2007 Ford F-150 Power Train

The contact owned a 2007 Ford F-150. The contact stated that when depressing the accelerator pedal while in reverse, the vehicle suddenly accelerated, crossing a field, and crashing into a nearby building, where the vehicle came to a stop. The contact sustained neck injuries, and the front passenger sustained neck injuries as well. The contact did not seek medical attention; however, they intended to do so in the future. The air bags did not deploy. A police report was filed. The rear end of the vehicle was damaged. The vehicle was driven home. The vehicle was taken to Collision Center who diagnosed that the rear of the vehicle needed extensive bodywork and determined the vehicle was totaled. The manufacturer was not informed of the failure. The failure mileage was approximately 300,000. The VIN was not available.

The contact owns a 2007 Ford F-150 The contact stated while driving at an undisclosed speed, the vehicle stalled and jerked. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred, with the check engine warning light illuminated. The vehicle was taken back to the mechanic where it was diagnosed and determined that the spark plugs, and torque converter had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 126,963.

The contact's daughter owns a 2013 Ford Focus. The contact stated that the vehicle had failed to shift properly and shuddered. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the clutch assembly needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to another local dealer, #1 Cochran Ford Boardman (7955 Market St., Youngstown, OH 44512); where it was diagnosed and determined that the clutch assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 17,000.

The contact owns a 2007 Ford F-150. The contact stated while making a right turn from a complete stop at 7-10 MPH, the vehicle shuddered significantly. The contact pulled over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the driveline assembly had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 120,000.

Shifting the automatic transmission from gear to gear with the shifting lever has become extremely difficult. can this be rectified with lubrication at some point? Thankyou

The contact owns a 2007 Ford F-150. The contact stated that while driving at an undisclosed speed, the gear shifter was difficult to shift. The contact stated that the gear shifter was stuck in park(P). There were no warning lights illuminated. The local dealer was not contacted. The vehicle was diagnosed or repaired. The contact stated that the transmission shifter cable was repaired several times by an independent mechanic. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 171,639. The VIN was not available.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHEN THE GEAR WAS SHIFTED INTO REVERSE, THE VEHICLE WOULD NOT MOVE BACKWARDS. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO ROBICHAUX FORD (985-446-3100, LOCATED AT 272 W MAIN ST, THIBODAUX, LA 70301) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE CONTACT WAS REFERRED TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT PROVIDED.

TRANSMISSION SLIPPING IN REVERSE.IT THROWS UP THE CODE PO720, WHICH IS THE OUTPUT SHAFT SPEED SENSOR. THE VEHICLE IS INCAPABLE OF TOWING ANYTHING. THIS IS AN ISSUE FOR THIS SPECIFIC TRANSMISSION DATED ALL THE WAY BACK TO 2002.WE BOUGHT THE VEHICLE LESS THAN A YEAR AGO.

VEHICLE DIFFERENTIAL FAILED AND STARTS ERRATICALLY BUCKING WHILE DRIVING.

I WAS STOPPED AT A TRAFFIC LIGHT, WHEN THE LIGHT TURNED GREEN I GAVE THE TRUCK SOME GAS AND IT STARTED MAKING NOISE AND ACTED AS IF SOMETHING WAS ABOUT READY TO FLY APART AND SEVERLY VIBRATING. I HAD TO STOP AS QUICK AS POSSIBLE WITH CARS BEHIND ME SWERVING TO GET AROUND ME. I HAD TO CALL A TOW SERVICE TO GET MY TRUCK HOME, AFTER INSPECTION OF THE DRIVESHAFT I FOUND THAT THE CARRIER BEARING HAD SLIP OUT OF IT'S HOUSING AND THE DRIVESHAFT WAS BOUNCING AROUND IN THE BEARING BRACKET. I COULD NOT LOCATE A CARRIER BEARING ANYWHERE SO I CALLED THE FORD DEALERSHIP AND WAS TOLD I WOULD HAVE TO BUY AND REPLACE THE ENTIRE DRIVESHAFT. I DID SOME SEARCHES ON THE INTERNET AND FOUND THAT THIS HAS HAPPENED NUMEROUS TIMES. IF YOU INSPECT THE DRIVESHAFTS NOW BEING SOLD FOR REPLACEMENTS YOU WILL FIND THAT THERE HAVE BEEN DESIGN CHANGES MADE BUT FORD WON'T ADMIT THAT THEY HAD A DESIGN FLAW WITH THE ORIGINAL DRIVESHAFT. BY THE WAY, MY 2007 F150 ONLY HAS 32000 MILES ON IT, IT'S NOT A WEAR ISSUE.

FORD 150 PICK UP TRUCK REGULARLY MAINTAINED WITH 70,836 MILES WAS TRAVEL ON CITY STREETS AT SPEED LIMITS WHEN A "POPPING" SOUND WAS HEARD AND TRUCK WOULD NOT TRAVEL OVER 25MPH. NO CABIN LIGHTS, NO INDICATION OF PROBLEM. IMMEDIATELY TOOK TO AUTOMOTIVE CENTER, FOUND NO ERROR OR TROUBLE CODES ON DIAGNOSTIC EQUIPMENT AND ALL FLUID LEVELS WERE FULL AND CLEAN. AUTOMOTIVE CENTER DISCOVERED FAILED TRANSMISSION WITH PIECES OF METAL IN TRANSMISSION COOLER AND LINES DURING TRANSMISSION FLUSH USING FACTORY RECOMMENDED SOLUTION. FACTORY DEFECT OF TRANSMISSION, ENGINEERING DEFECT FOR LACK OF CABIN WARNING LIGHTS AND MAINTENANCE DIAGNOSTIC EQUIPMENT.

WHILE DRIVING AT SPEEDS OF 5 TO 15MPH WHEN THE BRAKE IS ENGAGED THE TRUCKS ENGINE WILL REV AND PULL THE TRUCK FORWARD. THE ONLY WAY TO STOP IS TO PUT IT IN N AND PUMP THE BRAKES, THIS WILL STOP THE ACCELERATION.

WHILE DRIVING ON THE FREEWAY AT 75MPH A WARNING LIGHT CAME ON SAYING TRANSMISSION FAULT. THE OVERDRIVE LIGHT WAS FLASHING. THE TRUCK CONTINUED TO DRIVE NORMALLY BUT THE WARNING INDICATORS KEPT GOING ON. THERE WERE NO CODES WHEN IT WAS TAKEN TO THE SHOP ALTHOUGH THE SHOP SAID THEY HAVE A RETAINING CLIP THAT WEARS OUT AND CAUSES ALL THE PARTS TO SHIFT. THIS RESULTED IN HAVING TO REPLACE THE TRANSMISSION. FORD NEEDS TO RECALL THE DEFECTIVE PARTS. MANY OTHER F 150 OWNERS HAVE HAD THE SAME PROBLEM. TRANSMISSION REPLACEMENT COST MORE THAN I BOUGHT THE TRUCK FOR! *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 3 MPH, THE CONTACT HEARD AN ABNORMAL NOISE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE DRIVESHAFT WAS FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVESHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.

STARTED TO ACCELERATE OUT OF A PARKING LOT AND HEARD A LOUD THUMPING SO I PULLED OVER GOT OUT LOOKED AT THE DRIVESHAFT SEEN IT HAD SLID BACK. A BIT OUT OF THE TRANSMISSION ALSO OUT OF THE CARRIER BEARING. *TR

GEAR SLIPPED OUT OF PARK AS I WAS EXITING VEHICLE. I HAD NOT YET CLOSED THE DOOR AND THE TRUCK BEGAN TO MOVE DOWN THE DRIVEWAY. I WAS CAUGHT BY THE DOOR AND DRAGGED ALONG UNTIL THE DOOR THREW ME TO THE GROUND, INJURING MY BACK. THE TRUCK CAME TO REST ON BOTH OF MY LEGS. I WAS ABLE TO PULL OUT MY LEFT LEG EASILY RESULTING IN JUST A FEW CUTS, SCRAPES AND PARTIAL BLACK AND BLUE SPOTS. WOUNDS ALL HEELED THEMSELVES. HOWEVER MY RIGHT WAS THOROUGHLY PINNED AND I HAD TO PULL LONG AND HARD TO REMOVE IT FROM UNDER THE TIRE RESULTING IN LOST FLESH AT MY ANKLE BONE TO RIGHT BELOW MY KNEE AND ABOUT 4 TO 5 INCHES WIDE. *TR

I HAVE A 2007 F150 SUPERCREW CAB TRUCK. I WAS DRIVING DOWN A PARKING LOT WHEN THE TRUCK MADE A HUGE GRINDING SOUND FROM THE TRANSMISSION. I THEN RECEIVED A TRANSMISSION MALFUNCTION WARNING LIGHT. THE TRUCK SLAMMED INTO A STOP CAUSING DRIVER AND PASSENGER TO BE TOSSED FORWARD. I HAVE READ ONLINE OF SEVERAL OTHERS HAVING THE SAME PROBLEMS WITH THE 2007 F150 TRANSMISSIONS. FORD CLAIMS NO DEFECTS ON THIS MODEL YEAR. YET ON THE INTERNET THERE ARE SEVERAL FORD OWNERS WITH SAME TRANSMISSION ISSUES WITH TRUCK. FORD NEEDS TO RECALL THIS TRANSMISSION ASAP BEFORE SOMEONE GETS HURT BAD. I AM THE ORIGINAL OWNER WITH NO ACCIDENTS WITH TRUCK. TRUCK IS LOW MILEAGE. *JS

ON THE ABOVE LISTED DATE, WHILE DRIVING IN RUSH HOUR TRAFFIC IN A BUSY METROPOLITAN CITY MY DRIVE SHAFT CENTER SUPPORT BEARING ALLOWED THE DRIVE SHAFT OF MY 2007 FORD F150 TO SLIP BACKWARDS COMPLETELY DETACHING FROM THE TRANSMISSION. LUCKILY, MY SPEED AT THAT TIME WAS ONLY 10-15MPH. WHEN CALLING THE FOR DEALERSHIP TO INQUIRE ABOUT REPLACING THE PART OR ADVISE THE SALES PERSON WAS ONLY INTERESTED IN SELLING ME AN ENTIRE DRIVE SHAFT AND ADAMANTLY STATED THE PART IN WHICH I WAS SEARCHING WAS NOT OBTAINABLE IN NO POSSIBLE WAY. AFTER SEARCHING FOR THE EXACT PART ON FORD'S PARTS WEBSITE I DID LOCATE THE INDIVIDUAL PART ALLOWABLE FOR ORDER ONLINE. MY MAIN CONCERN AT THIS TIME IS THERE WAS NO REGARD FOR THE TREMENDOUS SAFETY HAZARD OF THIS PARTICULAR DEVICE OR PIECE OF EQUIPMENT, MOREOVER THERE WAS MORE CONCERN WITH OBTAINING A LARGER SELL. AFTER READING ONLINE I HAVE FOUND OTHER ISSUES WITH THIS EXACT DEVICE OR PARTS PERTAINING TO IT'S FUNCTION BUT THERE DOES NOT SEEM TO BE ANY RECALL OR INVESTIGATION REGARDING THESE MATTERS. I AM ONLY ADDRESSING THIS ISSUE BECAUSE OF THE DEFINITE SAFETY RISKS THAT ARE AT HAND AND TO ADVISE TO OTHER OWNERS OF THIS YEAR MAKE AND MODEL TO HAVE YOUR VEHICLE INSPECTED FOR THIS POSSIBLE SAFETY HAZARD. ALSO, TO THE FORD MOTOR COMPANY, BEING A MASSIVE ENTITY IN THE VEHICLE DEVELOPMENT AND SALES INDUSTRY I WAS APPALLED TO LEARN OF NO EXISTING INVESTIGATIONS IN THIS MATTER. PLEASE, FOR THE SAFETY OF THE FAMILIES DRIVING YOUR PRODUCT ALONE WITH MY FAMILY AS WELL, PLEASE TAKE AN INITIATIVE IN FURTHER INVESTIGATING THIS MATTER. THANK YOU, SATISFIED BUT DISSATISFIED CUSTOMER. *TR

ON 08/14/13 I WAS AT A BANK IN THE CITY OF FAIRFIELD CA. 94533, THERE WAS AN ACCIDENT IN THE PARKING LOT, WHICH IS A 1 DIRECTION ENTRANCE, MYSELF AND SEVERAL VEHICLES HAD TO BACK OUT OF THE LOT. AS I PRECEDED TO ACCELERATE TO EXIT THE LOT, I HEARD A LOUD THUMP. THE NEXT THING I KNEW WAS I WAS UNABLE TO MOVE. I EXITED MY VEHICLE AS OTHERS WHO WERE IN THE PARKING LOT OF THE BANK APPROACHED ME AND ASKED IF THAT WAS MY DRIVE SHAFT HANGING DOWN. WHEN I BENT DOWN TO LOOK I NOTICED THAT IT HAD BROKEN AT THE WELD AT THE YOKE OF THE TRANSMISSION. WHEN I RETURNED HOME AFTER BEING TOWED, I WENT ON LINE TO SEE OF ANY OTHER SITUATIONS OF DRIVE SHAFTS BRAKING ON FORD TRUCKS, AND I HAVE FOUND SEVERAL, WHICH ONE BROKE AND THE DRIVER LOST CONTROL AND HAD AN ACCIDENT WITH MASSIVE VEHICLE DAMAGE. I WENT TO THE LOCAL FORD DEALER, AND THEY SAID THEY HAVE NO RECALLS WITH THAT ISSUE. BUT FORD HAS HAD SEVERAL COMPLAINTS OF A LOUD THUMPING WHEN THE VEHICLE IS BEING PLACED IN GEAR WHICH IS ALL A RESULT OF DRIVELINE AND DRIVE TRAIN PROBLEMS. MY CONCERN IS THAT IF I HAD BEEN TRAVELING AT HIGHWAY SPEEDS AND THIS HAD HAPPENED, THE DRIVE-LINE WOULD HAVE DUG INTO THE ASPHALT AND PERHAPS FLIPPED MY TRUCK. KILLING MYSELF AND PERHAPS OTHERS. I ALSO CALLED FORDS CUSTOMER CARE CENTER IN MICHIGAN, BUT THEIR RESPONSE IS THAT THERE HAS BEEN NO COMPLAINTS OR RECALLS. TO WHICH I INFORMED THE REPRESENTATIVE THAT THERE WERE SEVERAL BLOGS ON LINE OF PEOPLE HAVING DRIVE-LINE PROBLEMS ON THE FORD F150 TRUCKS. I WAS IN A PARKING LOT BACKING UP WHEN MY INCIDENT OCCURRED BUT WHAT HAPPENS WHEN IT OCCURS ON THE HIGHWAY WITH CHILDREN IN THE VEHICLE. I AM NOW PRESENTLY WITHOUT A VEHICLE UNTIL I AM ABLE TO HAVE REPAIRS DONE AND I HAVE A $600 MONTHLY CAR NOTE. I FEEL THAT THIS IS A DEFECT THAT FORD NEEDS TO BE RESPONSIBLE FOR TAKING CARE OF. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED WHILE DRIVING 70 MPH THE VEHICLE BEGIN TO STALL AND SHAKE. THE CONTACT PULLED ONTO THE SIDE OF THE ROAD. THE CONTACT SHUT THE OVER DRIVE FUNCTION OFF AND WAS ABLE TO CONTINUE DRIVING. THE CONTACT STATED THE DEFECT CAME FROM THE POWER TRAIN. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR A LOCAL MECHANIC FOR A DIAGNOSTIC TEST. THE FAILURE MILEAGE WAS 55,522.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 50 MPH THE ELECTRONIC ALL WHEEL DRIVE SHIFTED FROM TWO WHEELS TO FOUR WHEEL DRIVE INDEPENDENTLY. THE CONTACT STATED THAT THE TWO FRONT TIRES LOCKED UP WHEN THE FAILURE OCCURRED. THIS CAUSED THE VEHICLE TO SLIDE TO A STOP. AS A RESULT OF THE FAILURE, THE DRIVE TRAIN SPLIT IN HALF. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT SPORADICALLY, THE GEAR SHIFTER COULD NOT BE MOVED OUT OF PARK. THE CONTACT NOTICED ALUMINUM SHAVINGS AROUND THE GEAR SHIFTER AND TOOK THE VEHICLE TO THE DEALER. THE DEALER ADVISED THAT THE GEAR SHIFTER WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 87,000.

VEHICLE SHAKES AT LOW SPEED VIOLENTLY. DID RESEARCH ON THE WEB THIS IS A COMMON PROBLEM WITH FORD TRUCKS. STORIES OF GETTING THE RUN AROUND FROM THE DEALER FOR SHAKING NEW TRUCK TO EXPENSIVE REPAIRS THAT DIDN'T REMEDY THE PROBLEM. I'M A FAMILY MAN WITH 6 KIDS AND LIMITED MEANS WHICH MEANS I WILL ATTEMPT TO FIX THIS MYSELF BECAUSE I CAN'T AFFORD A PRO-TECH TO TELL ME THE SHAKING IS NORMAL FOR FORD TRUCKS AS IN THE STORIES POSTED ALL OVER WEB DATING BACK SEVERAL YEARS. I'M STILL PAYING FOR MY TRUCK FOR ABOUT ANOTHER YEAR $647.00 A MONTH BOUGHT IT NEW IN 07 ZERO DOWN WHICH IT SEEMS THAT I WILL END UP WITH ZERO. WIFE AND KIDS CAN'T RIDE IN THE TRUCK UNTIL I FIX IT BECAUSE SHE HAS DONE SOMETHING IN ONE DAY THAT IT SEEMS IS TAKING YOU GUYS SEVERAL YEARS TO DO. SHE DEEMED OUR FAMILY CAR UNSAFE AND DANGEROUS. OH WELL I SUPPOSE THERE MIGHT BE A CERTAIN AMOUNT A PEOPLE THAT HAVE TO DIE FIRST BEFORE THIS AGENCY ACTS. I REMEMBER THE ROLL OVER TIRE THING. LETS HOPE I'M NOT ONE OF THEM BECAUSE THAT WOULD LEAVE MY WIFE ON THE HOOK FOR REST OF THE TRUCK PAYMENTS SHE'S A GREAT STAY AT HOME MOTHER BUT THAT'S NOT GONNA PAY OFF THIS TRUCK MC SHAKY. I BET THAT LAST PART MADE YOU SMILE.WISH ME LUCK AND DO YOUR JOB. I GOTTA GO TRY TO DO MINE. *TR

WHILE DRIVING AT A 15 MPH (1000 RPMS) TRUCK WOULD KNOCK AND TRY TO STALL WHEN COMING TO A STOP AND ALMOST CAUSE AN ACCIDENT. I WOULD HAVE TO PRESS THE GAS PEDAL TO KEPT IT FROM STALLING OR PUT INTO NEUTRAL AND PRESS THE GAS TO KEEP IT FROM STALLING. TOOK IT TO FORD DEALERSHIP ON 4/24/2007 AND THEY SAID THAT THE CAM PHASERS WERE THE PROBLEM OF MY ENGINE TRYING TO STALL. AS I DID MY RESEARCH ONLINE THIS SEEMS TO BE A BIG PROBLEM WITH THE 5.4L 3 VALVE ENGINES FROM FORD. *TR

DRIVELINE HAS BEEN VIBRATING AT 55 MPH FOR MONTHS. FORD SERVICE TOLD ME IT WAS THE TIRES, SO I PUT A NEW SET OF TIRES ON MY 2007 F150 KING RANCH SUPERCREW. STILL NOT THE PROBLEM. HAD IT CHECKED OUT BY THE TIRE SHOP AND THEY SAID IT WAS THE DRIVELINE NEEDED REBALANCING. THE TRUCK IS ONLY 4 YEARS OLD AND SHOULD NOT BE DOING THIS. PROBLEM STARTED ABOUT 50000 MILES - OUT OF WARRANTY OF COURSE. A RECALL SHOULD BE INSTATED FOR FORD TO CORRECT THE ISSUE. *TR