2002 Honda CR-V Engine

I AM ASKING YOUR ASSISTANCE WITH A PROBLEM WITH MY HONDA CRV. I TOOK MY HONDA IN FOR THE AIRBAG RECALL ON SEPTEMBER 1, 2015. WAS TOLD IT WAS ACCOMPLISHED AND DROVE HOME IN THE EVENING TO DISCOVER THAT MY HONDA HAD NO OIL IN IT. (THE CHECKLIST PROVIDED BY THE SERVICE TECHNICIAN SHOWED THAT MY OIL WAS FINE.) NOT ONLY IS THE ABS LIGHT BACK ON BUT MY CAR HAS NOW DEVELOPED A THROTTLE ISSUE. A COPY OF MY SEPTEMBER 17, 2015 LETTER TO BOTH THE LOCAL HONDA DEALER AND THEIR CORPORATE OFFICES FOLLOWS.AT LEAST AS MUCH OF IT AS YOUR FORM ALLOWS. I HAVE NOT HAD THE COURTESY OF A RESPONSE FROM EITHER. SEPTEMBER 17, 2015 "HONDA CORPORATE OFFICES VIA FAX 310-783-3023 PRINCETON HONDA VIA FAX 609-683-1637 I AM SIMPLY GOING TO PRESENT THE FACTS. I DO NOT WANT ANY TELEPHONE CALLS. I WILL ACCEPT E-MAIL CORRESPONDENCE ON THE MATTER ONLY. ([XXX]) ON SEPTEMBER 1ST OF THIS YEAR, THE AIRBAG RECALLS FOR MY CRV WERE SCHEDULED TO BE EFFECTED. I RECEIVED A CALL THAT MY CAR WAS READY AT 8:30 IN THE MORNING. I PICKED MY CAR UP THAT EVENING AFTER WORK. ABOUT 7 MILES INTO MY 12 MILE TRIP HOME THE ENGINE BUCKED AND I LOST POWER. I WAS ABLE TO LIMP MY WAY HOME WHERE I PROMPTLY CHECKED THE OIL AND FOUND TO MY CHAGRIN THAT I THERE WAS NO OIL IN THE CAR. HOW THE OIL COULD HAVE BEEN FINE (ACCORDING TO THE INSPECTION CHECKLIST) AT 8 IN THE MORNING AND THEN EVAPORATE BY 7 PM FOR MY RIDE HOME RAISES MANY QUESTIONS. THE QUESTIONS RAISED RANGE FROM BENIGN TO MALICIOUS DEPENDING ON THE LEVEL OF ANXIETY I AM EXPERIENCING AS I DRIVE. I HAVE BEEN MONITORING MY OIL CONSUMPTION CAREFULLY AND THE CAR IS NOT BURNING OIL EGREGIOUSLY AT PRESENT. I HAVE NEVER BEEN ABLE TO AFFORD THE DEALER MAINTENANCE PRICES BUT I HAVE BOUGHT MY CAR TO OVER 244,000 MILES WITH WHAT CARE I COULD AFFORD TO GIVE IT. I HAD HOPED FOR AT LEAST 300,000 MILES, BUT I DO NOT KNOW HOW MUCH OTHER DAMAGE MAY HAVE BEEN CAUSED BY THIS EVENT." PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*CC

THE AC COMPRESSOR KNOCKS AS IF IT WANT TO COME OFF THE ENGINE. THIS HAPPENS WHILE DRIVING CAUSING TO JERK THE CAR FORWARD WHEN IT KICKS IN, THEN STOPS AND KICKS IN AGAIN SHORTLY THERE AFTER. THE CAR ALMOST STALLED OUT JUST BECAUSE OF THIS. THE ENGINE WORKS HARD AT KEEPING THE COMPRESSOR FROM SHUTTING THE CAR DOWN. ONE OF THESE DAYS IT WILL COME OF THE ENGINE. *TR

AC COMPRESSOR SEIZED AND BROKE APART WHILE DRIVING ON THE HIGHWAY. *TR

THE AC STARTED TO MAKE BANGING NOISE, THEN CEASED TO WORK. THIS STARTED AT ABOUT 100,000 MILES, JUST AFTER THE WARRANTY EXPIRED. IN 90-100 DEGREE WEATHER THIS IS EXTREMELY DANGEROUS -- I FIND MYSELF FALLING ASLEEP BEHIND THE WHEEL IN THE HEAT, EVEN WHEN WINDOWS ARE OPEN. I CAN'T AFFORD $2000+ FOR REPAIRS. APPARENTLY LOTS OF CR-V OWNERS ARE EXPERIENCING THIS PROBLEM WITH AC COMPRESSOR. HONDA SHOULD BE RECALLING THIS VEHICLE AND PAY FOR ITS REPAIRS. *TR

CRV WITH 45,000 MILES MADE LOUD GRINDING NOISE AND A/C STOPPED WORKING. OCCUPANTS COULD HAVE SUFFOCATED DUE TO LACK OF AIR CONDITIONING IN CAR AS MEDICAL CONDITIONS PREVENTED OCCUPANTS FROM OPENING WINDOWS. *TR

I HAVE A 2002 HONDA CR-V THAT HAD 135,000 MILES AT THE TIME THE COMPRESSOR IMPLODED. AMERICAN HONDA IS AWARE OF THE ISSUE. THE COMPRESSOR IMPLODES, SHOOTING SHARDS OF METAL THROUGHOUT THE AC SYSTEM, RESULTING IN EXPENSIVE REPLACEMENT OF PARTS OTHER THAN THE COMPRESSOR. ESSENTIALLY THE ENTIRE AC SYSTEM NEEDS TO BE REBUILT AT A COST IN THE NEIGHBORHOOD OF $2500-3500 (MY BILL CAME TO $3100). AMERICAN HONDA REFUSED TO PICK UP THE TAB ON ANY OF THE PARTS OR LABOR ASSOCIATED WITH THIS REPAIR. IF YOU GOOGLE "HONDA+AIR+COMPRESSOR+FAILURE" YOU WILL FIND MANY, MANY REPORTS OF THIS ISSUE, ALL REPORTED TO AMERICAN HONDA. *TR

AIR CONDITIONER FAILED COST IS 3000.00 TO FIX. *TR

AIR COMPRESSOR IN MY HONDA CR-V WENT OUT. NEEDS TO BE REPLACED. COST $3300. *TR

2002 HONDA CR-V WITH 98,000 MILES. DRIVING DOWN INTERSTATE WITH AC ON. STOPPED FOR GAS. GOT BACK ON INTERSTATE AND AC WOULD NOT BLOW COLD AIR; ONLY HOT AIR. DEALER SAYS COMPRESSOR BLEW APART AND SENT SHARDS OF METAL THROUGH ENTIRE AC SYSTEM. THEY SAY WHOLE AC SYSTEM NEEDS REPLACING NOW FOR $3,800. *TR

I AM THE ORIGINAL OWNER OF A 2002 HONDA CR-V WHICH HAS AN AIR CONDITIONER FAILURE AT 86,000 MILES. ALL COMPONENTS NEED TO BE REPLACED. IT WAS FIRST NOTICEABLE WITH A RATTLING NOISE UNDER THE HOOD - NEEDS COMPRESSOR, DRYER, RECEIVER, CONDENSER ETC REPLACED FOR AROUND $1000-2200 AT AN INDEPENDENT MECHANIC. DEALER IS APPROX. $2500-3500 WHICH I HAVE NOT PINNED DOWN YET. AM. HONDA WILL DO NOTHING. MILEAGE SHOULD NOT BE A FACTOR HERE; HONDA MANUFACTURED A DEFECTIVE PART AND SHOULD PAY THE ENTIRE REPAIR AMOUNT. I AM SURE IF AM. HONDA REP. WAS FACED WITH SAME SITUATION, HE WOULD BE DEMANDING PAYMENT AS WELL. HOPE FOR DEFINITIVE CLASS ACTION LAWSUIT. ALSO, OXYGEN SENSOR NEEDS TO BE REPLACED AND DOOR LOCKS WILL NO LONGER WORK THEREFORE YOU CANNOT LOCK THE CAR. HAVE REPLACED TAIL LIGHTS 3X IN A YEAR AND NOW HONDA SAYS IT NEEDS A SOCKET REPLACEMENT. THESE ARE VERY EXPENSIVE REPAIRS ON WHAT SHOULD HAVE BEEN A RELIABLE VEHICLE. *TR

A/C COMPRESSOR EXPLODED BRAKING THE SHAFT OFF OF THE COMPRESSOR AND SENDING SHARDS OF METAL THROUGHOUT THE AC SYSTEM. *TR

FAILURE OF THE AIR CONDITIONER COMPRESSOR. *TR

MY AUTO A/C WAS BLOWING HOT AIR. MECHANIC DETERMINED THE COMPRESSOR WAS FROZEN AND THE CLUTCH DAMAGED. REPAIRS WERE DONE AT A COST OF $1250.15. IT APPEARS TO BE AN ONGOING PROBLEM WITH CR-VS WHICH HONDA REFUSES TO ACKNOWLEDGE AS A DEFECTIVE PART. I HAVE RETAINED THE DEFECTIVE COMPRESSOR. *TR

VEHICLE IS 2002 HONDA CR-V WITH 44,300 MILES A/C COMPRESSOR HAD TO BE REPLACED AT GREAT EXPENSE. AFTER READING ALL THE POSTS ONLINE, IT APPEARS TO BE A DEFECT THAT HONDA REFUSES TO ACKNOWLEDGE. I WANT TO JOIN ANY CLASS ACTION LAWSUITS REGARDING THIS MATTER. *TR

I PURCHASED MY 2002 HONDA CR-V EX NEW & HAVE HAD ALL OF THE RECOMMENDED SERVICES PERFORMED BY MY LOCAL HONDA DEALER. AROUND 7/12/2006, MY A/C STOPPED WORKING AT 57,023 MILES. THE POWER SWITCH MADE A STRANGE CLUNKING NOISE & THE A/C FAILED TO START RIGHT AWAY. I IMMEDIATELY TURNED THE SWITCH OFF & BACK ON. THE FAN CAME ON, BUT ONLY BLEW OUT HOT AIR. I TOOK IT TO MY REGULAR HONDA DEALER & PAID $153.40 TO HAVE THEM CHECK THE A/C SYSTEM OUT. THE DIAGNOSIS WAS THE A/C SYSTEM WAS DEAD & IT WOULD COST ME ANOTHER $1,600 TO REPLACE THE COMPRESSOR, COIL SET & CLUTCH SET. I SHOPPED AROUND & HAD ANOTHER SHOP THAT ONLY WORKS ON HONDAS AND ACURAS DO THE SAME WORK RECOMMENDED BY MY HONDA DEALER AT A COST OF $1,203.52. THEY USED GENUINE HONDA PARTS TO MAKE THE REPAIR & GAVE A 12 MONTH, 12,000 MILE WARRANTY. MY CAR NOW HAS 95,000 MILES. ON 7/11/2009, MY A/C WAS WORKING FINE WHEN I PARKED MY CR-V. THE NEXT AFTERNOON, THE A/C WAS ONLY BLOWING WARM AIR WHEN I TURNED MY CAR BACK ON. I STARTED LOOKING ON-LINE TO SEE IF THERE HAD BEEN ANY RECALLS FOR THIS PARTICULAR PROBLEM. THAT IS WHEN I REALIZED I HAVE A SERIOUS PROBLEM ON MY HANDS. THERE ARE NUMEROUS COMPLAINTS FOR THE SAME PROBLEM. ON 7/30/2009, I CALLED AMERICAN HONDA TO SEE IF THERE WERE ANY RECALLS. THEY BASICALLY DO NOT ACKNOWLEDGE ANY PROBLEM. BECAUSE MY CAR IS OUT OF WARRANTY, THEY CAN'T DO ANYTHING FOR ME. I EXPLAINED THIS IS THE SECOND TIME IN 95,000 MILES THE A/C HAS GONE OUT. HE SAID THEY CAN'T HELP ME BECAUSE I DID NOT HAVE THE 1ST REPAIR DONE BY MY HONDA DEALER, EVEN THOUGH THE MECHANIC WHO DID THE WORK WAS CERTIFIED BY MACS & ASE IN REFRIGERANT RECYCLING & SERVICE PROCEDURES AND USED GENUINE HONDA PARTS. ON 7/30/2009, I TOOK MY CR-V TO MY HONDA DEALER TO GET AN ESTIMATE. THE COMPRESSOR IS DEAD AGAIN. THE ESTIMATE IS APPROX. $1,600 TO FIX IT. THE SERVICE MGR. IS GOING TO TRY TO WORK WITH HIS DISTRICT MANAGER TO SEE IF THEY CAN GET AMERICAN HONDA TO HELP ME. I AM STILL WAITING TO HEAR. *TR

THE AC AIR COMPRESSOR CLUTCH ON MY 2002 HONDA CRV FELL OUT WHILE I WAS COMING TO A STOP AT A LIGHT. FORTUNATELY, NO ONE WAS HURT. I DO NOT KNOW IF THERE WAS ANY OTHER DAMAGE TO THE CAR FROM THIS INCIDENT ESPECIALLY ANY OTHER INTERNAL COMPONENTS OR PARTS. I TOOK IT TO A HONDA DEALER. THEY WANT TO CHARGE ME OVER 1200 TO INSTALL NEW ONE AIR COMPRESSOR. I ASKED WHETHER THEIR WAS ANY RECALL ON THIS PART, THEY SAID NO BECAUSE IT DID NOT FALL UNDER EMISSIONS OR SAFETY. HE ALSO MENTIONED THAT SINCE I'M NOT THE ORIGINAL OWNER OF THE CAR AND IT HAS OVER 130,000 MILES, WARRANTY WON'T COVER IT. I'M GOING TO GET A SECOND OPINION FROM ANOTHER AUTO MECHANIC. *TR

WHILE DRIVING AT APPROX 45 MPH, THE ENGINE IN MY 2002 HONDA CR-V EX LOST POWER AND STALLED IN THE MIDDLE OF THE HIGHWAY. I WAS ABLE TO RESTART THE ENGINE AND GET IT TO THE SIDE OF THE ROAD WHERE IT STALLED AGAIN. I TRIED TO RESTART AGAIN BUT THE ENGINE COULD NOT TURN OVER. HAD CAR TOWED TO ACURA DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUG COULD NOT BE REMOVED FROM CYLINDER #3 AND THE ENGINE COULD NOT BE TURNED OVER. THE ENGINE HAD SEIZED. A COMPLAINT HAS BEEN FILED WITH HONDA AND THE CAR TOWED TO A HONDA DEALER FOR FURTHER INVESTIGATION. HAD I BEEN TRAVELING AT HIGH SPEED ON A LIMITED ACCESS ROAD THIS WOULD HAVE BEEN FAR MORE DANGEROUS AND MIGHT HAVE RESULTED IN SEVERE INJURY OR DEATH. *TR

ADD ME TO THE LIST OF OWNERS WHO SUFFERED A CATASTROPHIC HONDA CR-V AIR COMPRESSOR FAILURE. IT'S A 2002 WITH 136K MILES. IT'S IN BEAUTIFUL CONDITION, WELL KEPT BY PREVIOUS OWNERS. I WAS DRIVING TO WORK AND I HEARD A TINNY GRINDING SOUND. I PULLED OVER AND LIFTED THE HOOD. DIDN'T SEE ANYTHING WRONG. CONTINUED DRIVING, BUT NOTICED THE AC WAS BLOWING WARM AIR. I CALLED BANKSTON HONDA (THE CLOSEST DEALER TO ME IN COPPELL, TX), WHO DIAGNOSED THE PROBLEM. THEY TOLD ME IT WOULD COST $3,100 TO REPAIR, BUT THAT I SHOULD CALL AMERICAN HONDA AND OPEN A CASE WITH THEM, SINCE THEY MAY AGREE TO COVER SOME OF THE COST. APPARENTLY THIS IS A WIDESPREAD ISSUE, ONE THAT HONDA APPEARS TO BE IGNORING FOR THE TIME BEING (AT LEAST UNTIL THEY'RE HIT WITH A CLASS ACTION LAWSUIT). WITH 100 DEGREE WEATHER, A WIFE AND TWO CHILDREN, THERE IS NO WAY WE CAN SURVIVE WITH A CAR THAT DOESN'T HAVE AC. WE CHOSE A 2002 HONDA CR-V BASED ON INCREDIBLY CONSISTENT POSITIVE FEEDBACK (SAFETY, RELIABILITY, VALUE RETENTION, ETC.). SO FAR THIS HAS BEEN THE ONLY ISSUE. OUR FAMILY CAN'T AFFORD TO PAY $3,100 TO REPAIR THE AC. WE REALLY NEED AMERICAN HONDA TO STEP UP AND AT LEAST PAY FOR THE PARTS. AMERICAN HONDA HAVE GIVEN ME A CASE NUMBER (N012009-05-2601731) AND ASKED THAT I WRITE THEM TO EXPLAIN WHAT HAPPENED SO THEY CAN MAKE A DETERMINATION AS TO WHETHER THEY'LL COVER ANY OF THE COST. I HOPE THEY AT LEAST PAY FOR THE NECESSARY PARTS. IF THEY COME THROUGH, THEY'LL CEMENT THEIR REPUTATION AND I'LL CONTINUE TO RECOMMEND HONDA TO MY FRIENDS AND FAMILY. IF THEY CAN'T OFFER ANY HELP, I'LL NEED TO JOIN THE CLASS ACTION LAWSUIT TO TRY TO RECOUP SOME OF THE COST. THIS IS CLEARLY A WIDE SPREAD PROBLEM, ONE THAT HONDA WILL EVENTUALLY NEED TO OWN UP TO. I ENCOURAGE EVERYONE TO GO TO THIS URL AND FILE THEIR INFO, IF ONLY TO PRESSURE AMERICAN HONDA TO DO THE RIGHT THING: HTTP://WWW.HONDA-LAWSUIT.COM/ THANKS, DON MONTALVO COPPELL, TX 2002 HONDA CR-V (136K MILES). *TR

MY 2002 HONDA CRV 4WD, 81000 MILES, HAS A DEFECTED AC COMPRESSOR THAT IS LOCKED UP. AMERICAN HONDA KNOWS ABOUT THE PROBLEM WITH AC COMPRESSORS IN THE CRV 2002-2005 MODELS AND WILL NOT ISSUE A RECALL TO FIX THE PROBLEM. *TR

TL*THE CONTACT OWNS A 2002 HONDA CR-V. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THEY STATED THAT THE TIMING CHAIN WAS THE CAUSE OF THE FAILURE, THUS THE ENGINE NEEDED TO BE REPLACED. SECONDLY, BECAUSE THE CONTACT DID NOT FOLLOW THE WARRANTY AGREEMENT, THEY WOULD NOT ASSUME FINANCIAL RESPONSIBILITY FOR ANY REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 95,000.

ON A TRIP TO MERCED, CA.SUMMER OF 2008. MY 2002 HONDA CRV AIR CONDITION COMPRESSOR FAILED. IT REQUIRED REPLACED EVERY PART FOR ENTIRE A/C SYSTEM. THE SYSTEM FAILED WITHOUT ANY WARNING. TOTAL COST $3500. I DO THINK IF COMPRESSOR FAILED IT SHOULD NOT RUIN THE ENTIRE. THIS IS THE CLEAR CASE OF DEFECTIVE DESIGNED SYSTEM. *TR

I AM FILING A REPORT DUE TO OIL THAT WAS LEAKED ONTO THE EXHAUST SYSTEM OF MY CAR AND RESULTED IN MY CAR CATCHING ON FIRE. THIS DAMAGE HAS BEEN ATTRIBUTED TO OIL FILTER GASKETS THAT HAVE NOT BEEN PROPERLY REMOVED. I HAVE CONTACTED HONDA, AND THEY HAVE ONLY OFFERED TO PROVIDE ME WITH A LETTER EXPLAINING THAT IT IS BEST TO HAVE MY OIL CHANGE AT THEIR DEALERSHIP. I FEEL IT IS A MANUFACTURE DEFECT TO HAVE A CAR MODEL THAT IS PRONE TO OIL FILTER GASKETS STICKING, ONLY TO RESULT IN OIL LEAKAGES AND FINALLY CAR FIRES. SUCH PRACTICES ARE NOT ONLY DANGEROUS, BUT IT IS UNETHICAL TO MARKET A PRODUCT TO THE PUBLIC THAT POSES SUCH DANGER. FURTHERMORE, NOT ALL HONDA BUYERS ARE NOTIFIED. I BOUGHT MY HONDA USED, AND NEVER RECEIVE AND SUCH LETTERS OR UPDATES, BEING UNKNOWINGLY EXPOSED TO HARM. I'M OUTRAGED. *TR

WE HAVE A 2002 HONDA CRV. THE 1ST AIR COMPRESSOR LOCKED UP/BLEW UP AT APPROXIMATELY 70K MILES. THE EXTENDED WARRANTY COVERED THE REPLACEMENT. NOW THE 2ND COMPRESSOR HAS DONE THE SAME THING. EXTENDED WARRANTY HAS EXPIRED. COST IS $2300. HAVE READ THAT THIS YEAR OF CRV HAS DEFECTIVE COMPRESSORS. HONDA AMERICA OFFERED TO PAY 25% ($408) WHICH IS NOT ADEQUATE SINCE THIS IS OUR 2ND COMPRESSOR AND THE PRODUCT APPEARS TO BE DEFECTIVE (AS OPPOSED TO REGULAR WEAR AND TEAR). *TR

FAILURE OF A/C COMPRESSOR ON 2002 HONDA CR/V EX. COMPRESSOR FROZE WHILE IN TRAFFIC ON BUSY STREET CAUSING ENGINE TO STALL. MY WIFE HAD TO COAST, IN THE VEHICLE OVER TO THE SIDE OF THE STREET AND INTO AN OFF-STREET PARKING LOT. *TR

I WAS DRIVING HOME FROM WORK ON 7/17/08 AND HEARD A LOW GRUMBLING NOISE COMING FROM MY AIR CONDITIONING VENTS IN MY 2002 HONDA CRV. THIRTY SECONDS LATER THIS SOUND STOPPED AND ABOUT A MINUTE LATER ONLY HOT AIR CAME OUT OF THE VENTS. I'VE TAKEN THE CRV TO A NON HONDA REPAIR SHOP AND THEY ADVISED REPLACING THE AIR COMPRESSOR, CLUTCH, DRYER AND EXPANSION COIL FOR APPROX $1235. THE HONDA DELIVERSHIP ADVISED REPLACING THE ENTIRE COOLING SYSTEM FOR $3350 AND THEN OFFERED A 30% DISCOUNT ( GOOD WILL ) DROPPING THE REPAIR COST TO $2350. *TR