2005 Ford F-350 Electrical System

Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.

THE INSTRUMENT CLUSTER AND RADIO CUT OUT FREQUENTLY WHILE THE VEHICLE IS RUNNING. THIS CAUSES THE SPEEDOMETER, TACHOMETER, FUEL GAUGE, THERMOSTATS, AND ODOMETER TO SHOW THERE IS NO POWER TO THEM AND THE NEEDLES RESTS AS THEY DO WHEN THE VEHICLE IS OFF. THE RADIO ALSO CUTS OUT DURING THIS TIME. THIS HAPPENS WHEN THE VEHICLE IS STATIONARY, MOVING, ON CITY STREETS, AND ON HIGHWAYS. THERE IS NO WARNING WHEN THIS HAPPENS. IT WILL STAY OFF FOR SECONDS TO MINUTES. CURRENTLY THERE IS NO RECALL FROM FORD. THERE IS INFORMATION ON THE INTERNET CONCERNING OTHERS WITH THE SAME PROBLEM SO THIS IS NOT A SINGLE VEHICLE ISSUE. I AM CURRENTLY UNABLE TO GET A STATE VEHICLE SAFETY INSPECTION DUE TO THE INSTRUMENTS NOT FUNCTIONING PROPERLY.

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY STALLED. AFTER, RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MATTHEWS FORD, 1101 WEST SW. EXPRESS DR., BROKEN ARROW, OK) WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL WIRE HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM), ALTHOUGH IT EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 45,000. *TT *JS

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART. THE CONTACT HAD THE VEHICLE TOWED. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR WAS IT DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO FILE A COMPLAINT IN AN ATTEMPT TO HAVE THE VEHICLE INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

AUG 1, 2014 FUEL INJECTION FAILURE, DUE TO FUEL INJECTION WIRE HARNESS CHAFING. SEPT 15 FUEL INJECTION FAILURE DUE TO FICM FAILURE RESULTING IN SEVERE LOSS OF POWER. VEHICLE BARELY MOVES, STRONG POSSIBILITY OF CRASH DUE TO VEHICLES UNEXPECTED SUDDEN LOSS OF POWER AND INABILITY TO MOVE. INCIDENTS CLOSELY RELATE TO RECALL 05V270000 FOR VEHICLE MANUFACTURED CLOSE TO SAME DATES. BELIEVE THAT RECALL SHOULD BE REOPENED AND EXTENDED TO INCLUDE ALL 6.0 DIESEL ENGINES. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHEN DRIVING AT HIGHWAY SPEEDS, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO RESTART AFTER STALLING. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO REPLICATE THE FAILURE. THE CONTACT WAS MADE AWARE ABOUT NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM), HOWEVER DID NOT VERIFY WITH THE MANUFACTURER IF THE VEHICLE WAS INCLUDED. THE FAILURE MILEAGE WAS 137,000.

TL* THE CONTACT OWNS A 2005 FORD F-350SD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND COULD NOT BE RESTARTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FUEL INJECTOR CONTROL MODULE NEEDED TO BE REPLACED. THE CONTACT WAS ALSO ADVISED THAT THE VEHICLE WAS NOT INCLUDED NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 212,000. *TR

MY HUSBAND WAS DRIVING THE TRUCK AFTER SEVERAL REPAIRS AND TURNED ONTO THE HIGHWAY AND THE TRUCK ELECTRICAL SYSTEM JUST SHUT DOWN! WE CONTACTED THE DEALERSHIP THEY DIDN'T HELP WE HAVE PUT OUR OWN MONEY IN THIS TRUCK TO FIX IT AND WAS TOLD THIS TRUCK SHOULDN'T HAVE BEEN SOLD TO US THAT IT WAS A LEMON PER THE MASTER MECHANIC! I DON'T KNOW WHAT TO DO THIS TRUCK IS A HAZARD TO DRIVE AND WHEN I SPOKE WITH THE DEALERSHIPS OWNER HE TOLD ME TO BRING IT BACK AND THEY WILL SELL IT IN THE AUCTION AGAIN. ITS A DANGER AND CAN'T BE FIXED I HAVE ALL REPORTS ON WHAT WAS DONE ON THIS TRUCK. *TR