2005 Nissan Titan Engine

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE CONTACT HEARD AN ABNORMAL TICKING SOUND. THE CONTACT STATED THAT THE TICKING SOUND WOULD CEASE AFTER THE ENGINE BECAME WARM. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR THE FAILURE. THE DEALER ADVISED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE DEALER DID NOT STATE WHAT CAUSED THE MANIFOLD TO CRACK. THE CONTACT REPLACED THE EXHAUST MANIFOLD. THE FAILURE MILEAGE WAS 83,000.

BOTH EXHAUST MANIFOLDS HAVE GONE BAD DUE TO CRACKS AND THUS HAVE EXHAUST LEAKS. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THE VEHICLE WAS BEING SERVICED BY AN AUTHORIZED DEALER FOR ROUTINE MAINTENANCE, WHEN HE WAS INFORMED THAT THE EXHAUST MANIFOLD WAS CRACKED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT BOTH EXHAUST MANIFOLDS CRACKED AND THE CONTACT NOTICED THAT THE VEHICLE HAD BECOME VERY LOUD. THERE WAS ALSO A FUEL ODOR INSIDE WHICH ALERTED HER TO A POTENTIAL FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE MANIFOLDS WERE CRACKED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT A LATER DATE. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 100,000. THE FAILURE MILEAGE WAS APPROXIMATELY 74,000.

CRACKED EXHAUST MANIFOLDS ON BOTH SIDES OF V8 ENGINE AS DIAGNOSED BY NISSAN DEALER. RESULT -- WILL LEAK RAW EXHAUST GASES INTO PASSENGER COMPARTMENT AND INTO ATMOSPHERE. INVESTIGATION REVEALS CRACKED MANIFOLDS TO BE A HUGE PROBLEM FOR NISSAN TITANS AND LARGE NUMBERS OF TITANS ARE AFFECTED. NISSAN EMISSION WARRANTY ONLY COVERS 8YRS/80,000 MILES. BUT SINCE THESE EXHAUST MANIFOLDS ARE CLEARLY DEFECTIVE DUE TO IMPROPER DESIGN AND POSE A SERIOUS SAFETY THREAT AND EMISSIONS PROBLEM THEY SHOULD BE REPLACED AT NISSAN'S EXPENSE REGARDLESS OF VEHICLE AGE OR MILEAGE. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, A NOISE WAS HEARD COMING FROM UNDER THE HOOD. THE VEHICLE WAS MANEUVERED TO THE SHOULDER OF THE ROAD AND THE CONTACT NOTICED EXHAUST FUMES WERE LEAKING FROM THE ENGINE MANIFOLD INSTEAD OF THE TAIL PIPE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 66,000. THE VIN WAS UNKNOWN.

TL* THE CONTACT OWNS 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WAS A CRACK IN THE EXHAUST MANIFOLD AND THE VEHICLE WOULD MAKE A POPPING SOUND WHEN THE ENGINE WAS ON. THE EXHAUST WAS ALSO LEAKING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE MANIFOLD WAS REPLACED. THE MANUFACTURER WAS NOTIFIED, BUT DID NOT ASSIST WITH THE REPAIRS. THE FAILURE MILEAGE WAS 100,000 AND 200,000.

TL* THE CONTACT OWNS A 20O5 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 25 MPH AND ACCELERATING FROM A COMPLETE STOP, THE ENGINE STALLED WITHOUT WARNING. AFTER WAITING A FEW MOMENTS THE ENGINE WAS RESTARTED. THE FAILURE RECURRED ON A DIFFERENT OCCASION AND THE ENGINE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THEY REPLACED THE RELAY SWITCH AT THE OWNER'S EXPENSE. A RECALL NOTIFICATION WAS RECEIVED TWO YEARS LATER AFTER THE REPAIR. THE RECALL WAS ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 10V517000 (ENGINE AND ENGINE COOLING). THE CONTACT PLANNED TO NOTIFY THE MANUFACTURER TO VERIFY WHETHER THE VEHICLE WAS INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT SHE COULD HEAR A LOUD NOISE COMING FROM THE ENGINE WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THERE WAS A LEAK IN THE EXHAUST SYSTEM. AS A RESULT, THE EXHAUST SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 90,000.

DRIVERSIDE EXHAUST MANIFOLD CRACKED APPROX TWO WEEKS AFTER PASSENGER SIDE EXHAUST MANIFOLD REPLACED DUE TO CRACK. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT A TICKING SOUND WAS HEARD FROM THE VEHICLE DURING STARTUP. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE MECHANIC CONFIRMED THAT THE RIGHT AND LEFT MANIFOLD WAS CRACKED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 90,000.

ABOUT TWO YEARS AGO I STARTED HEARING A TICKING NOISE ON MY 2005 NISSAN TITAN PU AT START UP. COULDN'T FOR THE LIFE OF ME FIGURE OUT WHAT IT WAS UNTIL NISSAN SENT ME AN OWNER NOTIFICATION CARD ABOUT CRACKS IN THE EXHAUST MANIFOLDS. THEN IT DAWNED ON ME WHAT THAT TICKING NOISE WAS WHEN COLD START UP TOOK PLACE. I HAD THE VEHICLE RECENTLY IN THE SHOP FOR 2 OTHER RECALLS AND MENTIONED THIS ALONG WITH THE NOTICE I RECEIVED ABOUT THIS PROBLEM FROM NISSAN. THE SERVICE MANAGER SAID THEY WOULD LOOK INTO IT BUT WAS CONCERNED BECAUSE I HAD 83,400 MILES ON THE TRUCK AND WARRANTY ISSUES ONLY WOULD FIX THIS UP TO 80,000 MILES. I HAVEN'T EVER HAD A EXHAUST CRACK ON ANY VEHICLE THAT I HAVE OWNED SINCE 1972 AND HAD SOME OF THESE VEHICLE TO UPWARD OF 250,000 MILES. WHY WON'T NISSAN DO SOMETHING ABOUT THIS TO FIX THIS ISSUE BECAUSE IT LOOKS LIKE IT IS ALL OF THEM THAT CRACK. SEEMS TO ME FOR SAFETY ISSUES AND EXHAUST FUMES THAT SHOULD BE ROUTED TO THE REAR OF THE VEHICLE ARE NOW BEING PUSHED INTO THE ENGINE COMPARTMENT AND NOT EVEN GETTING TO THE CATALYTIC CONVERTER. I'M VERY DISAPPOINTED IN NISSAN FOR THE ABSENCE OF HELP IN THIS ISSUE AND A SERIOUS ONE AT THAT. THIS SHOULD BE A RECALL AND OF ALL THE WATCHDOG AREAS OF OUR LIFE WHERE IS THE EPA ON THIS ONE. *TR

MY EXHAUST MANIFOLD/ CAT HAS FAILED. THERE IS A CRACK IN MY EXHAUST MANIFOLD AND OVER WARRANTY 15K. I HAVE NOTICE MPG LOSS AND GASES ENTERING MY CABIN WHEN I'M AT A STOP LIGHT AND MY WINDOW IS DOWN. I'M A FATHER OF 3 AND WORRIED FOR MY CHILDREN SAFETY. PASSENGER IS CRACKED AND WORRIED THAT THE DRIVERS IS GOING TO GO SOON. THE DEALERSHIP WILL NOT COVER UNDER WARRANTY. THIS WILL COST ME 600 PER SIDE + 600 FOR LABOR WHICH BRINGS THE TOTAL TO 1800+TAX. I'M APART OF A NISSAN CLUB/FORUM AND THIS IS A PROBLEM NUMEROUS PEOPLE ARE HAVING, 50+ IN CALIFORNIA. SOME PEOPLE HAVE TO GO AFTERMARKET OR EVEN PASS IT ILLEGALLY THROUGH BLACK MARKET CHANNELS. NISSAN IS WELL AWARE OF THIS PROBLEM AND RELEASED A REVISED VERSION WHICH STILL HAVE THE SAME PROBLEM. NISSAN IS ROBBING THEIR CUSTOMERS AND NEED TO BE BROUGHT TO JUSTICE. THEY SHOULD BE RESPONSIBLE UNDER THE EMISSIONS LAW AND FOR PUTTING OUT A KNOWN FAULTY PART. I DON'T KNOW WHAT TO DO I HAVE MANY FRIENDS IN OTHER STATES THAT ARE ON THEIR 2ND SET OR GOING ON THEIR 3RD SET. THIS SHOULD BE ADDRESSED FOR THE SAFETY OF PEOPLE AND THE EARTH [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

CRACK EXHAUST MANIFOLD/CATALYTIC CONVERTER IS ONE PIECE. *TR

TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHEN THE CONTACT TURNED ON THE IGNITION, THE ENGINE BEGAN TREMBLING AND TURNED OFF. THE CONTACT WAS UNABLE TO TURN IT BACK ON. THE VEHICLE WAS TOWED TO AN AUTHORIZE DEALER WHERE IT WAS STATIONED. THE TECHNICIAN STATED THAT THE BATTERY AND IPDM ASSEMBLY NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED THAT HIS VEHICLE WAS NOT INCLUDED IN RECALL 10V517000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

EXHAUST MANIFOLD LEAKING FOR THE SECOND TIME. BOTH SIDES WERE REPLACED UNDER WARRANTY AND THEN 1 YEAR AND 8 DAYS LATER I WAS TOLD THEY WERE LEAKING AGAIN. NISSAN REFUSES TO COVER UNDER WARRANTY. EXHAUST MANIFOLD LEAKING ALLOWS EXHAUST FUMES TO NOT BE VENTED CORRECTLY AND THE FUMES CAN COME INTO THE CABIN OF THE VEHICLE. I HAVE SPOKEN WITH THE DEALERSHIP AND ALSO FILED A REQUEST WITH THE MAIN NISSAN CORPORATION. *TR

BOTH MY EXHAUST MANIFOLDS HAVE CRACKED ONE HAS BEEN REPLACED BY THE DEALER UNDER WARRANTY. THE OTHER ONE IS NOW CRACKED AND IS OUT OF WARRANTY. *TR

2005 NISSAN TITAN LEAKING EXHAUST MANIFOLDS. THE EXHAUST MANIFOLDS ARE CRACKED AND LEAKING FUMES INTO THE CAB OF MY TRUCK. I CAN ALSO HEAR A TICKING NOISE AND ENGINE PERFORMANCE IS SUFFERING. *TR

2005 NISSAN TITAN EXHAUST FLANGE AT EXHAUST TIP FAILURE THIS CAUSED THE REAR WIRE HARNESS TO BURN UP AND THE REAR ABS TO FAIL. VERY DANGEROUS SITUATION. *TR

THE REAR EXHAUST FLANGE BROKE CAUSING THE EXHAUST PIPE TO AIM INTO THE UNDERSIDE OF THE TRUCK BED. THIS HAS CAUSE MELTING PLASTIC, REAR TAILLIGHT FAILURE AND PAINT TO DELAMINATE FROM THE REAR FENDER. *TR

FAILURE OF EXHAUST FLANGE IN EXHAUST OF 2005 NISSAN TITAN. *TR

2005 NISSAN TITAN LE HAD AN EXHAUST TAILPIPE SEPARATION AT A WELD. THE HANGER THAN HOLDS THE TAILPIPE IS DESIGNED WRONG. THE WEIGHT OF THE PIPE CAUSES THE EXHAUST GASES UP INTO THE PASSENGER SIDE REAR FENDER MELTING WIRES, PLASTIC, AND POTENTIALLY ANYTHING IN THE CARGO BOX AREA (BED LINER MELTED). THE TAILPIPE WAS NOT DAMAGED IN ANY WAY PRIOR TO THE INCIDENT. I HAVE FOUND MANY INTERNET FORUMS WITH THE SAME PROBLEM OCCURRING TO OTHER TITAN OWNERS. I AM CONFIDENT IF I WOULD NOT HAVE NOTICED THE PROBLEM EARLIER AND HAD COMBUSTIBLES IN THE CARGO AREA, THE VEHICLE WOULD HAVE CAUGHT FIRE. MY RIGHT TURN SIGNAL DID NOT WORK AND THAT IS WHAT MADE ME LOOK FOR THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE ATTEMPTING TO START THE VEHICLE, THE VEHICLE WAS HESITANT TO START. THE DEALER PERFORMED A DIAGNOSTIC ON THE VEHICLE AND FOUND THAT THE INTELLIGENT POWER DISTRIBUTION MODEL (IPDM) WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 95,403.

MY 2005 NISSAN TITAN HAS TWO CRACKED EXHAUST MANIFOLDS. THEY ARE CRACKED INTO TWO PIECES AND ARE ALLOWING CARBON MONIXIDE TO ESCAPE FROM THE EXHAUST SYSTEM ADJACENT TO THE CAB OF THE TRUCK. THIS IS A POTENTIALLY LETHAL FAILURE DUE TO CO POISIONING. NISSAN HAS BEEN CONTACTED AND WILL NOT ASSIST WITH REPAIRS, EVEN THOUGH THERE HAVE BEEN HUNDREDS OF SIMILAR REPORTED CASES. MY VEHICLE IS OUT OF THE WARRANTY PERIOD AND I UNDERSTAND NISSAN'S RELUCTANCE, FINANCIALLY, TO REPAIR THE FAILURE. HOWEVER, DUE TO THE POTENTIALLY DANGEROUS NATURE OF THE DESIGNED FLAW THAT CAUSED THE FAILURE I BELIEVE THAT A RECALL IS JUSTIFIED. I AM VERY WILLING TO TAKE THE STEPS REQUIRED TO INITIATE A RECALL, BUT I AM NOT SURE HOW TO PROCEED.

EMISSIONS PROBLEM LEADING TO CATALYTIC CONVERTER FAILURE DUE TO CRACKING EXHAUST MANIFOLD OF MY 2005 NISSAN TITAN. *TR