2023 Ford Escape Engine

Symptoms appeared in January 2026. Check engine light is on-HAD P0301 & P0316. Ran misfire monitor & Relative compression and cylinder 1 is the issue with 70 PSI. Performed cylinder head leak down test- exhaust valve leaking replace cylinder head assembly. Problem confirmed and diagnosed by Ford dealership. The safety issue associated with the car are: sudden jerking or hesitation, loss of acceleration when merging or crossing traffic, unpredictable throttle response, sudden loss of power. Symptoms appeared in September 2025. In October 2025, the car required a turbo repair, which cost a total of $1,600. The safety issue associated with the car are: air-fuel balance, engine misfires, complete stall, loss of power. This was diagnosed by certified repair show. Similar recalls have been made to other Ford Escape cars and I believe my VIN number should be included.

For the last 2 weeks After accelerating my engine coolant overheat warning light goes off and i can't accelerate any further until light goes off. Also ford mechanic states there is metal shavings in the coolant that might be causing engine to overheat on top of the sensor issue.

Within a block of my wife pulling out of our apartment complex onto a 55mph highway to travel to work in the morning, the vehicle had several lights on the cluster illuminate and indicated that it was overheating and went into limp mode. She was able to move to the shoulder and call me. The amount of traffic on this highway and the speed in which she lost power made this a very unsafe event. The check engine light had come on and the vehicle indicated maximum engine temperature, service engine soon light illuminated as well as powertrain fault. The vehicle was towed to the selling Ford Dealer and the condition was confirmed and the vehicle still indicated high temp even after sitting overnight. It was diagnosed from a service bulletin as having a faulty head that had manufacturing debris in it which was released into the coolant system and blocked the coolant temperature sensor. Warranty covered parts have been ordered with some being on Backorder. The vehicle is still in the shop awaiting parts and we have been provided a loaner. We have only owned the vehicle three months and 1500 miles when this occurred. Ford declined a buyback request on the vehicle and offered no remedy except warranty repair.

The contact owns a 2023 Ford Escape. The contact stated that while her husband was driving at 55 MPH he smelled a burning odor. The vehicle was pulled into a parking lot where the hood was lifted and the odor emanated strongly from the engine compartment. Additionally, he noticed sparking, and then flames erupted. The vehicle was towed to an unknown repair center. The fire department distinguished the fire. A police report was not filed. The manufacturer was not notified of the failure. The failure mileage was approximately 7,400.

The contact owns a 2023 Ford Escape. The contact stated while driving 70 MPH, the vehicle suddenly decelerated after the engine overheated and shifted into "LIMP Mode". The contact stated that during the failure, the message "Engine Overheated" was displayed. The vehicle was taken to the local dealer who diagnosed that the engine was faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was not contacted regarding the failure. The failure mileage was 4,200.

I was driving home to Aspen, CO from Denver. I was about 44 miles from my home, on the other side of an 11,000 ft mountain pass. As I was passing another vehicle, the car died. The dashboard light said "engine coolant over temperature". The car died as I was pulling back into the right lane. The person behind me swerved around me. I had to have the car towed to a dealer that is 2 1/2 hours from my home. It's been sitting at the Ford Dealership in Salida, CO for 9 days. They keep telling me they will get it in to diagnose the problem but every day it's the same story and they do nothing. After doing online research, that make, model and year vehicle engine issue has been reported by many owners. There was no warning about this issue. It simply died while driving on the highway.

Upon reaching 60 mph my vehicle displayed overheating messages and cut power to the motor. Vehicle was towed into Ford service on 4/4/24 and remains in the shop. Been told it needs a new top end of the motor with no eta on parts. I was approximately one mile from my home when the incident occurred.

The car warned of overheating and messaged to service immediately...

Shortly after purchasing this, my daughter was driving it and the check engine light came on and it said it was overheating. The dealer was contacted and it was taken in for repairs. We got it back and was told that it was a broken wire in the wiring harness and they ordered a new harness but had fixed the wire so it should be good to go. 2 weeks later it did the same thing and actually went into limp mode. This time they said it was the sensor in the cylinder head and they ordered a replacement. Fast forward 3 1/2 months and it's still at the dealers. They are now telling us the cylinder needs to be replaced and the parts are on backorder. While we have been waiting they gave us a 2023 Bronco Sport with the same 1.5 liter 3 cylinder and that hasn't given any issues. When the loaner hit 5000 miles we had to return it to the dealer for a different vehicle. They gave us a 2023 Escape with the same 1.5 liter 3 cylinder and only 800 miles in it. The 2nd day my daughter drove it, it did the same thing as the one she originally purchased did. We have now been told by the service department that they have several doing the same thing and they are replacing the heads on each one when they get them. Our Escape is now on the Lemon Law Buyback and the dealer won't even give us the time of day. The dealer told my daughter she needed to stop the Lemon Law Buyback process and then they would talk to her about trading it in for a different vehicle. The issue is, she is upside down on the loan and the only way she can finish the Lemon Law buyback is to come up with close to $5000 to get out from under the vehicle and the dealer says there is no way that they can/will roll that into a different loan. Upon looking at the Forums many of these vehicles are having the same issue. Ford really needs to step up and take care of this ASAP. It isn't safe being stranded along the road.

At approximately 1,000 miles on 2 separate occasions while traveling on the interstate, roughly 10 minutes apart, an audible chime and visual alert within the speedometer cluster appeared “engine coolant over temperature” for approximately 10 seconds. The temperature gauge within the cluster indicated normal, midway within the span of the gauge. The following day prior to starting the vehicle, a cold start essentially, the coolant level was “full”. I ran a “check engine” check with no stored codes in temporary or permanent storage. My 2023 Ford Escape has the 1.5L EcoBoost engine. When the warnings appeared, there was no reduction in engine power(limp mode) and no signs of steam while looking in the rear view mirror.