2018 Ford Edge Power Train

Brought vehicle in with check engine light on and vehicle codes P0741 and P1744 appeared. Torque converter needs to be replaced along with transmission.

Original transmission failed at 83,000km. August 2023. Replacement FORD crated transmission and new cooler installed at FORD dealership for a cost of approx $11,000 Canadian dollars failed 25 months later. Oct 2025. FORD would not honour 36 month advertised replacement parts warranty. Car was not abused and driven by retiree.

My 2018 Ford Edge (VIN [XXX] ) suffered a premature transmission failure at 105,415 miles. Just 389 miles earlier, Ford performed Customer Satisfaction Program 22N12 (flexplate/torque converter/pump replacement), for which I paid $1,669 as my 50% share. Less than two months later, the same dealer diagnosed the transmission as failed due to the forward clutch being stuck and quoted $6,955 for replacement. Ford’s maintenance schedule does not require transmission service until 150,000 miles, so this failure is premature and unreasonable. A transmission failure at highway speed could cause sudden loss of power, greatly increasing the risk of a crash. This issue appears related to Ford’s known flexplate defect (CSP 22N12) and raises concern of broader transmission reliability/safety problems in affected vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I’m having an issue where there’s a sudden loss of all power while driving at highway speeds, forcing me to slowly move to a safe spot while trying not to get hit by other cars. Once I’m safely stopped, I have to turn the vehicle off and back on, and then the power is restored—but the problem can randomly happen anytime at speeds over 65–70 mph. No codes are showing. A repair shop couldn’t find the issue, and even the dealership says everything is fine and just tells me to keep driving it. Sometimes it happens twice in one day, and other times I won’t see it for a week.

The contact owns a 2018 Ford Edge. The contact stated that at start-up, there was an abnormal rattling sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the flex plate, flywheel, and transmission pump were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 140,000.

The contact owns a 2018 Ford Edge. The contact stated that the power train, wrench, and check engine warning lights were illuminated. The contact stated that the transmission was slipping once the transmission was in 5th gear. The contact stated that while the warning lights were illuminated, the vehicle hesitated before accelerating, and the vehicle was struggling to drive forward. The vehicle was taken to the dealer and was diagnosed and determined that the torque converter had failed and needed to be replaced. The vehicle was not repaired. The clutch was repaired, but not the torque converter. The contact became aware of NHTSA Campaign 18V390000 ( Power Train); however, the VIN was not included. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 118,890.

I am filing a formal complaint regarding a potential failed or insufficient recall repair related to NHTSA Recall 22V413 / Ford Recall 22S43 on my 2018 Ford Edge (VIN: [XXX] ). Ford replaced the shift cable bushing in Sept 2022. Within months, I experienced symptoms consistent with the original defect, including gear engagement issues, especially on inclines. One day, after shifting into reverse in a parking lot, the car rolled forward. I had to slam the brakes to avoid hitting another vehicle and feather the gas to reverse. These issues continued. Despite multiple service visits and reporting concerns, the dealership failed to document the problem. In Sept and Nov 2024, I again contacted the dealer. On Dec 18, 2024, they finally provided a loaner and inspected the vehicle. A full teardown revealed internal damage: metal debris in the solenoid body, worn sun gears, and failed clutch components—consistent with long-term gear misalignment. Ford has offered partial financial help but refuses to cover the full cost, leaving me with over $1,300 out-of-pocket despite raising concerns during the warranty window. As of June 16, 2025, the vehicle is still disassembled and remains in the dealership’s service bay with no firm repair date. I have been without my personal vehicle for six months. I respectfully request NHTSA to: Investigate whether recall 22V413 repairs are failing prematurely or inadequately prevent long-term damage. Assess whether further manufacturer responsibility is warranted for failures linked to this recall. Encourage Ford to fully cover repair costs under an extended remedy. Consider requiring a recall performance audit or extended warranty for affected vehicles. Thank you for reviewing this safety matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fly wheel and flex plate broke causing the car to lose power. The car then stopped having use of the transmission so was unable to move the car.

Slips out of gear when starting up again from stop then back in gear suddenly causing jerky start

I am told my torque converter clutch is slipping, and I am recommended to replace my torque converter and pump despite the vehicle having only 64,000 miles driven. Transmission parts are failing despite having a relatively young car. The vehicle was inspected at a Ford dealership and a diagnostic was performed to find this defect. I have investigated if there is an open recall for my VIN and none appear, although the torque converter on 2018 Ford Edge Titanium vehicles have recalls on them. Prior to the failure, a wrench icon as well as the check engine light were turning on and off between uses of the vehicle. These icons both turned off prior to bringing my vehicle to the dealership, indicating to me that there was no longer an issue present, though the dealership stated through their diagnostic that there indeed was still an issue with the transmission.

Yes, available for inspection. 2.0L Eco Boost engine leaking coolant into cylinder 1 due to a design defect 2015-2018 which has since been corrected. The only fix is a complete engine replacement. There is a recall for the Ford Fusion and Focus FOR THE SAME ISSUE; however, the Ford Edge 2.0L Eco Boost has not yet been added. There is a service bulletin addressing this issue requiring an engine block replacement: TECHNICAL SERVICE BULLETIN 2.0L EcoBoost - Coolant in Cylinders, White Exhaust Smoke And/or Illuminated MIL. An extensive internet search revealed widespread accounts of this issue, mostly after the manufacturer warranty had expired, leaving the customer responsible for engine replacement. Because this was deemed to be caused by a design defect (grooves were etched into the block to allow coolant between the cylinders which weakened the block, causing cracks, which allowed the coolant intrusion), I believe the existing recall should be expanded to include the 2015-2018 2.0L EcoBoost engine as well.

While driving the vehicle transmission shifts are radically intermittently on up shift when traveling highway speeds no problem when decreasing speed at highway speed and increasing speed sometimes the vehicle lurches or jumps then when coming to a stop when you're downshifting it seems to be third gear through first gear the transmission violently jerks as it's downshifting to the point where you can almost lose control. It seems a lot like a safety recall on the 2017 edge dealing with the torque converter

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle briefly jerked, after which the contact heard an abnormal sound emanating from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 93,000.

Check engine light and wrench light are both on. Checked by mechanic. Issue with power train:automatic torque converter. There is a recall on 2018 ford edge for this issue, but my VIN isn’t listed. Car has less than 60,000 miles on it.

Transmission went to nurteal because it went out at 139k tow to repair shop who stated this the same transmission as escape called ford cs was told there a customer extended warranty placed on my transmission but covered it to 120k I was never notified of this ford said tuff but if it’s the same transmission as escaped they should warranty it

I took my vehicle in for a check engine light to the dealership. It has been diagnosed with coolant intrusion. There is a current recall but I’ve been told my vehicle isn’t in it even though this is what is wrong with my vehicle

Summary: Some 2015-2018 Edge equipped with a 2.0L EcoBoost due to coolant intrusion into engine which could cause the potential for engine fires and failure, misfires, collision risk, and costly repairs. Vehicle did not exhibit a low coolant level, white exhaust smoke did not run rough. Automaker knew about the Ford EcoBoost engine defect since 2010 based on pre-production testing and complaints made by consumers to the NHSTA but didn’t address the cause of the problem. Now I have to pay $10,000 parts and labor!!! Called Ford Customer Service. No assistance unless a recall is sent.

Two days after I bought this car I took it back to the dealership and told them that there was something wrong with the car. It didn't drive right and when I would put the car in reverse I felt a "flutter" feeling. After they finally got me in to have it looked at, they told me that there was nothing wrong with it. A few months later I took it back to another local Ford dealership after I got a notice in the mail about the transmission. It was not a recall. They also told me there was nothing wrong with it. At this point it would shift hard every now and again. about a month and a half ago, I was driving and a wrench light showed up on my dash. I had a mechanic hook it up to the computer and it was giving me codes P0741-00. I took it to Ford and had them run a diagnostic on it and they called me and told me that I needed a transmission overhaul. If they had fixed it the first two times I had it in to be looked at I wouldn't be without a car right now. I have been in contact with Ford Motor Co also and they are now saying that I still have to pay out over $3200 that I don't have. They were supposed to reach back with me on Fri and still have not heard from them.

The Ford Edge 2018 has a common issue with its transmission - it fails to start at low mileage, causing the car to lose power unexpectedly. This could lead to dangerous situations and potentially render the car completely uncontrollable. Ford dealers acknowledge that it's a common problem for this model, but they do nothing about it.

The contact owns a 2018 Ford Edge. The contact stated while after a stop sign and attempting to accelerate, the vehicle failed to respond as needed. The contact stated that the vehicle jerked and then abruptly accelerated with the check engine warning light illuminated. The contact stated that the vehicle was diagnosed, and it was determined that the torque converter and clutch cylinder needed to be replaced. The vehicle was not repaired. On another occasion while attempting to accelerate, the vehicle failed to respond and started jerking. The contact pulled over on the side of the road and looked under the hood and noticed smoke coming from the transmission. The vehicle was towed to the residence. The dealer was contacted and stated that the vehicle was not included in NHTSA Campaign Number: 18V390000 (Power Train). The manufacturer was contacted and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 88,000.

The contacts husband owns a 2018 Ford Edge. The contact stated that while driving various mph on multiple occasions the vehicle accelerates without the accelerator pedal being depressed. Additionally, when the vehicle was shut off the engine still sounds like its on. The check engine and powertrain malfunction safety warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified and a case number was provided. The failure mileage was 67,500.

We were sent a recall notice from Ford (Program 22N12-Flexplate) in September 2022. Our vehicle was in the service department for an engine replacement in August of 2022. I asked my local dealer to make repair before I left for a trip from Lewisville, TX to Athens, Ga for our granddaughter's graduation. They would not because the FLEXPLATE must be broken. On our return trip home, we pulled into our hotel in Laurel, Ms. There was loud noise from the engine compartment. Went to the local dealer and he said come back in the morning and they would check it out. They found the flexplate broken and the dealer said the vehicle was unsafe to drive. Thank God it broke in town rather than on the lonely interstate at night. We believe this program should be completed immediately before you are left alone on the side of the interstate. In addition, we incurred extra expenses that Ford is not reimbursing us.

2018 FORD EDGE. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 22V-413.

The contact owns a 2018 Ford Edge. The contact stated while driving at various speeds, the accelerator pedal was depressed but the vehicle hesitated and stalled on several occasions. The vehicle was taken to the local dealer where the transmission was repaired. However, the failure reoccurred. No further information was available. The vehicle was taken back to the dealer where it was diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 20,000.

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train ) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available