1992 Ford Mustang Electrical System

TL* THE CONTACT OWNS A 1992 FORD MUSTANG. THE CONTACT STATED THAT HE EXPERIENCED DIFFICULTY IN TURNING THE KEY IN THE IGNITION ON MULTIPLE OCCASIONS. THERE WAS AN ABNORMAL CLICKING NOISE THAT WAS HEARD WHEN ATTEMPTING TO START THE VEHICLE IN ADDITION TO THE VEHICLE STALLING SPORADICALLY. THE FAILURE WAS RECURRING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS ADVISED THAT A CONNECTOR WIRE AND A FUSE LINK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE WAS NOT REMEDIED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 96V071000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. ADDITIONALLY, THE CONTACT NOTICED SMOKE FROM THE IGNITION AS THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED BACK TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE WIRE TO THE FUSE LINK WAS FRACTURED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,726.

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS AT AN INDEPENDENT REPAIR SHOP FOR A SHORT CIRCUIT WITH THE IGNITION SWITCH, THE CONTACT WAS INFORMED OF AN EXISTING RECALL FOR THIS DEFECT. THERE WAS A NHTSA RECALL #96V071000, REGARDING THE ELECTRICAL SYSTEM:IGNITION. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

CONSUMER WAS INSPECTING THE VEHICLE, SHE LIFTED UP THE HOOD, AND NOTICED THAT THE WIRE ATTACHMENT WAS UNRAVELING FROM THE ENGINE COMPARTMENT. CONSUMER WILL CONTACT THE DEALER IN THE NEAR FUTURE. *AK

VEHICLE EXPERIENCED AN ELECTRICAL FIRE. FIRE STARTED APPROXIMATELY 10 MINUTES AFTER VEHICLE WAS PARKED. DRIVER SMELLED SOMETHING BURNING COMING THROUGH THE VENTS. BATTERY AND ALTERNATOR, THAT WERE JUST RECENTLY INSTALLED, WERE LOST IN THE FIRE. VEHICLE WAS TOTALED. CONSUMER OBTAINED A FIRE DEPARTMENT REPORT. *AK

UPON STARTING VEHICLE IGNITION FELT VERY HOT, AND THE VEHICLE WOULD NOT START.VEHICLE WAS TOWED. *AK

THE VEHICLE EXPERIENCED THE SAME PROBLEM AS STATED IN RECALL 96 V 071 000. IGNITION ELECTRICAL SYSTEM SHORTED IN TURN SIGNALS.*JB

THE IGNITION SWITCH BECAME VERY HOT WHILE DRIVING AND INTERMITTENTLY SHORTED OUT. CONSUMER HAD TO "JIGGLE" IGNITION TO MAKE IT FUNCTION WHEN STARTING VEHICLE. ALSO, CONSUMER INTERMITTENTLY SAW SMOKE EMITTING FROM STEERING COLUMN WHEN STARTING CAR. RELATED RECALL 96V071000, HOWEVER VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL.

CONSUMER RECEIVED RECALL LETTER 96V071000 CONCERNING IGNITION SWITCH FAILURE. TOOK VEHICLE TO DEALER ,AND DEALER STATED THEY DID RECALL REPAIRS. CONSUMER FELT DEALER NEVER CHANGED DEFECTIVE PARTS BECAUSE CAR WAS RUNNING WHEN IT WAS TAKEN IN, AND CURRENTLY IT WAS NOT RUNNING. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

AFTER VEHICLE HAD BEEN TURNED OFF A FIRE STARTED AFTER DRIVER EXITED VEHICLE WHICH CONSUMED THE ENGINE AND PASSENGER COMPARTMENTS. NO DETERMINATION HAS BEEN MADE TO THE CAUSE OF THE FIR,E AND CONSUMER WAS INFORMED THAT VEHICLE WAS NOT INCLUDED IN RECALL 96V071000 DUE TO VIN. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK

FIRE BROKE OUT UNDER HOOD OF VEHICLE. FIRE DEPARTMENT INFORMED CONSUMER THAT IT WAS AN ELECTRICAL FIRE. CONSUMER WAS COMING TO A STOP LIGHT AT APPROXIMATELY 10 TO 15 MPH WHEN RADIO WENT OUT/BATTERY LIGHT CAME ON, AND THERE WAS A SMOKING/BURNING SMELL. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK

FAULTY IGNITION MODULE CAUSED VEHICLE TO STALL WHILE DRIVING LEAVING THE CAR WITH NO POWER, IT WAS REPLACED TWICE IN 2 YEARS. NLM

VEHICLE HAS STALLED 2 TIMES AND BOTH TIMES THE IGNITION MODULE WAS REPLACED, THIS FAILURE COULD HAVE CAUSED A SERIOUS ACCIDENT, THE FIRST FAILURE OCCURRED ON A HIGHWAY. *SLC

IGNITION SWITCH IS NOT WORKING. THIS FAILURE IS SIMILAR TO THE PROBLEM IN RECALL 96V71000. *AK

WHILE DRIVING BATTERY EXPLODED AND WHOLE VEHICLE CAUGHT ON FIRE. DEALER HAS VEHICLE NOW. *AK

ALTERNATOR OVERHEATED AND CAUGHT FIRE. MJS

NONE

INSTRUMENT PANEL WIRING HARNESS SHORTED OUT, RESULTING IN A FIRE. IN ADDITION, HEADLAMPS STOPPED FUNCTIONING. *AK

VEHICLE WAS IN THE PARK POSITION AND THE IGNITION WAS OFF, AND THERE WAS AND ELECTRICAL SHORT IN THE WIRING HARNESS, CAUSING THE VEHICLE TO CATCH ON FIRE IN THE CONSOLE AREA OF THE VEHICLE. CONSUMER HAS CONTACTED THE DEALER. *AK

WAS DRIVING AND THERE WAS A FIRE UNDER THE FRONT HOOD. *AK

WAS DRIVING AND SMELLED RUBBER BURNING, RESULTING IN VEHICLE CATCHING ON FIRE . *AK

THE VEHICLE CAUGHT ON FIRE WHILE PARKED DUE TO THE IGNITION SWITCH. PLEASE DESCRIBE. *AK

DRIVING CAR, SMOKE STARTED COMING FROM STEERING COLUMN, KEPT DRIVING, SMOKE BECAME HEAVIER, STOPPED CAR, JUMPED OUT, CAR CAUGHT FIRE, SOMEONE PUT FIRE OUT. *AK

THE VEHICLE CAUGHT ON FIRE DUE TO THE IGNITION SWITCH WHILE IT WAS PARKED. PLEASE DESCRIBE. *AK

IGNITION FIRE. *AK

IGNITION SWITCH CAUGHT FIRE. *SD