up the tank registers only half a tank. It seems similar to this recall which wasn't for my car's year. NHTSA campaign number: 22V155