2001 Hyundai Santa Fe Electrical System

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CRANKSHAFT POSITION SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V030000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTE FE. THE CHECK ENGINE LIGHTS ILLUMINATED AND THE VEHICLE WILL NOT SHIFT PROPERLY. WHILE DRIVING 55 MPH AND SHIFTING GEARS,THE GEAR STUCK FROM FOURTH TO THIRD GEAR. THE CONTACT TURNED THE VEHICLE OFF. THE VEHICLE OPERATED NORMALLY ONCE IT WAS RESTARTED. THE FAILURE USUALLY OCCURRED DURING RAINY OR DAMP CONDITIONS. THE DEALER INFORMED THE CONTACT THAT THE FAILURE WAS DUE TO A CRACKED CRANKSHAFT. THE VEHICLE WAS INSPECTED, AND THE CRANKSHAFT WAS REPLACED ON MARCH 30, 2004. AFTER THE CRANKSHAFT WAS REPLACED THERE WERE NO OCCURRENCES UNTIL MAY 2005 AND AUGUST 2005, WHEN THE COIL WAS REPLACED. THE VEHICLE OPERATED NORMALLY UNTIL NOVEMBER 2006. THE CURRENT AND FAILURE MILEAGE WAS 88,000.*AK THE CONSUMER HAS PROVIDED A RECALL FOR THE ELECTRICAL SYSTEM PERTAINING TO THE CRANKSHAFT POSITIONER AND INVOICES FOR THE REPAIRS. THE DEALER STATED THAT THE SPEED SENSOR HAS BEEN REPLACED. UPDATE 5/3/07*TR

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH ON THE HIGHWAY, THE VEHICLE STALLED WITHOUT WARNING. IT WAS MANEUVERED OFF THE ROAD AND TOWED TO THE DEALER WHO REPLACED THE CRANK SHAFT POSITION SENSOR. THERE WAS A NHTSA RECALL, # 03V030000, REGARDING THE ELECTRICAL SYSTEM; STARTER ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

MY 2001 HYUNDAI SANTA FE HAD A VERY BAD ODOR LIKE WIRES WERE BURNING IN THE VEHICLE. WHEN THAT OCCURRED MY POWER DOOR LOCKS WOULD NOT WORK AND MY REAR WIPER WOULD NOT WORK. THE SMELL WAS SO BAD I HAD TO LOWER ALL THE WINDOWS SO I WOULD NOT PASS OUT. I STOP TO CHECK IF THERE WAS A FIRE. I TOOK IT TO THE DEALER WHO SAID THEY COULD NOT FIND ANY PROBLEM, BECAUSE IT DID NOT OCCUR WHEN THEY CHECKED IT. I WAS TOLD TO BRING THE CAR BACK IMMEDIATELY WHEN IT HAPPENS AGAIN. I WAS WONDERING IF THERE WERE ANY SIMILAR PROBLEMS WITH 2001 SANTA FE'S. *JB

DT:THE CONTACT STATED THE CPS CAPACITOR THAT IS WITH THE CRANK SHAFT POSITION SENSOR IS NOT WORKING PROPERLY AND AS A RESULT THE VEHICLE STALLED ON THE FREEWAY. THE DEALERSHIP RAN A DIAGNOSTIC TEST AND THIS PROBLEM CAME UP AS A CRITICAL CODE. THE CONSUMER FOUND NHTSA RECALL 03V030000 FOR THIS PROBLEM BUT THE DEALERSHIP TOLD HER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK UPDATED 2/7/2006 - *NM

IN DEC 04, JAN 05 AND FEB 05, MY 2001 HYUNDAI SANTA FE V-6, EXPERIENCED ARCING OF SPARK PLUG WIRES, REQUIRING THE WIRES TO BE REPLACED BY DEALER 3 SEPARATE TIMES. *JB

I HAD THE SAME PROBLEM WITH THE ELECTRICAL SYSTEM LIGHTS DIMMING WIPERS GOING SLOW RADIO GOING OFF ALSO WHEN I WENT THROUGH A PUDDLE IN THE RAIN SOMETHING GOT WET IN THE ENGINE AND STARTED TO SMELL .I WENT TO HYUNDAI IN MANHATTAN AND THEY FIXED THE PROBLEM. SO FAR SO GOOD KEEPING MY FINGERS CROSSED.*AK

I AM A MEDICAL PERSONNEL AND WORK NIGHT HOURS. I OWN A HYUNDAI SANTA FE 2001 AND HAVE ELECTRICAL PROBLEMS. THE CAR RUNNING BUT AT STOP CANNOT HANDLE HEADLIGHTS, HEATER, RADIO AND INTERNAL LIGHTS, WHICH IS A PROBLEM IF I WERE EVER STUCK. IT HAS HAPPENED IN SUMMER AND WINTER AND CAN BE DANGEROUS IF I'M STRANDED. I HAVE BROUGHT THIS VEHICLE TO 2 DIFFERENT HYUNDAI DEALERS AND THERE ARE NO PROBLEMS FOUND, YET I BROUGHT MY VEHICLE TO PEP BOYS AND SEARS AND THEY SAID MY BATTERY WAS FAILING. I REPLACED BATTERY AT SEAR'S 3 MONTHS AGO AND LIGHTS ARE STARTING TO DIM AGAIN. THE RESPONSE FROM HYUNDAI SERVICE DEPARTMENT WAS TO TURN OFF HEADLIGHTS? ISN'T THAT DANGEROUS? *LA

WHILE DRIVING ABOUT 55 MPH ON THE HIGHWAY AND WITHOUT WARNING VEHICLE WOULD STALL AND SHUT DOWN, AND WOULD NOT RESTART. THE SUV WAS TOWED TO THE DEALERSHIP FOR ANALYSIS. DRIVER PICKED UP THE TRUCK FROM THE DEALER THAT DAY, BUT WITHOUT WARNING THE SUV SHUT DOWN ON THE WAY HOME. *AK

FOR THE PAST MONTH, CAR HAS PROBLEMS STARTING. USUALLY, IT DOES NOT START FOR THE FIRST TIME OR IT HAS A SLOW START. IN ADDITION, THERE'S AN OCCURRENCE THAT IT DID NOT START AT ALL, WHICH HAD TO BE TOWED TO THE DEALER WHERE IN THEY REPROGRAMMED THE MODULE. WILL WAIT AND CHECK IF THIS FIXES THE PROBLEM BECAUSE THE CAR STARTS SLOWLY THAT MORNING. *LA

VEHICLE DASH BRAKE AND ALTERNATOR LIGHTS COME ON WHEN VEHICLE SPLASHES THROUGH WATER PUDDLES. ON ALL OCCASIONS I ALSO LOSE POWER STEERING CONSTROL. THE DEALER'S RESPONSE TO THE PROBLEM REPORTED IS SIMPLY NOT TO SPLASH WATER WHILE GOING OVER PUDDLES. THIS IS VERY DIFFICULT TO DO DURING THUNDER STORMS FOR WHICH TAMPA BAY IS WELL KNOWN. WATER IS OBVIOUSLY GETTING INTO THE ALTERNATOR AND WETTING THE POWER STEERING SYSTEM. ON ONE OCCASION I LOST POWER STEERING AS I WAS NEGOTIATING A RIGHT TURN. VERY DANGEROUS SITUATION. MR

BATTERY CHARGE INDICATOR SHOWED A LONG TERM "LOW" CHARGE LEVEL, AND DURING VERY HOT WEATHER, BATTERY FAILED TO START VEHICLE DUE TO ALTERNATOR NOT KEEPING BATTERY CHARGED UP PROPERLY.*AK

WILL LIKE THIS RESOLVED BY HYUNDAY AMERICA AS SOON AS POSSIBLE. NO SAFETY DEFEC TLISTED. *AK

OCCASIONALY AS I DRIVE AT NIGHT THE HEADLIGHTS WILL DIM, CLOCK WILL FLASH, AND THE WINDSHIELD WIPERS WILL SLOW DOWN BECAUSE THE ALERNATOR WILL NOT CHARGE THE BATTERY. OCCASIONALY WHEN I STOP AND TURN THE CAR OFF I WILL COME BACK OUT TO RESTART THE CAR AND IT WILL NOT START BECAUSE OF THE BATTERY BEING DEAD AND NOT BEING CHARGED BY THE ALTERNATOR. I HAVE ALREADY HAD THE BATTERY AND ALTERNATOR REPLACED ONCE ON 7/26/02 AND IT IS STARTING TO DO THE SAME THING AGAIN. I AM IN CONTACT WITH SEVERAL OTHER SANTA FE OWNERS AT WWW.SANTAFEFORUM.NET AND ALOT OF THEM ARE HAVING THE SAME PROBLEM.

FROM THE FIRST DAY WE PICKED UP THE VEHICLE (6-01-01) THE KEYS STUCK IN THE IGNITION & WE WERE NOT ABLE TO GET THEM OUT WITHOUT JIGGLING THE GEARSHIFT. THE VEHICLE WAS TAKEN INTO PATTERSON'S SERVICE DEPARTMENT ON 10-25-01, 3-1-02, 7-5-02, & 8-7-02, BUT THE PROBLEM WAS NEVER REPAIRED. ON THE LAST OCCASION THE SERVICE DEPARTMENT CAUSED AN EVEN GREATER PROBLEM TO OCCUR. EVIDENTLY THEY HAVE DISCONNECTED THE SAFETY MECHANISM WHICH KEEPS ONE FROM REMOVING THE KEY FROM THE IGNITION IN ALL GEARS EXCEPT PARK. NOW WE CAN TURN OFF THE VEHICLE AND REMOVE THE KEYS FROM THE IGNITION IN ANY GEAR. WHEN WE DROVE THE VEHICLE INTO OUR GARAGE THIS PAST FRIDAY, AUGUST 23RD, WE PUT THE GEARSHIFT INTO WHAT WE THOUGHT WAS PARK (THE SHIFTER WOULD NOT GO ANY FURTHER), TURNED OFF THE VEHICLE, REMOVED THE KEY FROM THE IGNITION AND STARTED GETTING OUT OF THE VEHICLE. THE VEHICLE STARTED ROLLING OUT OF THE GARAGE. IT TURNED OUT THE GEARSHIFT WAS IN REVERSE. THE VEHICLE IS DIFFICULT TO PUT INTO PARK NOW ESPECIALLY IF THE BRAKE PEDAL IS NOT FULLY DEPRESSED PAST THE NORMAL STOPPING TENSION. THE DEALER IS AWARE OF THE PROBLEM.*AK

THE FIRST TIME IT HAPPENED, WE WERE STOPPED AT LIGHT AND THE RADIO STARTED TO GO OUT AND THE CLOCK LIGHT DIMMED. WE TOOK IT TO THE LOCAL DEALERSHIP AND THEY REPLACED THE BATTERY (IT SAT ON THE SHIP TOO LONG AND DRAINED THE BATTERY). ABOUT A MONTH LATER, THE SAME THING HAPPENED AND THEY SAID THAT THE CONNECTIONS TO THE BATTERY WERE CORRODED AND THAT I MUST CLEAN THE CONNECTIONS EVERY 3K MILES...YEAH RIGHT! ANOTHER MONTH WENT BY AND THE DOME LIGHTS BEGAN FADING, THE CAR WAS VERY SLOW TO TURN OVER, AND THE A.C. WOULD BARELY WORK. THIS TIME THEY REPLACED THE ALTERNATOR. FINALLY, THIS WEEKEND, THE STUPID THING WOULDN'T TURN OVER, LEAVING MY WIFE AND 4 MONTH OLD CHILD STRANDED IN 95+ DEGREE TEXAS HEAT. THE DEALERSHIP HAS LEFT ME A MESSAGE RIGHT AT BUSINESS END TODAY STATING THAT THE "NEW" ALTERNATOR IS EXPECTED IN ON WEDNESDAY BUT THAT THEY HAVE "INTERESTING" NEWS TO REPORT ON THIS PROBLEM. I ANXIOUSLY AWAIT TO SEE WHAT THIS MIGHT BE. IT IS VERY FRUSTRATING TO HAVE OUR ENTIRE LIFE REARRANGED 4 TIMES, ESPECIALLY SINCE THIS IS A NEW VEHICLE. THE WORST PART IS THAT I LOVE THE WAY THE SANTA FE DRIVES, FEELS, LOOKS. JUST WISH I DIDN'T HAVE TO USE THE STUPID WARRANTY THIS MUCH. JUST HOPE THIS IS NOT HAPPENING TO EVERY SANTA FE OWNER AS I KNOW THESE CARS ARE BIG SELLERS! THANKS FOR THE OPPORTUNITY TO VENT!*AK

WHILE DRIVING AND WITHOUT ANY NOTICE WILL LOSE POWER, AND CONSUMER CAN NO LONGE ACCELERATE VEHICLE. CONTACTED DEALER. *AK

HYUNDAI WILL NOT REPLACE ALTERNATOR WITH HIGHER OUTPUT. *AK

THE CAR "MISSES" SO BADLY IT WILL NOT ACCELERATE. IN ADDITION, IT PERIODICALLY DIES WHILE IDLING. THIS VEHICLE HAS HAD NUMEROUS ELECTRICAL ISSUES. HYUNDAI HAS REPLACED THE ALTERNATOR AND THE BATTERY WITH HIGHER OUTPUT EQUIPMENT AND THE PROBLEMS HAVE WORSENED.*AK

VEHICLE WOULD NOT START WHEN LEAVING FROM DEALERSHIP AFTER PURCHASING, CAUSE ACCORDING TO DEALER WAS DEFECTIVE BATTERY. BATTERY WAS REPLACED. ELEVEN MONTHS LATER I EXPERIENCED ENGINE HAD SLOW CRANKING TO START AND LIGHTS DIMMED WHEN AIR COMPRESSOR ENGAGED AND THE CAR WAS AT LOW RPMS. RADIO THEN TURNED OFF LIGHTS WENT OUT, AND VEHICLE ALMOST STALLED. TURNED OFF AIR, RADIO AND LIGHTS (LUCKILY IT WAS SUNDOWN NOT DARK YET) AND PROCEEDED HOME. CONTACTED DEALERSHIP AND ONCE AGAIN PROBLEM WAS ATTRIBUTED TO DEFECTIVE BATTERY. BATTERY WAS REPLACED. IT SHOULD BE NOTED THAT HYUNDAI HAD INCREASED THE OUTPUT OF THE ALTERNATOR IN THE NEWER SANTA FE MODELS TO 110AMP OUTPUT. IT WOULD SEEM THAT THEY HAVE NOTED THE INADEQUATE OUTPUT OF THE EARLIER ALTERNATOR. I WOULD THINK THIS WOULD WARRANT AN INVESTIGATION INTO THE RETROFITTING OF EARLIER VEHICLES TO THE HIGHER OUTPUT ALTERNATOR. ALSO DISCUSSIONS WITH OTHER SANTA FE OWNERS THAT HAVE THIS MAKE AND MODEL HAVE IN SOME INSTANCES OBTAINED A REPLACEMENT FOR THE UPGRADED ALTERNATOR THROUGH WARRANTY.*AK

THE CAR WAS MAKING A GRINDING NOISE WHEN I SHIFTED FROM DRIVE TO PARK AND REVERSE. I TOOK IT BACK TO THE DEALERSHIP WHERE I HAD PURCHASED THE CAR THE DAY BEFORE AND WHILE IN PARK AT THE DEALERSHIP THE CAR'S STARTER CAUGHT ON FIRE AND WAS PUT OUT BY THE MECHANIC. NO INJURIES, THANK GOODNESS IT HAPPENED AT THE DEALERSHIP AND A FIRE EXTINQUISHER WAS AVAILABLE!!