2022 Ford Expedition Electrical System

Rear defrost coils have continually fallen off. Dealer fixed one in February of 2024. It fell off March 2024. They are both hanging there. Dealer won’t touch it - says rear window needs replacement. I’ve researched on ford expedition forum and many expeditions have a similar issue. Especially with dealer not covering it.

The audio system has become inoperable and instead the speakers are blasting static noise with crackling and popping sounds at high volume. Cannot stop it or use any other audio. Very unsafe to drive due to extreme noise level and lack of controls. Appears many people have this issue and there needs to be a recall to fix.

While driving the vehicle, the stereo system suddenly without warning started an unbearable loud and deafening noise. I was driving on a busy highway and was able to the the next exit. I had 2 other occupants in the vehicle. We had to exit the vehicle because the noise level from the speaker was painful and caused disorientation. I turned the vehicle off but the noise continued for at least 10 minutes then stopped. Myself and the 2 other occupants still have ear pain 24 hours later.

The contact owns a 2022 Ford Expedition. The contact stated that while her husband was having a light bulb replaced, the dealer became aware that the electrical wiring was damaged due to rodents chewing on the wiring insulation. The vehicle was repaired but the failure persisted. There was no warning light illuminated. The manufacturer was notified of the failure. The failure mileage was 22,489.

Alternator failed suddenly. Caused loss of power to all components while driving.

For the fourth time our brand new Ford Expedition has had a issue with the SYNC radio B&O Sound system. It initially started out where the 15.5 inch screen locked up and no radio, Bluetooth would work and couldn’t even control climate. The dealer got to see this first hand and had no interest in investigating. Now the last three times has been a HORRIFYING pop and extremely loud static and popping like fire works inside the car. Two of the three times luckily my wife wasn’t driving. The most recent time this happened as we were driving down the road and THANKFULLY no car was in the opposite lane as it caused me to jump and swerve because i though we had been hit. This could have ended very badly under the wrong timing and especially with my 4 year old and infant in the car which they also started screaming because it was ear piercing. After a little investigation I have come to see this is no new issue with the Ford Sync B&O sound system. Some people have stated the dealers complimentary changed the amplifiers and seemed to have solved the problem. Sadly the two dealers in my area will not even look into it unless the problem is currently occurring. The bad part is that the next time it does occur could be detrimental to the life of my wife and kids!

I just had the same issue described in the forum listed below. Extremely loud max volume screeching static through the speakers. Tried turning the car off and on several times, tried turning the radio off, tried switching to Serius xm radio, nothing would make it stop and it was completely unsafe to drive it like that. It was too loud to hear anything else over it and it was so jarring. I now have a headache and i’m nervous to drive it for fear of it happening again. My husband had to disconnect the battery to get it to stop. I have a video but it doesn’t seem like I can upload it here, only pics. https://www.f150gen14.com/forum/threads/extremely-loud-electrical-pop-followed-by-loud-static.9591/page-4