2019 Ford Fusion ENGINE AND ENGINE COOLING,ENGINE

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an engine misfire, with the check engine warning light illuminated. The vehicle was able to restart. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into the engine, which caused engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 108,831.

The contact's wife owns a 2019 Ford Fusion. The contact stated that while his wife was pulling out of the driveway, the check engine warning light illuminated. Additionally, the contact stated that the temperature gauge quickly rose to hot(H). The vehicle was taken to the residence where coolant was added to the coolant reservoir. The failure reoccurred on several occasions and on one occasion the vehicle stalled. The vehicle was restarted after the engine had cooled down. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer where it was diagnosed that there was a crack in the engine due to coolant intrusion in one of the cylinders, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.

The contact owns a 2019 Ford Fusion. The contact stated that the vehicle was taken to the dealer for a recommended maintenance inspection; however, the contact stated that upon the technician inspecting the vehicle, the contact was informed that the engine short block needed to be replaced due to coolant intrusion into the engine. The vehicle was not repaired. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was out of warranty. The contact was informed to draft a letter for assistance. No further assistance was provided. The failure mileage was 119,000.

The contact owns a 2019 Ford Fusion. The contact stated while his daughter was driving approximately 40-45 MPH, the check engine warning light illuminated, and the vehicle went into LIMP mode. The contact stated that the vehicle failed to exceed 5 MPH. The contact's daughter pulled into a parking lot. The contact stated that he used an OBD reader to determine that cylinder #2 was misfiring. The vehicle was taken to the Chevrolet dealer where it was purchased, and was diagnosed with coolant intrusion into the engine, causing cylinder #2 to misfire. The contact was informed that the engine needed to be replaced. The vehicle was taken to a Ford dealer, where the diagnostic result was confirmed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 84,717.

The contact owns a 2019 Ford Fusion. The contact stated that the check engine warning light illuminated. The contact's friend used an ODB code reader and determined that there was a misfire in cylinder #3. The ignition coils were replaced; however, the failure persisted. The contact also discovered that the coolant level remained low. The vehicle was then taken to a dealer for a diagnostic test where it was determined that coolant had leaked into cylinder #3 and that the long block needed to be replaced. The manufacturer was notified of the failure. The vehicle was not repaired due to parts being on backorder. The failure mileage was approximately 76,000.

About a week or so ago I went out to crank my car and it sounded awful It was shuttering, sounded like it was going to shut off and the engine light came on, it's a 2019 Ford Fusion. I notice it does this every morning, well I took it to the dealer ship today, they said I have coolant leaking into the Engine.