2016 GMC Sierra 2500 Steering

2016 Denali 2500 Diesel - Loose steering, like many of the others complaining. I only have 13,000 miles on the truck since I don't drive it during Ohio winters (salt) and use it to tow my 6500 lb boat. Doesn't feel safe at all when towing. The dealer explained both the pitman and idler arm were worn. $1500 repair bill. Very frustrating that GM doesn't cover this potential safety related issue regarding vehicle control/stability. Several versions of Technical Service Bulletin's exist #PIT5501D as an example.

STEERING BOX ADJUSTMENT SCREW BACKED OUT CAUSING EXCESSIVE SLOP IN THE STEERING WHEEL. THIS IS A WELL DOCUMENTED PROBLEM WITH THESE TRUCKS WITH GM'S SOLUTION IS TO ADD LOCKTITE AND TORQUE NUT. I BELIEVE THAT THIS IS A TEMPORARY SOLUTION AND IT COULD BACKOUT AGAIN. SHOULD HAVE A MECHANICAL LOCK TO PREVENT IT FROM BACKING OUT.

TL* THE CONTACT OWNS A 2016 GMC SIERRA 2500. WHILE DRIVING AT HIGH SPEEDS, THERE WAS A LOT OF PLAY IN THE STEERING WHEEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO DAVE SMITH MOTORS (210 N DIVISION ST, KELLOGG, ID 83837) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE OPERATED AS INTENDED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 43,000.

TRUCK STEERING IS VERY DANGEROUS. 4-8 INCH PLAY IN THE WHEEL LEFT AND RIGHT. YOU HAVE TO TURN THE WHEEL 4' EITHER WAY FOR IT TO RESPOND. THE DEALERSHIPS DON'T HAVE A FIX FOR THIS AND THERE ARE 1000 OF THREAD POSTS ON THIS ISSUE. THIS EXACT ISSUE. PEOPLE ARE GOING TO DIE IF THIS IS NOT FIXED PROPERLY AND RECALLED BY GM. THE DEALERSHIPS ARE PUTTING LOCTITE ON THE STEERING G BUT TO PREVENT IT FROM BACKING OUT BUT THIS DOES NOT LAST. IT HAPPENS AGAIN ONLY 1000S OF MILES LATER. GOING DOWN THE ROAD I ALMOST ENDED UP IN THE WOODS BECAUSE MY STEERING WOULD NOT RESPOND. NIGHTMARISH.

STEERING HAS EXCESSIVE PLAY BEFORE TIRES RESPOND. THIS HAS BEEN CASE SINCE A COUPLE THOUSAND MILES ON VEHICLE. HARD TO KEEP TRAVELING IN STRAIGHT LINE. ALWAYS HAVING TO CORRECT, ESPECIALLY WITH 17K FIFTH WHEEL IN TOW.

VEHICLE HAS BEEN INTO GMC DEALERSHIP SERVICE FACILITY FIVE TIMES, IN THE SPAN OF 3 MONTHS. ALL SERVICE/MAINTENANCE HAS FOCUSED ON LOOSE STEERING AND UN-COMMANDED VEHICLE PULL. ISSUE REOCCURS IMMEDIATELY FOLLOWING SERVICE. FIRST ISSUE WAS EXTREMELY NON-RESPONSIVE STEERING, WHERE I COULD MOVE THE STEERING WHEEL MULTIPLE INCHES IN EITHER DIRECTION WITH NO MOVEMENT OR REACTION FROM THE VEHICLE. COMPOUNDED WITH STEERING WHEEL HAD TO BE HELD OFF OF CENTER TO MAKE VEHICLE TRAVEL STRAIGHT. GMC DEALERSHIP SERVICE TECHNICIAN PERFORMED GM RECOMMENDED FIX, WHICH DID NOT RESOLVE THE ISSUE. RETURNED VEHICLE TO GMC DEALERSHIP SERVICE DEPARTMENT, WHERE THEY FOUND THE STEERING GEAR, STEERING BOX AND PITMAN ARM TO BE DAMAGED AND THUS REPLACED ALL ITEMS. THIS DID NOT FIX THE ISSUE. RETURNED THE VEHICLE TO THE SERVICE DEPARTMENT, WHERE THEY FOUND NOTHING WRONG, AND RELEASED THE VEHICLE BACK TO ME THE CONSUMER WITH THE PERSISTENT STEERING ISSUE. THE STEERING IS LOOSE. THE WHEEL CANTS TO THE RIGHT IF IT IS LET GO OF, AND WHEN RETURNED TO CENTER, THE VEHICLE PULLS TO THE LEFT. TOOK THE VEHICLE TO A DIFFERENT DEALER, AND ASKED THEM TO INSPECT THE STEERING AND SUSPENSION COMPONENTS. THE DEALERSHIP TEST DROVE THE VEHICLE, NOTICED THE RIGHT OFF CENTER CANT, ALONG WITH THE LEFT PULL, YET FOUND NOTHING VISUALLY WRONG WITH THE STEERING OR SUSPENSION. THEY ARE REFUSING TO FURTHER DIAGNOSE THE ISSUE AS THEY CLAIM THEIR VISUAL INSPECTION FOUND NOTHING WRONG, YET WHEN DRIVING THE VEHICLE THERE IS A NOTICEABLE STEERING ISSUE. 2016 GM HEAVY DUTY TRUCKS HAVE THIS AS A KNOWN ISSUE, YET GM HAS NOT ACKNOWLEDGED IT OR CREATED A SOLUTION. THIS IS A HIGHLY UNSAFE CONDITION, WHERE THE STEERING IS UNRESPONSIVE, AND VEERS THE VEHICLE IN UN-COMMANDED DIRECTIONS.

2016 GMC SIERRA 2500 HD. CONSUMER WRITES IN REGARDS TO DEFECTIVE STEERING. *LD THE CONSUMER STATED THE VEHICLE WAS REPAIRED UNDER THE INSTRUCTION OF A SERVICE BULLETIN. THE CONSUMER REQUESTED TO REIMBURSED FOR THE REPAIRS. *JS

STEERING IS NOT TIGHT AND HAS A LOT OF SLOP BEFORE THE TIRES ACTUALLY TURN. GM DEALER IDENTIFIED A BAD STEERING BOX AND FOLLOWED TSB PIT5501F TO DETERMINE THERE IS A DEFECT.

TL* THE CONTACT OWNS A 2016 GMC SIERRA 2500. THE CONTACT STATED THAT THE STEERING HAD EXCESSIVE SLACK WHEN TURNING THE WHEEL. THE VEHICLE WAS TAKEN TO A DEALER WHO REPLACED THE PITMAN SHAFT AND PERFORMED FURTHER DIAGNOSTIC TESTING. THE MECHANIC DROVE THE VEHICLE AND THE FAILURE CONTINUED. THE CONTACT WAS WAITING ON A SOLUTION FROM THE MANUFACTURER. THE MANUFACTURER ISSUED FOUR TECHNICAL SERVICE BULLETINS, BUT NO RECALL YET TO ADDRESS THE REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 1,000.

STEERING WHEEL VERY LOOSE, CAN MOVE 3-4 INCHES WITHOUT ANY STEERING TAKING PLACE.