2020 Chevrolet Traverse Engine

After getting my suv back i been notice that ticking sound while driving over 40 mph can't pin point were it coming from the dealership or anybody cannot locate it it happens with speeds.over 40 not exxeced over 60 mph

According to Special Coverage bulletin N242445280, some 2022 Traverse units may have a condition where the mounting bracket on the front exhaust pipe can separate from the pipe. If this event were to occur, a hole can develop in the exhaust pipe at the bracket location, and a ratting or increased exhaust noise may be present. This is exactly what has happened to my 2020 Traverse. I took the car to the Chevrolet dealer where I was told that the recall did not pertain to my VIN. While that may be the case now, I am complaining to have this exact same issue applied to the 2020 and 2021 models as well. This design is exactly the same and should be included. My Traverse has an awful rattle where the bracket has broken off and a hole has worn through. It also throws a downstream 02 exhaust sensor code.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while the vehicle was parked, after starting the vehicle, the vehicle was making an abnormal sound. There was no warning light illuminated. The vehicle was driven to an independent mechanic, who researched the failure, and informed the contact of an undisclosed NHTSA recall; however, the VIN was not included. The contact was also informed that there was a hole in the exhaust system. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Similar to [XXX] . Exhaust bracket broke, was fixed but stress caused converter to break at engine connection. All other years of this generation are recalled but 2020. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Broken bracket for exhaust system. This is know issue in several model years, but have only issues Special Assessment for some years to cover cost even though the same setup in multiple model years (N222385510).

The bracket on the front exhaust pipe broke off and created a hole in the exhaust pipe which caused the catalytic converter to become detached from the engine. A recall has already been issued for the previous model year of traverse but the issue is still occurring on this year vehicle.

After routine oil change in January 2023, rattling noise under car was noticed. Returned to dealer who stated front mounting bracket had cracked. Was informed by technician to take vehicle to muffler shop nearby to have bracket welded due to them not "doing" weld jobs there. Had both bracket and crack in front pipe repaired in June 2023 mileage 68,660. February 2024 Noise returned and steadily grew louder. On March 3, 2024 while turning onto neighborhood road, loud bang was heard then car sounded like it was roaring and was barely moving when pressing gas. Made it to driveway and at ignition cut off, gurgling fluid sound was heard. Towed to Hardy Chevrolet on Tuesday 03/05. Mileage 82,059 Still waiting on full diagnostics but front pipe has completely detached at right passenger cat. Bolts stripped out? I will not be able to pass State mandated emissions testing until repaired. This problem was recalled for the 2018, 2019 and 2021 vehicles, but for some reason not 2020 for the exact issue. The dealership wants to charge for a known safety issue. 2021 - GM Special Coverage (N222385510) 2019 - GM Front Exhaust (N212356540)

Hole in the flex pipe which seems to happen with them all as there have been recalls on years 2018,2019, and 2021.

While driving at low and highway speeds, I began hearing a rattle under the vehicle, along with a loud exhaust noise. I looked at the undercarriage of the vehicle and observed a broken bracket on the exhaust pipe causing a hole in the exhaust pipe. I searched and found this was a common issue with this make and model of vehicle.

The contact owns a 2020 Chevrolet Traverse. The contact noticed that an abnormal exhaust odor was entering inside the vehicle. Additionally, the contact stated that while starting the vehicle, the vehicle made an abnormal rattling sound that became louder over time. The vehicle was taken to the dealer, where it was diagnosed that the exhaust pipe mounting bracket was fractured, which damaged the exhaust pipe. The dealer determined that the exhaust pipe and the mounting bracket needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 58,500.

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving at various speeds, the vehicle made a loud abnormal sound. Additionally, the vehicle made an abnormal rattling sound. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the mounting bracket for the front driver’s side exhaust pipe had fractured, causing a hole in the front exhaust pipe. The dealer also determined that the mounting bracket for the passenger's side exhaust pipe had started to detach. The dealer informed the contact that the passenger's side exhaust pipe would be repaired under warranty; however, she would be charged a repair fee for the driver's side exhaust pipe. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 78,000.

The contact owns a 2020 Chevrolet Traverse. The contact stated while starting the vehicle, the check engine warning light illuminated with a loud sound coming from the exhaust. Additionally, there was an abnormal odd odor entering the cabin of the vehicle. The contact became aware that the front mounting bracket for the exhaust was fractured. The dealer was contacted and stated that the vehicle was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was not under recall. The failure mileage was 106,000.

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving approximately 65-70 MPH, the check engine warning light illuminated. There was an abnormal gurgling and bubbling sound heard. The vehicle was taken to the local dealer where it was diagnosed that the exhaust pipe bracket had fractured and there was an exhaust leak. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 83,000.

Good morning, I have an issue with my 2020 Traverse that GM refuses to fix. I am getting warning lights from leaking exhaust. This is to due to weld defects. GM knows of the issue, they did recalls on the 2018, 2019, 2021 models but won't fix my 2020 even though it is the same issue. GM has a safety bulletin PIP5681 and PIP5681A for this issue. N222385510 is the number for the 2021 recall. The dealership has told me that this absolutely should be recalled but GM will not allow them to repair the 2020 under the same recall number. Thanks for your help!

I was told that my muffler needed to be replaced and not covered under warranty this vehicle is not even 3 years old yet and I need a new muffler my car sounds LOUD and the check engine light is now on.

The contact owns a 2020 Chevrolet Traverse. The contact stated that after starting the vehicle, there was a loud rumbling sound coming from the rear of the vehicle. The vehicle was taken to the local dealer who diagnosed that the front driver’s side exhaust pipe weld had fractured. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer was notified of the failure, but no assistance was provided. The manufacturer was not yet contacted. The VIN was not available. The failure mileage was 56,000.

The exhaust pipe and muffler developed a hole in both exhaust components at less than 32k miles. This is a known design issue for the model as a previous model year had a special coverage adjustment on 03/2022 [XXX] . It is apparent this is a design flaw that wasn't fixed for the 2020 model year. GM has only offered 50% of repair costs. I am requesting the NHTSA to open review of exhaust failure for the 2020 model year of Chevrolet Traverse, GMC Acadia, and Cadillac XT6 that are equipped with the 3.6 liter V6 engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at an undisclosed speed, the vehicle made rattling sounds. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the front exhaust pipe needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to Special Coverage Program: N222385510 (Front Exhaust Pipe); however, the vehicle was not covered by the Special Coverage Program. The failure mileage was approximately 65,000.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound. Additionally, the contact stated that while parked, the vehicle made an abnormal sound. The vehicle was taken to the dealer, who informed the contact that there were fractured brackets that rubbed holes into the exhaust pipe and front muffler. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin Number: N222385510 (Front Exhaust Pipe). The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 35 MPH, the vehicle stalled. The contact stated that the service engine warning light was illuminated. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The vehicle was not repaired. The contact had experienced the failure several times. The manufacturer had not been informed of the failure. The failure mileage was unknown.

I was operating my vehicle at 70 MPH on the freeway, when I took my foot off the accelerater pedal to exit I could feel a pop under my feet and the engine started to make a lot more noise. I lost engine power and had to coast/idle to the nearest gas station. I went under the car and discovered a hole in my exhaust where there used to be a bracket to mount the exhaust pipes to yhe undercarriage. I went on a chevy Traverse Forum to discover this is a common problem. I believe it is unsafe to operate the vehicle with an exhaust leak that also creates loss of engine power and eventually leads to engine damage.

P0420 warning light came on car exhaust has whole in it

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving approximately 35 MPH, there was an abnormally loud sound coming from the vehicle. The contact then started to smell an exhaust odor inside the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer to be diagnosed. The contact was notified of a cracked exhaust pipe. The vehicle was repaired. The contact was made aware of TSB: PIP5681A (Exhaust leak, Lean Codes, Rattle Noise, or Catalytic Converter Failures). The manufacture was notified of the failure. The manufacture informed the contact that VIN was not under recall. The failure mileage was approximately 49,643.

Front exhaust pipe breaks at bracket due to poor design and ineffective welding causing exhaust leak, exhaust rattle, multiple trouble codes. Technical service bulletin PIP5681 and Special Coverage Adjustment N212356540 already exist for known problem.

Muffler pipes are rubbing on the metal that was used to hold the muffler pipes from dragging. There is nothing to stop this from happening. If it’s Rubbing holes in the muffler then it’s allowing the fumes into the ozone layer and also wasting gas and messing the engine up m, causing the engine to read wrong. This is not Normal wear and tear this is a manufactured default that should not be my responsibility bc it wasn’t secured correctly.