1997 Ford Explorer VEHICLE SPEED CONTROL

DT*: THE CONTACT STATED THE CRUISE CONTROL WAS SET AT 55 MPH WHILE DRIVING ON THE HIGHWAY WHEN THE VEHICLE ACCELERATED ON ITS OWN. THE CRUISE CONTROL WOULD NOT DISENGAGE. THE VEHICLE REVVED TO 85 MPH BEFORE THE CONTACT TURNED THE KEY TO THE OFF POSITION AND PULLED OFF OF THE ROAD. EACH TIME THE VEHICLE WAS RESTARTED THE VEHICLE CONTINUED TO ACCELERATE ON ITS OWN. FINALLY THE CONTACT DISENGAGED THE CRUISE CONTROL UNDER THE ENGINE AND DROVE THE VEHICLE ONE MILE TO A DEALERSHIP WHERE IT WAS DETERMINED THE CRUISE CONTROL SWITCH WAS FAULTY. UPDATED 09/11/06. *JB

DT*: THE CONTACT STATED THE VEHICLE HAD A BRAKE FLUID LEAK THAT WAS LEAKING ONTO THE VEHICLE SPEED CONTROL SWITCH. THERE WAS A RECALL #97V074000 PERTAINING TO THE VEHICLE SPEED CONTROL. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE HAS NOT BEEN TO A DEALER.

WHILE DRIVING 1997 FORD EXPLORER XLT 4X4 V6 SOHC UPON ACCELERATION ON TO FREEWAY, THE GAS PEDDLE STUCK TO FLOOR AND WOULD NOT RELEASE. THE RESULT WAS A BLOWN ENGINE/SMALL FIRE,NO INJURIES THANK GOD, BECAUSE THE ONLY WAY TO STOP VEHICLE WAS TO PUT INTO NEUTRAL AND THEN PARK. THE FOOT BRAKE AND EMERGENCY BRAKE WERE USELESS, AND THE VEHICLE WAS REVVING AT 75 MPH AT THE TIME TILL BROUGHT TO STOP THUS BLOWING A HUGE HOLE IN WALL OF ENGINE TO THE TUNE OF $5000.00 TO FIX. FORD CLAIMED THERE WAS NOTHING WRONG WITH PEDAL AFTER DOING A DIAGNOSTIC. THIS THROTTLE WAS RECALLED A FEW YEARS AGO AND FORD CLAIMED THAT THEY FIXED IT. *NM

CRUISE CONTROL UNDER THE HOOD CAUSED POWER OUTAGE TO OVERHEAD TEMPERATURE/DIRECTION DISPLAY. WHEN TAKEN TO DEALERSHIP FOR REPAIR THE TECH ALONG WITH THE SERVICE MANAGER,INDICATED THAT SPARKS AND SMOKE WAS COMING FROM THE CRUISE CONTROL LOCATED UNDER THE HOOD WHEN POWER WAS APPLIED. THIS IS THE SAME CRUISE CONTROL THAT HAS CAUSED ACCIDENTS AND DEATH. THIS CRUISE CONTROL IS THE SAME ONE THAT HAS SPARKED A LARGE RECALL FROM FORD BUT THE FORD MOTOR COMPANY ELECTED NOT TO INCLUDE THE EXPLORER. *NM

I HAVE A 1997 FORD EXPLORER THAT CAUGHT FIRE. THE FIRE ORIGINATED AROUND THE WIRING HARNESS IN AND AROUND THE MASTER CYLINDER. WHEN MY VEHICLE CAUGHT FIRE I LOST MY BRAKES INSTANTLY.*JB

DT: THE CRUISE CONTROL SWITCH STOPPED WORKING, THE CONSUMER LIFTED UP THE HOOD AND NOTICED THAT FLUID WAS LEAKING AROUND THE MASTER BRAKE UNIT. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND THEY CONFIRMED THAT IT WAS A PROBLEM AND THEY REPLACED THE CRUISE CONTROL SWITCH ABOUT A WEEK AGO. *JB

THE CRUISE CONTROL ON OUR 1997 FORD EXPLORER STOPPED WORKING. I CALLED AND CHECK TO SEE IF THERE WERE ANY RECALLS ON THIS PROBLEM BECAUSE WE KNOW OF THE EXPEDITION HAVING PROBLEMS WHERE THIS WAS CAUSING FIRES TO START WITH THE VEHICLE. WE WERE TOLD THIS DID NOT INVOLVE THE EXPLORER. I WAS CONCERNED BECAUSE I FEEL THAT THERE COULD BE A CONNECTION. WE HAD THE REPAIRS DONE BUT I FELT THAT THIS NEEDED TO BE REPORTED. I ALSO FEEL THAT FORD SHOULD BE REQUIRED TO REPORT TO THE NHTSA EACH TIME THE FORD EXPLORER HAS TO REPAIR CRUISE CONTROL FAILURES TO HELP DETERMINE IF THERE IS A PROBLEM THAT IS WIDESPREAD. *JB

DT: THE CONTACT STATED WHEN ATTEMPTING TO STOP AT A STOP SIGN THE VEHICLE SUDDENLY ACCELERATED AND IT WENT THROUGH THE STOP SIGN AND THEN CAME TO A STOP WHEN PLACED INTO NEUTRAL. THE VEHICLE ACCELERATED SUDDENLY TWO MORE TIMES BEFORE THE CONTACT WAS ABLE TO TAKE VEHICLE TO THE DEALERSHIP. IT OCCURRED WHILE AT A COMPLETE STOP. AGAIN THE BRAKES WOULD NOT HOLD AND THE VEHICLE WAS PLACED INTO NEUTRAL TO GET IT TO STOP. THE VEHICLE IS CURRENTLY AT THE DEALER FOR DIAGNOSTIC TESTING, WHICH HAS NOT BEEN COMPLETED AT THIS TIME. *AK UPDATED 12/27/2005 - WHEN THE VEHICLE WAS STARTED COLD IT WOULD NOT STAY ON AND IDLED ERRATICALLY. THE DEALER INFORMED THE CONSUMER THAT THE ACCELERATION PROBLEM AND IDLE PROBLEM WERE DUE TO A FAULTY THROTTLE SENSOR. THE DEALER REPLACED THE THROTTLE VALVE ASSEMBLY BUT THAT DID NOT CORRECT THE PROBLEM.*NM

ACCELERATOR PEDAL AND BRACKET FELL OFF WHILE DRIVING ON HIGHWAY. GAS CABLE WAS PULLED TO IDLE CAR OFF ROAD. THE PEDAL WAS BOLTED BACK ON BY AUTO BODY SHOP BUT IS NOT GUARANTEED TO HOLD. *JB

WHEN I LIFTED OFF OFF THE GAS PEDAL TO BRAKE FOR STOPPED TRAFFIC, THE GAS PEDAL SEEMED TO STICK AND REV THE ENGINE AS I WAS TRYING TO STOP. I HAD PLENTY OF TIME TO STOP, BUT BECAUSE OF THE SPEED OF THE ENGINE IT TOOK LONGER TO SLOW DOWN, AND I HIT THE VEHICLE IN FRONT OF ME. THIS HAS HAPPENED TWICE TO ME AND AT LEAST ONCE WITH MY WIFE OVER A 3 YEAR PERIOD. THE OCT 15TH RESULTED IN AN ACCIDENT. *JB

CONSUMER STATED WHEN BRAKES WERE APPLIED VEHICLE ACCELERATED. AS A RESULT, CONSUMER'S VEHICLE REAR ENDED ANOTHER VEHICLE. *AK

WHILE PULLING OUT INTO TRAFFIC, ACCELERATOR PEDAL BROKE AWAY FROM THE FIREWALL. WAS ABLE TO ROLL OVER TO SHOULDER. I WAS ABLE TO REACH UNDER THE DASH AND PULLED ON THE PEDAL TO DRIVE. APPARENTLY THE WELDS (3) FAILED (TORE OUT). I REPAIRED IT BY DRILLING OUT HOLES AND SCREWING THE BRACKET BACK TO THE FIREWALL. *AK

1997 FORD EXPLORER LIMITED. WHILE DRIVING GAS PEDAL ASSEMBLY BROKE OFF FROM FIREWALL. UNABLE TO ACCELERATE. HAD TO REACH UNDER DASH TO GRASP THROTTLE LINKAGE TO GET OFF ROAD. (THANKFUL MY WIFE WASN'T DRIVING AT THE TIME). *AK

ON FEBRUARY 16, 2004 AT APPROXIMATELY 2:30 PM I WAS PULLING MY WIFE'S 1997 FORD EXPLORER SPORT INTO A DIAGONAL PARKING STALL. I HAD ALMOST COME TO A COMPLETE STOP WHEN THE ENGINE BEGAN TO ROAR AND THE CAR BEGAN TO ACCELERATE AGAINST MY BRAKING. I PRESSED AS HARD AS I COULD ON THE BRAKE PEDAL BUT THE CAR CONTINUED TO MOVE FORWARD UNTIL IT STRUCK A CAR OPPOSITE MY PARKING STALL. I PUSHED THE GEAR SHIFT INTO NEUTRAL AND TURNED OFF THE ENGINE. I CHECKED MY RIGHT FOOT POSITION AND CONFIRMED THAT I WAS ONLY PRESSING ON THE BRAKE PEDAL. WHEN I RELEASED THE BRAKE PEDAL THE CAR ROLLED BACK A COUPLE OF FEET. I SHIFTED THE CAR INTO PARK AND RESTARTED THE ENGINE AND BACKED THE CAR UP ANOTHER 3 FEET. THE SUDDEN ACCELERATION HAS NOT RECURRED BUT I AM CONCERNED THAT IT MIGHT AGAIN. *JB

ENGINE IDLE SURGES WITHOUT WARNING AT STOP SIGNS. IT IS VERY DANGEROUS, AND HAS ALMOST CAUSED FIVE ACCIDENTS. IT SURGES BEWEEN 3000-4000 RPMS. *AK

VEHICLE EXPERIENCED THE SAME DEFECT WITH ITS SPEED CONTROL AS STATED IN RECALL 99 V 062 001, BUT IT'S VIN NUMBER IS NOT INCLUDED.*AK

VEHICLE ACCELERATED AT AN UNSAFE SPEED. *TT

SAFETY COMPLAINT INVOLVING A STUCK ACCELERATOR ON A 97 FORD EXPLORER. THE INCIDENT OCCURRED ON A COUNTY ROAD, WHILE TRAVELING A 50 MPH, WHEN A ATTEMPT WAS MADE TO SLOW DOWN THE VEHICLE AS IT APPROACHED AN INTERSECTION. AFTER SEVERAL ATTEMPTS TO APPLY BRAKES FAILED, I WAS ABLE TO MANEUVER THE VEHICLE TO THE RIGHT SHOULDER AND STOP IT BY SWITCHING OFF THE ENGINE. SEARCHING TO FIND THE SOURCE OF THE PROBLEM, I REACHED FOR THE ACCELERATOR PEDAL, WHICH WAS LOOSE AND SUBSEQUENTLY DANGLED IN MY HAND. THE VEHICLE WAS TOWED TO NORTH COUNTY FORD, VISTA CA., WHERE IT WAS REVEALED THAT"BROKEN ACCELERATOR BRACKET WELDS" WERE THE SOURCE OF THE PROBLEM. THE CAR WAS THEN REPAIRED AT A COST OF $132.89. ON MONDAY MAY 12 AND AGAIN ON TUESDAY MAY 13, I CALLED FORD MOTOR CO. CONSUMER SERVICE (800) 392-3673, TO REPORT WHAT I BELIEVE IS A SAFETY DEFECT IN THE VEHICLE AND TO REQUEST A REIMBURSEMENT FOR THE REPAIR. I WAS TOLD BY THE FORD REPRESENTATIVES THAT THE "INCIDENT" WOULD BE REPORTED TO THEIR ENGINEERING DIVISION, BUT SINCE THERE WERE NOT ANY RECALLS ON CASES SUCH AS THIS, THEY WOULD NOT COVER THE COST OF REPAIR. I CERTAINLY TAKE EXCEPTIONAL TO THEIR FINDING AND EXPRESSED MY DISAGREEMENT. THEREFORE, I REQUEST YOUR AGENCY TO LOOK INTO THIS INCIDENT AS I FEEL THERE IS A POTENTIAL HAZARD TO PUBLIC SAFETY AND TO HELP DETERMINE WHETHER OR NOT I AM DUE REIMBURSEMENT FOR THE COST OF THE REPAIR OF THIS DEFECT. *JB

IN MANY OCCASIONS I HAD TURNED OFF THE CRUISE CONTROL AND THE CAR HAD CONTINUE TO ACCELERATE. MY GAS PEDAL HAS GOTTEN STUCK TOO MANY TIMES. WELL TODAY WAS THE BEST OF ALL. MY CAR FELT FOR A FEW DAYS THAT IT DID NOT ACCELERATE WHEN I PRESSED ON THE PEDAL. I TOOK IT IN YESTERDAY TO HAVE THE OIL CHANGED AND SEE WHAT THE MATTER WAS. NOTHING WAS FOUND WRONG WITH THE CAR BY THE MECHANIC. WELL, TODAY I FOUND OUT WHAT THE MATTER WAS. AS I WAS DRIVING ON MY WAY TO MY SON'S DAYCARE THE ACCELERATOR PEDAL CAME OFF THE FLOOR. I HAD NO PEDAL. I PULLED TO THE SIDE AND INDEED THE CABLE AND PEDAL WERE LAYING ON THE FLOOR. I MANAGED TO GET TO THE MECHANIC BY TRYING THE CAR TO MOVE. THE MECHANIC SAID THAT THE CABLE SNAPPED AND THAT IT HAD TO BE REPLACED. *NLM

I HAVE TO PUSH EXTRA HARD ON THE PEDAL TO ACCELERATE BECAUSE IT FEELS STUCK. WHEN AND WHEN THE PEDAL FINALLY GETS LOOSE, THE CAR ACCELERATES ABRUBTLY. *AK

THE VEHICLE EXPERIENCED THE SAME PROBLEM WITH THE CRUISE CONTROL AS STATED IN RECALL 99 V 062 00, BUT THE VEHICLE WAS INCLUDED IN THE RECALL. THE CONSUMER STATED THE CRUISE CONTROL FAILED TO DISENGAGED, THE PROBLEM HAPPENED THREE TIMED. *AK *JB

CONSUMER STATES THAT THERE HAVING THE SAME PROBLEM AS RECALL#0V422000 THROTTLE. DEALER WILL NOT REPAIR.

WHEN THE VEHICLE WAS PUT IN REVERSE, IT ACCELERATED, RESULTING IN A CRASH. CAUSE UNKNOWN AND THE DEALER WAS NOTIFIED. *AK THE CONSUMER STATES THAT HIS WIFE STARTED TO BACK OUT OF THE LEVELED DRIVEWAY, WHEN THE VEHICLE IMMEDIATELY WENT INTO FULL THROTTLE AND CROSSED THE STREET ONTO THE NEIGHBORS PROPERTY. THE VEHICLE TRAVELED APPROXIAMATELY 500 FEET BEFORE SHE WAS ABLE TO STOP. (CAUSE DAMAGE TO THE PROPERTY AND THE VEHICLE) THE CONSUMER FEELS THAT THERE IS A MALFUNCTION ON THE PART OF THE EXPLORER AND THAT FORD IS RESPONSIBLE. *SCC

CONSUMER STATES WHILE DRIVING THE ACCELERATOR PEDEL STICKS CAUSING THE VEHICLE TO SURGE FORWARD. PH

CONSUMER STATES WHILE DRIVING AND WITHOUT WARNING THE ACCELERATOR PEDAL WILL STICK UPON ACCELERATION, DEALER HAS BEEN NOTIFIED AND HAS REPLACED PEDAL.*JB *SLC