2020 Kia Optima Engine

While driving, the vehicle experienced a sudden loss of engine power and entered limp mode. The check engine light began flashing and the vehicle had very limited acceleration, creating a safety concern when driving in traffic. The vehicle was towed to a Kia dealership for diagnosis. The dealer retrieved diagnostic trouble code P1326 (Knock Sensor Detection System – range/performance). During inspection, the dealer found metal contamination in the engine oil and oil control valves and advised that the engine has internal damage and requires replacement.

The contact owns a 2020 Kia Optima. The contact stated that while the vehicle was at a full stop, the red oil warning light illuminated; however, after driving off, the warning light disappeared. The vehicle was driven to an independent mechanic where it was diagnosed with an oil pump failure caused by low oil pressure while the vehicle was stationary, and the RPM was low. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 167,000.

I’ve been told by multiple Kia dealerships that my Kia needs a new engine however I am barely outside of their class action lawsuit so they are not willing to settle with me. They recently within the last two months came out with two recalls that did not fix the issue.

I took my vehicle to the dealership in Chantilly, VA on May 17, 2025. On July 24, 2025, I discovered that my vehicle had no oil, despite being approximately 4,000 miles away from my next scheduled oil change. I have video documentation confirming that there was no oil in the vehicle. The car was towed back to the dealership; however, no corrective action was taken. The dealership offered to perform a test, which I declined, as this issue did not exist before servicing my vehicle at their location. Additionally, no explanation or guidance regarding the oil was provided to me. I was only advised to pay for another oil change, or a 205 dollars to diagnose the car. Subsequently, I took the vehicle to Fairfax Auto Shop, where a dye test was conducted to check for oil leaks. While no leaks were found, they advised that the vehicle has an oil consumption issue. They recommended that I monitor and top off the oil every 1,000 miles and return for oil changes every 2–3 months.

Took to Kia for engine burning excessive oil. They determined the cylinder wall was scorched due to piston ring. The warranty people say it’s normal wear and tear and won’t honor the warranty. It’s still sitting in their engine bay because they want me to pay for the diagnostic which I don’t have. $4000 roughly for that but it needs a new engine. The warranty should be covering this! NEVER PAY FOR AN EXTENDED WARRANTY!!! They will not help you

Vechile is burning oil and knock sensor came on which indicated rod bearing. While driving the car lost power the check engine came on was abl to pull over and turned off the car. Did not drive it was tow home.

I got the car was running good week or 2 later I see the oil light flash after my oil change I go back top it off repeat the cycle almost weekly burning losts of oil then I get a code p1326 for a knock sensor same day car go into limp mode no power rpm won’t go over 2 car won’t go over 60-65 I park it go outside to take it to the dealership next day it ain’t start I haven’t had the car 4 months only have 138,000 miles

Same issue as the 2011-2019 recalled vehicles. (P1326)

Out of the blue I get a code for a misfire on cylinder one. Got in to head to work as normal and it was stalling and shaking so bad that I am scared to drive it. The next day the check engine light was on when I started it to seek out the issue. Car was manufactured in September 2019 but is the 2020 model year. I was told by a license mechanic this is related to an internal Kia engine issue. I contacted 800 333 4KIA to see if this was a known issue that they had a solution to. Of course I was told to self repair that my VIN is not covered under the recall. Can you tell me how Kia assumes that engine issues with the 2019s model year would have been fixed before the 2020 models were assembled? Sounds like my dream car is now my nightmare. 3rd White Kia Optima but I am likely leaving the Kia family if this requires a new engine.

Metal contamination found on VVT solenoid of 2020 kia optima 2.4L GDI engine. Firestone Autocare Confirmed metal debris in oiling system. Vehicle exhibits symptoms identical to prior theta II bearing recall SC172/SC200/SC227 but not covered under recall range.

My car has been burning oil rapidly. I’ve contacted kia over this issue and I have had several times where I have had to continually add oil. There is no leak. This is a known issue with kia motors across mechanics nationwide and there should be a recall issued. This has been at several shops and over the last few years. This motor should NOT be consuming 4 quarts of oil within 1000 miles after an oil change.

It is an oil burner and engine failed and went into limp mode less than 5 years when drove off dealership brand new.

Every since I bought my car back in 2020 I have to keep getting a oil change because my light keep coming on I was told by a mechanic the my Kia have a oil consumption problem

Car consumes a lot of oil. Approximately 5 quarts per week-faulty engine parts allowing oil to seep into the combustion chamber. The oil is then ignited along with the fuel, creating blue-tinted exhaust smoke. It is burning out spark plugs which is then wearing them out and almost caused car accident when car started sputtering and would not barely go once pressing gas. Has been inspected by KIA dealership. Was told engine needs to be replaced-warranty expired and nothing can be done. Car only 2 years old when this problem started and they will not replace.

The engine is burning through oil. I have already had the car checked for an oil leak. It is the engine. It's a 2020 however it does not have high mileage for the year that it is.

Burning oil, not wanting to accelerate properly on the freeway, kia has engine in previous years having the same issue, and these 2020 and they are not trying to fix them.

The contact owns a 2020 Kia Optima. The contact stated that the vehicle was experiencing excessive oil consumption. The vehicle was taken to Downtown Auto Care, where an oil consumption test was initiated. The mechanic added 5 quarts of oil to the engine and advised the contact to return after 3,000 miles. The contact stated that the low oil pressure warning light illuminated after 2,275 miles. The vehicle was urgently taken to Valvoline, where 3 quarts of oil were added to the engine. The dealer was notified of the failure and informed the contact that the VIN was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 51,072.

Engine failure do to excessive oil consumption. I do have records. Not able to file now. Please contact if needed Thank you

engine's knock sensor

UNKNOWN, Engine excessively burns oil and is now seized. Kia used the same engine in this car as they did in the 2016-19 Models which were recalled for engine failure, however mine was not included. 2.4 Theda Engine.

Oil pan developed stress crack below and along both sides of the oil pan drain plug All components are in place and there are no signs of road damage or damage do to obstacles being hit Leak started slowly and progressively became worse Returned car to have plug checked but no report back of any problem and it was documented on service order

The car drives slowly and sputters because oil is burning out quickly. I have to replenish oil continuously.

My engine is burning lg amounts of oil. There has been a lawsuit regarding the same issues with Kia engines (specifically up to 2019 Optimas). The Theta 2 engine lawsuit is regarding excessive oil consumption/burning, knock sensor issues, and deeper engine issues. This has been an ongoing issue for me and is ultimately affecting my engine. Kia will not cover the defects or repair expenses despite knowing the concerns with prior Kia Optima engines.

Oil consumption has rapidly been increasing causing the loss of several quarts of oil. Inspection by service center confirmed this is a known Kia issue and recommended a flush to help combat some of the issue. Service center did note that this issue would not fix the problem, but put off needing to replace the engine. Oil light was not flashing on the dash unless coming to a quick stop, but then would disappear. The value of these cars has resulted in quite a bit of negative equity for folks due to the theft issue. Now add on a fear of blowing an engine cause your vehicle is burning through oil like no tomorrow.

Dealing with sudden excessive oil consumption at 130,000 miles. Had an oil change about 2,000 miles ago and oil sensor has been going off after 1,500-2,000 miles driven. Mechanic put 3 more quarts in and a week and a half later oil sensor is going off again indicating low oil. Mechanic confined this has been a frequent problem with this engine and insists piston rings are faulty & will eventually need engine replacement.