2012 Ford Focus Steering

Steering system failure light came on and the Rack and pinion failed with no warning while I was driving on the highway at 75mph and the steering wheel locked up almost causing a potential fatal accident.

I was driving to drop my fiancé off at work when the "Steering fault, Service now" warning came on. Went home, parked the car. Start it up to go pick him up later, the wheel locked and "Steering loss, stop safely" warning came on. I just recently had my car inspected and had two new lower ball joints replaced. The one employee said my cars steering was working fine, and it was driving okay with no issues until today. Same thing just happened. You can't turn the wheel.

Experienced abrupt electrical steering motor failure. Power steering remains inoperable and available for inspection. Occurred during normal driving without warning, and effort required to manually steer was too much for my wife necessitating an emergency stop to avoid collision with oncoming traffic while trying to execute a routine turn putting us and the other vehicle in danger of an offset collision. This appears to be a known issue in FORD steering units but has only been addressed in Fusion models as a recall. The component has yet to be inspected as Ford will not pay for the repair despite the obvious ongoing safety issue, the vehicle will remain off the road for now in the hopes a recall is issued.

Power steering light intermittently comes on and vehicles looses power steering. Upon turning vehicle off then back on power steering will come back on. Can't get it to act up long enough for mechanic to diagnose. Only a matter of time before an accident happens. There are hundreds of complaints online about this same issue. Ford has issued some recalls but not on my particular VIN...

Received Steering Assist Fault message. Vehicle has lost power steering ability without warning causing a safety issue

I was traveling on a Highway on my way home and as I was turning in a curve at around 40 mph all of a sudden a message came up on my dash that steering assist fault which I didn’t know at the time I was to busy trying not to wreck my steering wheel locked In place coming out of the curve which put me in to the other lane of travel and eventually into a ditch and and thank god not into another vehicle, if there is not some kind of safety recall or major issue that should be a recall the governor or someone should address this immediately I was lucky I did not die. 1. So the system that failed is steering assist fault & yes it is available for inspection. 2 my safety and anyone else that was traveling in oncoming lanes life was in serious risk. 3 the problem is still there can’t get the steering to move to take it anywhere safely. 4 No it has not been inspected by anyone other than my brother to tow it home for me. 5 There was no warning lamps or malfunctions or symptoms at all until the incident happened the steering locked up I heard a tone and when I finally came to a stop these words where on the center dash display. Steering Assist Fault Service required.

the car steering wheel first said steering fault and then after parking and less than 10 minutes, car hood was still warm, after car turned back on it said steering loss stop safely. this is after over $1300 in repairs and new tires went into the car, same day with less than 2 hours of servicing. The steering wheel in the car can no longer move at all. Not sure what to do at this point. After a few hours of research learned this was a common issue but there has been no recall. Car no longer worth the money or time. Ford used to be reputable but now it has gone down the drain even Ford mechanics don't know what to think or do.This needs to be addressed and fixed.

The contact owns a 2012 Ford Focus. The contact stated that while driving and exceeding 25 MPH, the steering wheel was seized. The vehicle was driven to an independent mechanic, and the contact was informed that the power steering needed to be replaced. The vehicle was not taken to a dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 90,000.

My son was driving vehicle to work when the power steering assist failure light came on and the steering became difficult. He was in traffic and this could have very easily caused and accident as the car is now very hard to steer. Have not had it looked at yet because from what I have seen the cost to repair is well over $2000 and I don't have that kind of money laying around.

While driving vehicle power steering went completely out and warning message displayed. Control of car was difficult due to know power steering. No prior problems with steering before. have not had problem diagnosed as mechanics are all booked weeks out.

My power steering went out so my rack and pinion needed replaced and my car is only at 85,000 miles. This is a manufacturer error on ford's part and would like it to be looked into.

I had just came home after driving on the interstate to and from a family event. I wasn’t home but approximately 15 minutes and got an emergency call about a death in my immediate family. I started my car and the steering wheel wouldn’t move! It still didn’t move if you put it in gear! It was totally disabled and I was thankful that this didn’t happen while driving. Especially on the interstate. I had several children with me on that trip, whom along with myself, could have been severely injured or killed! I later found out that Ford recalled the 2012 Ford Fusion, but not the 2012 Ford Focus for the exact same steering loss issue. This should be against the law and Ford needs to be held accountable for this issue for the Ford Focus as well!

The contact owns a 2012 Ford Focus. The contact stated that on two separate occasions, the power steering assist failed with the "Service Power Steering Now" message displayed. The contact's husband used excessive force to drive the vehicle to a dealer where he was informed that the steering rack needed to be replaced. The manufacturer was notified of the failure and informed the contact that the vehicle was not under recall. The contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 52,000.

Power steering went out after a repair to the transmission control module.

The contact owns a 2012 Ford Focus. The contact stated while driving 30-35 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact was able to veer across a parking lot. The contact stated after investigating the failure online, she turned off the vehicle for a moment. The contact then restarted the vehicle while turning the steering wheel and the vehicle responded as needed; however, the failure reoccurred increasingly while driving. The message "Loss of Power Steering Assist" was displayed. The vehicle was towed to an independent mechanic, where it was diagnosed that the electronic power steering rack and pinion and outer tie rod needed to be replaced. The contact related the failure to Ford Campaign Number: 15S08. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 50,000.

On April 29, 2023 our 2012 Ford Focus SE with a 5 speed manual transmission indicated a dashboard warning stating the power steering assist was inoperable. Steering was still able to be done manually, but with much greater input required, especially at low speeds. Being a manual transmission, this is especially problematic as steering regularly has to be performed one handed. Fortunately this incident did not occur while driving, but reviewing many other similar complaints on the NHSTA website, as well as seaching '2012 Ford Focus steering issues' online, it is evident that this loss of assist CAN and HAS occurred to others when the vehicle was in motion. This poses a serious safety risk to not only the driver, but others on the road as well. This is an issue known to Ford Motor Company as they issued a recall (15S18) for similar problems on other Ford vehicles, but not the Focus. I am requesting the NHTSA investigate this situation and take action to compel Ford to fix the Focus as well under a recall to prevent similar situations from causing potential injury or death. I encourage one of your investigators to try driving one of these vehicles without the power assist to see just how dangerous it is, especially in low speed maneuvers. This car is primarily used by my son for his commuting to and from college. He is the one that first saw the warning. I am very thankful this did not happen while he was in motion. I will be contacting my dealer on Monday May 1, 2023 to start the diagnosis/repair process.

Power steering will go out intermittently. Known safety defect by Ford but they still have not issued a recall.

electric power steering works intermitently at low speed not safe when having to make turns or change lanes.

Electric power steering assist failed. Vehicle currently has no power steering. Problem confirmed by dealer who says steering rack needs replacement. Fairly common issue per online complaints. Ford issued recall on other models but not the Focus.

Power steering stopped working while driving at 65 miles per hour and wheel locked almost causing an accident. Power steering malfunction

The contact owns a 2012 Ford Focus. The contact stated while driving 15 MPH, the vehicle lost power steering functionality. The contact was able to pull over safely. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the Electronic Stability Programme (ESP) needed to be replaced. The manufacturer was not contacted. The failure mileage was 75,000.

The power steering quits working and has no power assist when driving down the road. You are not able to turn the vehicle at all and even get it off the road to a safe spot on the side of the road. It goes out even when trying to turn a corner and it starts to go head on into traffic putting other drives at rick of being hit by a car I can’t control.

When starting the car, the message displays "steering assist fault. Service required". The entire power assistance is not functional. The car can be manually steered under heavy effort. This issue came and went multiple times. Some times, the steering system started to work and all was good. Other times, there was no recovery. The last time the issue occured was while driving down the road. The message appeared and the power assist was gone. It has not come back online. It did not cause an accident as I was able to manually force the steering to do what I needed to exit the road safely. It appears reading online that the only recourse is to replace the entier system requiring the removal of the rack and pinon and the front assembly sub frame. Estimate costs are over $3000 and it must be done at Ford as it needs software to work correctly. This does not seem reasonable for a car with only 120,000 miles on it.

The contact owns a 2012 Ford Focus. The contact stated that while starting the vehicle, the steering wheel locked and she was unable to steer the steering wheel on three occasions. The warning letter "I "was illuminated. The local dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 60,000.

WHILE DRIVING HOME LAST NIGHT JUST AFTER EXITING THE HIGHWAY, MY STEERING WHEEL SUDDENLY BECAME STIFF AS IF IT WAS LOCKED. POWER STEERING FAULT LIGHT CAME ON. I HAD TO USE ALL MY MIGHT TO KEEP IT IN A STRAIGHT LINE JUST SO I CAN MAKE IT HOME.