2005 Ford F-350 Engine

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE MISFIRED AND CAUSED THE STEERING WHEEL TO SEIZE. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO IMMEDIATELY STOP. THE VEHICLE WAS TAKEN TO FORMULA FORD LINCOLN (4318 MIDDLE RD, RUTLAND, VT 05701, (802) 773-9168) WHERE THE CAM PHASERS WERE REPLACED; HOWEVER, THE FAILURE RECURRED AFTER 176 MILES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 65 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. LATER, THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT A FAILURE CODE COULD NOT BE FOUND. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE CONTACT HAD THE VEHICLE TOWED TO HIS HOME. A DIAGNOSTIC APPOINTMENT WAS SCHEDULED WITH GUESS FORD (457 STEUBENVILLE RD SE, CARROLLTON, OH 44615, (330)-627-7666). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS; THEREFORE, THE CONTACT WOULD HAVE TO PAY IN FULL FOR THE REPAIRS. THE FAILURE MILEAGE WAS 76,000. *TT CONSUMER STATED THIS WAS THE SECOND TIME IT STALLED. UPDATED 12/03/18*JB

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT MANAGED TO COAST TO AN EMERGENCY LANE. THE VEHICLE WAS RESTARTED. HOWEVER, THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 74 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT FOUR INJECTORS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

THE TRUCK WOULD SHUT OFF WHILE DRIVING. NOTHING WILL WARN THE DRIVER WHEN THIS HAPPENS. I HAVE SPENT MORE THAN $1500 AT A FORD DEALERSHIP AND IT STILL HAS THE SAME PROBLEM. THIS IS A VERY DANGEROUS PROBLEM BECAUSE THE POWER STEERING AND BRAKES WILL NOT FUNCTION WHEN THE ENGINE SHUTS OFF. *TR

TOWING UP A GRADE AT ABOUT 35 MPH LOSS ALL POWER. UPDATED 11/24/2014 *JS

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE HEAD GASKET, OIL COOLER, AND EGR COOLER WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 73,233. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT THE CONTACT WAS TOLD THAT NO CAUSE FOR THE FAILURE WAS FOUND. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 99,000.

WHITE HEAVY SPOKE, LOSS OF POWER, PERFORMANCE, ENGINE STALLED ON MAJOR HIGHWAY AN EXTREMELY DANGEROUS SITUATION. DEALER STATED NOT FORD OR THEIR PROBLEM. CHARGES CLOSE TO $1,500 TO REPAIR. DEALER CLAIMS FAILED EGR VALVE.

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE ACCELERATING INTO TRAFFIC AT 15 MPH. THE FAILURE HAD RECURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO THE CONTACT'S PERSONAL MECHANIC AND HAD BEEN DIAGNOSED WITH NO FAILURES. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT HER VEHICLE WAS NOT PART OF A RECALL. THE CONTACT WAS THEN ADVISED TO CONTACT NHTSA. THE FAILURE MILEAGE WAS 115,000 AND CURRENT MILEAGE WAS 120,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 40 MPH, THE CONTACT NOTICED THE SMELL OF COOLANT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE EGR OIL COOLER WAS REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 81,000. UPDATED 9/13/10 *CN UPDATED 09/27/10

TL* THE CONTACT OWNS A 2005 FORD F350. THE CONTACT STATED THAT THE EGR OIL COOLER FAILED AND NEEDED REPLACING. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE DUE TO THE VEHICLE BEING OUTSIDE OF FACTORY WARRANTY. THE VEHICLE WAS NOT BEEN REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE TRAVELING 15 MPH THE CONTACT NOTICED THAT THE ENGINE HAD BEGAN TO RUN HOT AND WAS MAKING A WHINING NOISE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE HEAD GASKET AND EGR COOLER HAD TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 60000.

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING BETWEEN 50-55 MPH, THE VEHICLE SHUT OFF COMPLETELY AND THE POWER STEERING AND BRAKES FAILED. THE CONTACT STATED THAT FORD SHOULD PAY FOR THE REPAIRS BECAUSE THE FAILURE WAS A MAJOR SAFETY ISSUE. THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE CURRENT AND FAILURE MILEAGES WERE 194,947.

TL*THE CONTACT OWNS A 2005 FORD F350. THE MOTOR IN THE VEHICLE CONSTANTLY FAILS. WHILE TOWING A FIFTH WHEEL AT APPROXIMATELY 65 MPH, THE TURBO CHARGER BLEW OUT. THE DEALER INSTALLED A NEW TURBO CHARGER UNDER WARRANTY. APPROXIMATELY THREE MONTHS LATER, THE FAILURE RECURRED AND THE MOTOR OVERHEATED WHILE DRIVING APPROXIMATELY 65 MPH. THE VEHICLE WAS TOWED TO A LOCAL DEALER AND THEY TESTED THE MOTOR AND REPLACED TWO HEADS, THE OIL COOLER, AND THE EGR VALVE. THE MECHANIC ADVISED HIM TO NOT USE STRETCH VOLTS TO PREVENT THE FAILURE AGAIN. THE CONTACT WAS INFORMED THAT NON STRETCH VOLTS WOULD INCREASE THE CHANCES OF THE FAILURE NOT RECURRING BECAUSE IT WAS A BETTER PRODUCT THAN WHAT THE MANUFACTURER USED. THE CONTACT DID NOT WANT TO PAY ADDITIONAL MONEY FOR AN AFTERMARKET PRODUCT BECAUSE HE BELIEVED THAT THE PRODUCTS USED BY THE MANUFACTURER SHOULD WORK PROPERLY. AFTER THE REPAIRS WERE MADE, THE VEHICLE WORKED WELL FOR LESS THEN A MONTH. THE VEHICLE IS NOT CURRENTLY WORKING. HE ATTEMPTED TO TURN ON THE VEHICLE, BUT THERE WAS NO POWER TO THE MOTOR. THE VEHICLE WILL BE RETURNED TO THE SHOP FOR MORE REPAIRS. THE CONTACT FEELS THAT THIS IS A MANUFACTURER DEFECT THAT SHOULD BE RECALLED. THE FAILURE MILEAGE WAS 27,000 AND CURRENT MILEAGE WAS 30,000.

2005 F-350 WITH OVERHEATING PROBLEMS CUSTOMER STATES THAT THE ENGINE WAS REPLACED CUSTOMER WANTS FORD TO PAY FOR REPAIRS**CC THE CONSUMER STATED HE HAS HAD PROBLEMS WITH THE VEHICLE FROM DAY ONE. IT WAS AT THE DEALERSHIP FOR 25 DAYS FOR AN ENGINE REPLACEMENT. THE ENGINE WAS REPLACED, HOWEVER 90 DAYS LATER THE CONSUMER STARTED TO HAVE PROBLEMS WITH THE REPLACEMENT ENGINE. THE AIR TAKE TO THE TURBO WOULD BLOW OFF AND LEAVE THE VEHICLE WITH NO POWER, 2 EGR VALVES WERE REPLACED. FINALLY, THE ENGINE LOCKED UP. THE CONSUMER STATED THERE IS A DESIGN FLAW WHERE THERE IS TOO MUCH HEAT WITH THE TURBO ON TOP OF THE ENGINE. *JB

DT*: THE CONTACT STATED THE VEHICLE'S ENGINE REVVED UP WHEN STARTING UP, AND WHEN PUT INTO FIRST GEAR, THE ENGINE JERKED PROFUSELY. THE VEHICLE WAS TAKEN TO THE DEALER WHO UPON EXAMINATION COULD NOT DUPLICATE THE PROBLEM. THE MANUFACTURER WAS CONTACTED, AND DETERMINED THAT THERE WAS NO RECALL ON THIS ISSUE.