2002 Ford Focus Electrical System

REAR RIGHT PASSENGER DOOR WILL NOT UNLOCK/OPEN. WHEN TRYING TO UNLOCK I DON'T HEAR THE SOLENOID MOVING. WHEN TRYING TO OPEN FROM EITHER INSIDE OR OUT IF FEELS LIKE THE HANDLE ISN'T MOVING ANYTHING.

HATCH SWITCH FAILED .GHOST ELECTRICAL PROBLEM HAVING WIPER COME ON AT TIMES.WIRING HARNESS INSIDE RUBBER BOOT LOCATED WHERE HINGES BETWEEN HATCH AND VEHICLE BODY DEVELOPE BARE AND BROKEN WIRES. FOUND THIS AFTER CHECKING ALL FUSES AND SWITCHES. THIS IS APPARENTLY COMMON AS SEEN ON YOU TUBE AND SEEMS TO HAVE BEEN PREVIOUSLY REPORTED. PLEASE REPLY AS TO WHY THERE HAS BEEN NO RECALL. SURELY DEALERS HAVE ENCOUNTERED THIS DEFECT. LIKE ONE INDIVIDUAL SAID HIS DOG COULD HAVE FLEW OUT THE REAR GOING 70. NOT TO MENTION FIRE.MINE BLEW NO FUSES. *TR

EVER SINCE I HAVE HAD THIS CAR AND SINCE THE WARRANTY RAN OUT IN 2005, I HAVE NOTHING BUT REPAIRS. FIRST, THE RADIO NEEDED TO BE REPLACES, THEN THE BRAKES, THEN THE LOCKS ON BOTH DOORS AND THEN THE BRAKES AGAIN, HIGH BEAM LIGHT NEVER GOES OFF, ALWAYS ON AND NOW THE RADIATOR. THIS CAR IS 12 YEARS OLD, HAS LESS THAN 50,000 MILES ON IT AND IT HAS BEEN NOTHING BUT TROUBLE. I LIVE ON A LIMITED INCOME AND CANNOT AFFORD ALL THESE REPAIRS AND FORD COULD CARE LESS. IF I EVER BUY ANOTHER CAR, IT WILL NOT BE A FORD. THIS IS WHY THE NAME STANDS FOR: FIX OR REPAIR DAILY. I AM NOT ASKING FOR MONEY BUT IF YOU WANT TO THROW SOME MY WAY THANKS AND IF NOT THANKS. *TR

IGNITION CYLINDER IN STEERING COLUMN IS FROZEN. KEY INSERTS BUT WILL NOT TURN AT ALL. CANNOT START THE CAR, SHIFT INTO NEUTRAL, ETC. *TR

ALTERNATOR PULLING TO MUCH FIRE FROM THE BATTERY. *TR

DECKLID WIRING HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE HINGE. SIMILAR TO NHTSA RECALL ID# 00V411000. CONSEQUENCES: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH. *TR

HAVING INTERMINENT ELECTRICAL ISSUES. WOULD START UP AND RUN FINE FOR A PERIOD OF TIME, THEN THE 2002 FORD FOCUS WOULD JUST STOP RUNNING. AS TIME PASSED THE ISSUE GREW WORSE, NOW THE FOCUS WILL NOT RUN AT ALL. THE DEALERSHIP COUD NOT DUPLICATE THE PROBLEM AND COULD NOT FIX IT. *TR

I DROVE MY FORD FOCUS ABOUT 6 MILES TO A STOP LIGHT. WHEN IT TURNED GREEN, I PRESSED THE GAS. THE CAR STALLED LIKE IT WAS OUT OF GAS, REGAINED PARTIAL POWER, AND DISPLAYED THE AIRBAG LIGHT. IT MADE IT TO THE NEXT STOPLIGHT, AND I PULLED IT OVER TO THE SIDE AND TURNED IT OFF AND REMOVED THE KEY. AT THAT POINT A PLUME OF WHITE SMOKE SHOT OUT OF THE DRIVER'S SIDE HOOD. I TOLD MY SON TO GET OUT BECAUSE I KNEW THE CAR WAS ON FIRE. WE WALKED AWAY, AND AS WE DID, THE AMOUNT OF SMOKE INCREASED EXPONENTIALLY. WITHIN MINUTES, THE FRONT END OF THE CAR WAS TOTALLY ENGULFED IN FLAMES. THE WINDSHIELD SHATTERED AND MELTED, THE HOOD WAS CHARRED AND BLACK, THE PLASTIC PARTS OF THE FENDERS AND BUMPERS MELTED AWAY, AND PART OF THE BODY METAL BURNED AWAY ON THE HOOD AND THE FENDERS. EVERYTHING UNDER THE HOOD WAS MELTED, DISTORTED, OR OTHERWISE DESTROYED. I KEPT THE CAR VERY WELL MAINTAINED, MAKING SURE TO FIX EVERYTHING THAT WAS EVER WRONG WITH IT IMMEDIATELY UPON DISCOVERY. I KEPT UP ON ALL OIL CHANGES. IT IS PERPLEXING THAT A CAR WHICH IS SO WELL KEPT WOULD SPONTANEOUSLY SELF-IGNITE, HOWEVER THERE HAVE BEEN ACCOUNTS OF FIRES IN THE FORD FOCUS SINCE 2000, AND MANY SINCE. NOW I HAVE ADDED ONE MORE. THE CAR, OBVIOUSLY, IS A TOTAL LOSS. *TR

KEY WOULD NOT TURN IN THE IGNITION LOCK CYLINDER. IGNITION KEY COULD BE INSERTED ALL THE WAY INTO THE LOCK CYLINDER, BUT KEY WOULD NOT TURN FORWARDS OR BACKWARDS TO EITHER ENGAGE THE STARTER OR TURN ON ACCESSORIES. TRIED MOVING THE STEERING WHEEL TO FREE UP THE CYLINDER AND MADE SURE THE CAR WAS IN PARK TO TRY AND TURN THE CYLINDER. NOTHING. WAS TOLD BY THE AAA MECHANIC THAT THIS IS A COMMON ISSUE WITH EARLY MODEL YEAR FORD FOCUSES. THE ISSUE, PER THE AAA TOW TRUCK OPERATOR COULD BE TEMPORARILY RESOLVED BY USING SOME WD40 ON THE KEY AND A COUPLE OF QUICK TAPS TO THE KEY WHILE IN THE LOCK CYLINDER. THIS FIX DID NOT WORK AT THIS TIME. HAD TO HAVE MY CAR TOWED TO THE DEALER SINCE THIS WAS NOT A FIX I COULD MAKE ON MY OWN (I COULD REPLACE THE CYLINDER MYSELF, BUT THE CAR'S PASSIVE ALARM WOULD NEED TO BE RE-SET BY THE DEALER). RESULTING CHARGE WAS $378.50 FOR A PART I COULD HAVE FIXED FOR $60-70. MY LOCK CYLINDER NEEDED TO BE RE-KEYED BY THE LOCAL FORD DEALER. SAFETY ISSUE: COULD HAVE BEEN STRANDED. CAR FAILURE OCCURRED ON VERY COLD DAY. *JS

I HAD MY 81 YEAROLD MOTHER WITH ME, I TURNED OFF THE CAR AND WHEN I TRIED TO START IT THE KEY WOULD NOT TURN. IT WAS NOT UNTIL 5 DAYS LATER THAT MY MECHANIC SON IN LAW WAS ABLE TO LOOK AT IT AND TELL ME THE PROBLEM AND THAT A FORD GARAGE HAD TO FIXIT. THEIR PRICES VARY FROM 350.00 TO 450.00 TO REPLACE MY IGNITION SWITCH ASSEMBLY. IT IS A 48.00 PART. FORD REFUSES TO RECALL BECAUSE THEY CLAIM IT IS NOT A SAFETY ISSUE. IT IS IF SOMEONE HAS A HEART ATTACK OR A STROKE BECAUSE OF THE STRESS OF BEING STRANDED IN THE MIDDLE OF NOWHERE OR BECAUSE IT IS OVER 100 DEGREES AND YOU CAN'T WALK TO A PHONE OR TURN ON THE AIR CONDITIONER. NOT EVERYONE HAS A CELL PHONE. IT IS COVERED UNDER WARRANTY BUT THE PROBLEM DOES NOT OCCUR UNTIL IT IS OUT OF WARRANTY AND IT HAS TO BE REPAIRED EVERY TIME BY FORD. IT IS A SAFETY HAZARD ESPECIALLY FOR THE ELDERLY. *TR

TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT ATTEMPTED TO START THE IGNITION NUMEROUS TIMES HOWEVER, THE IGNITION KEY FAILED TO TURN IN ANY DIRECTION. THE KEY WAS EVENTUALLY RELEASED FROM THE IGNITION SWITCH. THE CONTACT PLANNED TO HAVE THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

BATTERY CABLES SHORTED OUT CAUSING SMALL FIRE ON BATTERY CABLES AND MELTING ON BOTH BATTERY CABLES. *TR

TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE PARKED, THE VEHICLE IGNITED INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE MASSIVE FLAMES AND INFORMED THE CONTACT THAT THE FIRE ORIGINATED WITHIN THE BATTERY. THE VEHICLE WAS DECLARED AS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

I HAVE HAD MY 2002 FORD FOCUS FOR 2 MONTHS. THE KEY HAS ALWAYS GAVE ME PROBLEMS WITH NOT WANTING TO TURN. TODAY THOUGH I WENT TO GO TO MY COLLEGE CLASSES AND THE KEY WILL NOT TURN AT ALL. I HAVE TRIED TO GET IT TO TURN FOR 2 HOURS. UNTILL I SAID [XXX] IT BEFORE I BREAK THE KEY AND THAT I HAD ALREADY MISSED MY CLASS THAT I COULDN'T MISS BECAUSE OF A TEST. NOW I GET A ZERO. I LIKE FORD VEHICLES BUT IF THEY CANT EVEN FIX A SMALL IGNTION DEFECT FOR THIER CUSTOMERS[XXX] FORD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

AT 69,411 MILES MY 2002 FORD FOCUS BATTERY CABLE WAS DEFECTIVE AND HAD TO BE REPLACED. THERE WERE BATTERY CABLE RECALLS ON OTHER FORD FOCUSES FOR THIS PROBLEM THAT CAUSED FIRES. OF COURSE FORD WOULD NOT PAY FOR MINE. *TR

KEY WILL NOT TURN IN THE IGNITION, THEREBY PREVENTING THE CAR FROM STARTING. *TR

TL*THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT ATTEMPTED TO START THE VEHICLE BUT THE KEY WOULD NOT TURN WITHIN THE IGNITION SWITCH. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE AUTHORIZED DEALER WAS NOTIFIED AND THEY INFORMED THAT THE IGNITION SWITCH WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 59,000.

TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING AT SPEEDS OF 30 MPH, THE VEHICLE WOULD NOT SHIFT GEARS. THE VEHICLE FELT AS IF IT WAS ATTEMPTING TO STALL. IN ADDITION, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER WAS CONTACTED AND ADVISED THERE WAS NOTHING WRONG WITH THE VEHICLE. THE VEHICLE WAS DIAGNOSED BY A SECOND MECHANIC WHO ADVISED REPLACING THE ALTERNATOR. THE ALTERNATOR WAS PREVIOUSLY REPLACED A TOTAL OF 3 TIMES. THERE WERE NO ADDITIONAL REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 83,000. UPDATED 8/9/10 *CN UPDATED 08/11/10.*JB

TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT WHEN THE KEY WAS IN THE IGNITION, IT WOULD NOT TURN THE ENGINE ON. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE CYLINDER AND THE KEY SWITCH AT THE CONTACTS EXPENSE. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE WITH THE FAILURE. THE VEHICLE WAS BEING REPAIRED BY THE DEALER. THE FAILURE MILEAGE WAS 22,000. UPDATED 1/21/11 *CN THE KEY WOULD NOT TURN THE IGNITION. THE DEALER REPLACED THE IGNITION LOCK CYLINDER UPDATED 04/18/11

WE JUST RECENTLY BOUGHT THIS CAR (2002 FORD FOCUS) AND SO I DO NOT KNOW THE HISTORY OF IT, HOWEVER THE CAR JUST STARTED LOCKING UP OUT OF NOWHERE. THE FIRST TIME IT HAPPENED WAS WITH MY HUSBAND AND LUCKILY HE DID NOT HAVE ANY OF OUR CHILDREN WITH HIM. THE IGNITION KEEPS LOCKING AND WE HAVE TO KEEP ON HAVING IT TOWED HOME. WE HAVE HAD THIS CAR FOR ABOUT 2 AND 1/2 MONTHS AND SO FAR IT HAS HAPPENED 4 TIMES. SO WE HAVE HAD TO PAY $160 IN TOWING COSTS. WE HAVE A FRIEND THAT SOMEHOW FIXED IT AND MY HUSBAND SPENDS HOURS OUTSIDE MESSING WITH IT TO GET IT WORKING. THIS TIME IS WONT START AT ALL AND ITS THE WORST TIMING EVER WE HAVE A PREMATURE BABY AND 4 OTHER CHILDREN THAT NEED TO GET TO SCHOOL AND DAYCARE. *TR

FAULTY IGNITION IN 2002 FORD FOCUS WAS STRANDED FOR FIVE HOURS HAVE NOT YET FIXED THE PROBLEM DUE TO FORDS HIGH COST TO FIX THERE DEFECT. *TR

KEY IS STUCK IN IGNITION, VEHICLE WILL NOT START. MY SON WAS STRANDED. *TR

FORD FOCUS ZX5 2002 POWER CUT OUT COMPLETELY WHILE I SAT IN VEHICLE WITH AIR CONDITIONING RUNNING; SMOKE BILLOWED OUT FROM UNDER THE HOOD. I TURNED OFF THE IGNITION IMMEDIATELY AND PULLED THE KEY OUT OF THE IGNITION. THE CAR IGNITION TURNED THE VEHICLE BACK ON ALL BY ITSELF. THE CAR BEGAN TO RUMBLE AND SMOKE SPEWED FROM UNDER THE HOOD EVERYWHERE. I JUMPED OUT OF THE VEHICLE AND GRABBED MY TWO DOGS FROM THE BACK SEAT. I RAN INTO THE LAWN CARE BUSINESS AND ANNOUNCED "MY CAR IS ON FIRE -- CALL 911." TWO EMPLOYEES CAME OUT, ONE WITH A FIRE EXTINGUISHER; THE OTHER ASKED ME FOR THE IGNITION KEY WHO JUMPED IN THE VEHICLE AND TRIED TO TURN THE CAR IGNITION OFF--THE CAR IGNITION WENT OFF BUT TURNED ON AGAIN EVEN AFTER THE KEY HAD BEEN REMOVED. HE PULLED THE HOOD LATCH SO THE OTHER EMPLOYEE WITH THE EXTINGUISHER COULD USE THE FIRE EXTINGUISHER. WHEN THAT PERSON OPENED THE HOOD, FLAMES SHOT EVERYWHERE. THE FIRE DEPARTMENT AND POLICE CAME. THE FIRE DEPARTMENT SAID THAT THE CAR WOULD HAVE EXPLODED WITHIN 2 MINUTES HAD THE EMPLOYEES NOT USED THE FIRE EXTINGUISHER. THE FIRE DEPARTMENT SPRAYED THE VEHICLE WITH ADDITIONAL FIRE RETARDANT AND STATED THAT THE VEHICLE IS "TOTALED." *TR

I OWN A 2002 FORD FOCUS ZX5 WAGON, THE BRAKE LIGHTS STAY ON CONSTANTLY WHILE I'M DRIVING, REGARDLESS IF I'M PRESSING ON THE BRAKE OR NOT. THIS IS A HUGE SAFETY PROBLEM AS THE BRAKE LIGHTS ARE NO LONGER FUNCTIONAL IF THEY ARE CONSTANTLY ON. THERE SEEMS TO BE A RECALL ON THE 2000 FORD FOCUS ON A DECKLID WIRE HARNESS, HOWEVER THIS SHOULD BE EXPANDED TO COVER ALL THE FORD FOCUS HATCHBACKS/WAGONS AS THE PROBLEMS ARE STILL EVIDENT BEYOND THE 2000 YEAR. I'VE HAD THIS PROBLEM SINCE AUGUST 2010 AND NOW SEPTEMBER 2010 I'VE FINALLY FOUND THE PROBLEM TO BE THE EXACT PROBLEM AS THE RECALL IN THE YEAR 2000 MODELS. THERE SHOULD BE AN INVESTIGATION ON THIS ISSUE, IT'S VERY DANGEROUS TO BE DRIVING WITH THE BRAKE LIGHTS ON AT ALL TIMES. THIS DEFECT NEEDS TO BE RECALLED ASAP. *TR

I HAVE 2002 FORD FOCUS THE IGNITION OR STARTER IS GIVING ME PROBLEM THE CAR WANT START AT TIMES I GET STRANDED SOMETIMES IT TAKES OVER FIVE MINUTES TO GET STARTED. *TR